PERFECT EQUIPMENT COMPANY LLC -- KNX/PERFICURE CHEMICAL ACTIVATOR CEMENT
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CJWQW
MSDS NAME: KNX/PERFICURE CHEMICAL ACTIVATOR CEMENT
Responsible Party
Name: PERFECT EQUIPMENT COMPANY LLC
Address: 1435 HEIL QUAKER BOULEVARD
City: LA VERGNE TN 37086
Info Phone: 615-641-1950
Emergency Phone Number: 615-641-1950
Preparer's Name: R. WEACHAUPT
Chemtrec IND/Phone: (800)424-9300
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: PERFECT EQUIPMENT COMPANY LLC
Address: 1435 HEIL QUAKER BOULEVARD
City: LA VERGNE TN 37086
Phone: 615-641-1950
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Cas: 64742-89-8
Name: LIGHT ALIPHATIC SOLVENT NAPHTHA (PETROLEUM); (NAPHTHA (PETROLEUM
DISTILLATE))
> Wt: 90.
Other REC Limits: N/K (FP N)
OSHA PEL: 400 PPM
OSHA STEL: N/K (FP N)
ACGIH TLV: 400 PPM
ACGIH STEL: N/K (FP N)
------------------------------
Cas: 108-88-3
RTECS #: XS5250000
Name: TOLUENE
< Wt: 5.
Other REC Limits: N/K (FP N)
OSHA PEL: see Table Z-2
OSHA STEL: 150 PPM
ACGIH TLV: 188 MG/M3;50 PPM
ACGIH STEL: 150 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 1314-13-2
RTECS #: ZH4810000
Name: ZINC OXIDE (ZNO); (ZINC OXIDE)
< Wt: 2.
Other REC Limits: N/K (FP N)
OSHA PEL: 15 MG/M3
OSHA STEL: N/K (FP N)
ACGIH TLV: 10 MG/M3
ACGIH STEL: N/K (FP N)
------------------------------
Cas: 5459-93-8
RTECS #: GX1225000
Name: N-ETHYLCYCLOHEXYLAMINE
< Wt: 1.
Other REC Limits: N/K (FP N)
OSHA PEL: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
ACGIH STEL: N/K (FP N)
------------------------------
Cas: 136-23-2
RTECS #: ZH0175000
Name: ZINC BIS(DIBUTYLDITHIOCARBAMATO)-; (ZINC D-N-BUTYLDITHIOCARBAMATE)
< Wt: 1.
Other REC Limits: N/K (FP N)
OSHA PEL: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
ACGIH STEL: N/K (FP N)
------------------------------
Cas: 137-30-4
RTECS #: ZH0525000
Name: ZINC DIMETHYLDITHIOCARBAMATE
< Wt: 1.
Other REC Limits: N/K (FP N)
OSHA PEL: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
ACGIH STEL: N/K (FP N)
------------------------------
Cas: 71-43-2
RTECS #: CY1400000
Name: BENZENE
% Wt: < 10 PPM
Other REC Limits: N/K (FP N)
OSHA PEL: see 1910.1028
OSHA STEL: N/K (FP N)
ACGIH TLV: 32 MG/M3;10 PPM
ACGIH STEL: N/K (FP N)
EPA Rpt Qty: 10 LBS
DOT Rpt Qty: 10 LBS
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE & CHRONIC: EXCESSIVE EXPOS TO AIRBORNE SOLV VAPS
MAY CAUSE EYE DISCOMFORT, EYE & SKIN DERM, NOSE, THROAT, MOUTH &
DIGESTIVE TRACT IRRIT, NERVOUS SYSTEM DEPRESSION (DROWSINESS, DIZZINESS, LOSS
OF COORDINATION) & IRREG HEART BEATS. SWALLOWING/MOVIT & SUBSEQUENT
ASPIRATION INTO LUNGS MAY LEAD TO CHEM PNEUMONIA & PULM EDEMA WHICH IS A
POTENTIALLY FATAL CONDITION. MISUSE/OTHER MASSIVE EXPOS TO TO LUENE MAY CAUSE
MULTIPLE ORGAN DAMAGE &/OR DEATH. TOLUENE & BENZENE APPEAR ON THE
NAVY OCCUP CHEM REPRO HAZARDS LIST. SEEK CONSULTATION FROM APPROP HEALTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HANDLING &
EXPOSURE INFO (FP N).
Explanation Of Carcinogenicity: THERE IS EVIDENCE TO SUGGEST CARCINOGENIC
ACTIVITY WHEN EXPOSURE IS CONTROLLED BELOW THE PERMISSIBLE EXPOSURE LIMIT
(PEL).
Signs And Symptions Of Overexposure: EXCESSIVE INHALATION OF THE SOLVENT VAPORS
OR INGESTION MAY CAUSE IRREGULAR HEART BEATS, DIZZINESS, LIGHT-HEADEDNESS,
HEADACHE, NAUSEA, LOSS OF COORDINATION AND EQUILIBRIUM, UNCONSCIOUSNESS OR
IRRITAT ION OF THE NOSE, THROAT, AND DIGESTIVE TRACT. EYE AND SKIN CONTACT
MAY CAUSE IRRITATION. PROLONGED OR REPEATED LIQUID CONTACT CAN RESULT IN
DEFATTING AND DRYING OF THE SKIN WHICH MAY RESULT IN DERMATI TIS.
Medical Cond Aggravated By Exposure: EXCESS INHAL OF SOLV VAPS MAY CAUSE INCRD
BRTHG DFCLTY FOR PERS W/IMPAIRED LUNG FUNC/ASTHMA-LIKE CNDTNS. PRE-EXISTING
HEART DISORDERS MAY BE AGGRAVATED & SKIN DISORDERS MAY BE MORE
SUSCEPTIBLE TO IRRIT.
First Aid: INHALATION: REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION OR
OXYGEN IF NEEDED. EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN:
REMOVE CONTAMINATED CLOTHING. INGESTION: IF VICTIM IS CONSCIOUS AND ALERT,
DRINK LARGE QUANTITIES OF WATER. DO NOT INDUCE VOMITING. IF VOMITING OCCURS,
HOLD HEAD BELOW HIPS TO PREVENT ASPIRATION INTO LUNGS.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EVACUATE AREA & PROVIDE MAX VENT. PROTECT FROM
IGNIT. DANGER! EXTREMELY FLAMM. WEAR APPROP NIOSH APPRVD RESP & PROT
CLTHG. HNDLG EQUIP MUST BE GROUNDED TO PVNT SPKG. DIKE AREA TO CONTAIN LGE
SPILLS. S OAK UP RESIDUE W/ABSORB SUCH AS CLAY/OTHER SUITABLE MATL. PLACE IN
NON-LEAKING CONTRS FOR PROPER DISP. DO NOT FLUSH TO SEWER. THIS PROD CONTAINS
APPROX 5% TOLUENE (CAS # 108-88-3). (SUP DAT)
Waste Disposal Methods: DISPOSE OF WASTE CONTAINER IN A PERMITTED HAZARDOUS
WASTE MANAGEMENT FACILITY IN ACCORDANCE WITH ALL GOVERNMENTAL REGULATIONS.
RCRA/EPA HAZARDOUS WASTE NUMBERS ARE IGNITABLE - D001, AND HAZARDOUS - D0 18.
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS (FP N).
Handling And Storage Precautions: DO NOT USE IN POORLY VENTILATED AREA W/OUT
PROPER RESP PROT. STORE IN CLSD PROPERLY LABELED CONTRS. AVOID CONTAM OF
WATER SUPPLIES. FLAMM IS A SERIOUS HAZ. VAPS MAY ACCUM & TRAVEL TO IGNIT
SOURCES DIS TANT FROM HNDLG SITE. EXTING PILOT LIGHTS, CIGARETTES & OTHER
SOURCES OF IGNIT PRIOR TO USE.
Other Precautions: DO NOT BREATHE VAPORS. LIMIT EXPOSURE BELOW PEL. AVOID
CONTACT WITH EYES. AVOID PROLONGED OR REPEATED CONTACT WITH SKIN. DO NOT
SWALLOW. DO NOT EAT, DRINK OR SMOKE IN WORK AREAS. DO NOT CUT, WELD, DRI LL,
GRIND OR EXPOSE EMPTY CONTAINERS TO HEAT. THEY MAY CONTAIN EXPLOSIVE VAPORS.
CTC STORAGE CODE: F .
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point: =-15.C, 5.F
Lower Limits: 1%
Upper Limits: 8%
Extinguishing Media: DRY CHEMICALS, CARBON DIOXIDE, FOAM OR WATER FOG. DO NOT
USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE REIGNITED ON
SURFACE OF WATER.
Fire Fighting Procedures: WEAR NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT (FP N). DANGER. EXTREMELY FLAMMABLE.
CLEAR FIRE AREA OF UNPROTECTED PERSONNEL AND ISOLATE. COOL EXPOSED CONTAINERS
WITH WATER SPRAY OR FOG.
Unusual Fire/Explosion Hazard: VAPORS CONCENTRATED IN A CONFINED OR POORLY
VENTILATED AREA CAN BE IGNITED UPON CONTACT WITH A HIGH ENERGY SPARK, FLAME
OR HIGH INTENSITY SOURCE OF HEAT. THIS CAN OCCUR AT CONCENTRATIONS RANGING
BETWE EN 1-8% BY VOLUME. NFCC CLASSIFICATION: 1B.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS FOR
EMERGENCY.
Ventilation: LOCAL EXHAUST: NOT NORMALLY REQUIRED. MECHANICAL (GENERAL):
RECOMMENDED. SPECIAL: NONE. OTHER: ADEQUATE TO MAINTAIN VAPOR CONCENTRATION
BELOW TLV.
Protective Gloves: FOR FREQUENT OR PROLONGED CONTACT, USE VITON, NITRILE,
BUTYL/NEOPRENE GLOVES.
Eye Protection: ANSI APPROVED CHEMICAL WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPROVED EMERGENCY EYEWASH AND DELUGE SHOWER
(FP N). NO SPECIAL PROTECTIVE CLOTHING NEEDED. HOWEVER, FOR FREQUENT OR
PROLONGED CONTACT, USE BOOTS AND APRON DEPENDING UPON THE SEVERITY OF
EXPOSURE.
Work Hygienic Practices: REASONABLE CARE AND CAUTION. NORMALLY ACCEPTED
PERSONAL HYGIENE.
Supplemental Safety and Health: SPILL PROC: IT IS SUBJECT TO RELEASE REPORTING
UNDER SECTION 313 OF SARA TITLE III. REPORTABLE QTY IS 20,000 LBS. RELEASES
TO AIR, LAND/WATER WHICH EXCEED RQ MUST BE REPORTED TO NATIONAL RESPONSE CTR
(800) 424-8802.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: >90.6C, 195.F
B.P. Text: 195F - 206F
Vapor Pres: 119 MM HG @ 100F (38C)
Vapor Density: 3.5(AIR=1)
Spec Gravity: 0.70 @ 60F (16C)(WATER=1)
Evaporation Rate & Reference: 2.8 (BUTYL ACETATE=1)
Solubility in Water: NEGLIGIBLE (LESS THAN 1%)
Appearance and Odor: PALE YELLOW LIQUID, WITH RUBBER SOLVENT ODOR.
Percent Volatiles by Volume: 95
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID OPEN FLAMES, HOT GLOWING SURFACES AND HIGH
ENERGY SPARKS. PREVENT VAPOR ACCUMULATION.
Materials To Avoid: LIQUID OXYGEN AND OTHER STRONG OXIDIZING MATERIALS.
Hazardous Decomposition Products: THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE AND UNIDENTIFIED ORGANIC COMPOUNDS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE.
=======================================================
MSDS Transport Information
=======================================================
Transport Information: DOT HAZARD CLASS: ADHESIVES FLAMMABLE (CLASS 3). DOT ID
NUMBER: UN1133, PACKING GROUP II.
=======================================================
Regulatory Information
=======================================================
Federal Regulatory Information: MATERIAL SAFETY DATA SHEET MAY BE USED TO
COMPLY WITH OSHA'S HAZARD COMMUNICATION STANDARD, 29 CFR 1910.1200. STANDARD
MUST BE CONSULTED FOR SPECIFIC REQUIREMENTS. CANADIAN W: B2 - FLAMMABLE LIQUI
D, D2B - OTHER TOXIC EFFECTS.
State Regulatory Information: THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE
STATE OF CALIFORNIA TO CAUSE CANCER AND/OR REPRODUCTIVE TOXICITY.
=======================================================
Other Information
=======================================================
Other Information: THIS IS A NATURAL RUBBER/SOLVENT SOLUTION. IT HAS NOT BEEN
EVALUATED AS A WHOLE. CHEMICAL INGREDIENTS ARE BLENDED IN THE RUBBER POLYMER.
POTENTIAL FOR HAZARDOUS EXPOSURE AS SHIPPED IS MINIMAL PROVIDED EXPOSURE IS
LIMITED BELOW THE OSHA PEL. RATINGS: HEALTH = 3; FLAMMABILITY = 4;
REACTIVITY = 0; PERSONAL PROTECTION = C. NFPA RATINGS: HEALTH = 3;
FLAMMABILITY = 4; REACTIVITY = 0; SPECIAL HAZARD = -.
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: KNX/PERFICURE CHEMICAL ACTIVATOR CEMENT
Company: PERFECT EQUIPMENT COMPANY LLC
Street: 1435 HEIL QUAKER BOULEVARD
City: LA VERGNE TN
Zipcode: 37086
Health Emergency Phone: 615-641-1950
Label Required IND: Y
Date Of Label Review: 12/17/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE! ACUTE: EXCESSIVE INHALATION OF THE SOLVENT
VAPORS OR INGESTION MAY CAUSE IRREGULAR HEATE BEATS, DIZZINESS,
LIGHT-HEADEDNESS, HEADACHE, NAUSEA, LOSS OF COORDINATION AND EQUILIBRIUM,
UNCONS CIOUSNESS OR IRRITATION OF THE NOSE, THROAT, AND DIGESTIVE TRACT. EYE
AND SKIN CONTACT MAY CAUSE IRRITATION . CHRONIC: PROLONGED OR REPEATED
LIQUID CONTACT CAN RESULT IN DEFATTING AND DRYING OF THE SKIN WHICH MAY
RESULT IN DERMATITIS. TOLUENE APPEARS ON NAVY OCCUPATIONAL CHEMICAL
REPRODUCTIVE HAZARDS LIST (FP N).
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|
| ALL PAGES On Chemical Property IN THIS GROUP
| | NAME | CAS |
|
MC-236 CLASS A BASE
| |
|
MC-236 ACCELERATOR
| |
|
STAINLESS STEEL BARE WIRE, AWS 308.
| 7439-89-6
7440-47-3
7440-02-0
7439-96-5
7440-21-3
7439-98-7
7440-44-0
7723-14-0
7704-34-9
7727-37-9
7440-50-8
7440-03-1 |
|
CON A SEPHAROSE 4B,17-0440-02
| 64-17-5 |
|
VCI-238 AEROSOL
| |
|
KFS1003 5958-36440 FLAT GRAY
| 1330-20-7
78-93-3
110-43-0
141-78-6
123-86-4
108-65-6
763-69-9 |
|
URANYL ACETATE, 21447
| 541-09-3
7440-61-1 |
|
KNX/PERFICURE CHEMICAL ACTIVATOR CEMENT
| 64742-89-8
108-88-3
1314-13-2
5459-93-8
136-23-2
137-30-4
71-43-2 |
|
LS-70 MARINE GREASE
| |
|
SILVER PROTEIN MILD, S03380
| 9015-51-4 |
|
28771, ULTRA-HIDE CLEAR SEALANT, 13PL513
| |
|
CON A SEPHAROSE 4B,17-0440-03
| 64-17-5 |
|
MK 74 PROPELLANT
| 1317-36-8
119-75-5
55-63-0
9004-70-0 |
|
SAFE D SCALE INDUSTRIAL DESCALER
| |
|
SAFE D SCALE PLUS DESCALER
| |
|
CON A SEPHAROSE 4B,17-0440-04
| 64-17-5 |
|
BLASTICIDIN S HYDROCHLORIDE, 150477
| 2079-00-7 |
|
ISOPROPYL-BETA-D-THIOGALACTOPYRANOSIDE, 102101
| 367-93-1 |
|
TRIS-BUFFERED SALINE W/TWEEN 20 (TBST) 10X CONCENTRATE,S3306
| 7647-14-5
77-86-1
9005-64-5 |
|
BENZALKONIUM CHLORIDE, 150430
| 8001-54-5 |
|
DUOPRIME OIL 70
| 8042-47-5 |
|
SODIUM LAURYL SULFATE, STOCK BUFFER, 46-0004
| 151-21-3 |
|
SODIUM CHLORIDE, HEPES SALINE, 46-0389
| 7647-14-5 |
|
SODIUM ACETATE, 46-0043
| 6131-90-4 |
|
743410, OLIVE DRAB 34068, ENAMEL: LUSTERLESS, QUICK(SUP DAT)
| 64742-89-8
1330-20-7
78-83-1
136-52-7
123-86-4
110-19-0
14808-60-7
14464-46-1
14807-96-6
1333-86-4 |
|
POLYTRITICUM, AG2-215-6
| 60961-73-1
119553-67-2
26247-20-1
24980-41-4
34346-01-5
25322-68-3
56-81-5
13463-67-7
7732-18-5
108-31-6
80-43-3 |
|
NYALIC
| 64742-94-5 |
|
APPLICATION FLUID
| |
|
AC-236 CLASS A BASE
| |
|
AC-236 ACCELERATOR
| |
|
DEX-O-TEX CF-M RESIN B COMP
| |
|
DYNASOLVE 185, J008
| 872-50-4
122-99-6 |
|
NONENYL SUCCINIC ANHYDRIDE MODIFIED
| |
|
SUCROSE, 102978
| 57-50-1 |
|
SUCROSE, 104713
| 57-50-1 |
|
SUCROSE, 152584
| 57-50-1 |
|
SUCROSE, 190271
| 57-50-1 |
|
SUCROSE, 194018
| 57-50-1 |
|
SUCROSE, 194747
| 57-50-1 |
|
SUCROSE, 195509
| 57-50-1 |
|
SUCROSE, 812000
| 57-50-1 |
|
SUCROSE, 812013
| 57-50-1 |
|
SUCROSE, 812021
| 57-50-1 |
|
SUCROSE, 821712
| 57-50-1 |
|
SUCROSE, 821713
| 57-50-1 |
|
SUCROSE, 821721
| 57-50-1 |
|
SUCROSE, 821730
| 57-50-1 |
|
SUCROSE, 902978
| 57-50-1 |
|
SUCROSE, 904713
| 57-50-1 |
|
SH 200-10 CS EG
| 63148-62-9 |
|
|