LORD CORP CHEMICAL PRODUCTS GR -- TYRITE 7650
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BTYGX
MSDS NAME: TYRITE 7650
Responsible Party
Name: LORD CORP CHEMICAL PRODUCTS GROUP
Address: 2000 W GRANDVIEW BLVD
Box: 10038
City: ERIE PA 16514-0036
Info Phone: 814-868-3611
Emergency Phone Number: 814-763-2345
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: LORD CORPORATION, CHEMICAL PRODUCTS DIVISION
Address: 2000 WEST GRANDVIEW BLVD
City: ERIE PA 16514-0038
Phone: 814-868-3611
=======================================================
Ingredients
=======================================================
Name: ING 6: FLAME-CUT AN EMPTY DRUM.
-----------------------------
Name: VENT: ALL APPLICATION AREAS SHOULD BE VENTILATED I/A/W OSHA REG 29CFR
PART 1910.94. CAUTION: SOLV VAPS ARE
-----------------------------
Name: ING 8: HEAVIER THAN AIR AND COLLECT IN LOWER LEVELS OF THE WORK AREA.
SUFFICIENT VENT (USING EXPLO PROOF EQUIP)
-----------------------------
Name: ING 9: SHOULD BE PROVIDED TO PREVENT FLAMMABLE VAPOR/AIR MIXTURES FROM
ACCUMULATING.
-----------------------------
Name: WORK HYGIENE: OR BEVERAGES SHOULD NOT BE CONSUMED ANYWHERE THIS PRODUCT
IS HANDLED OR STORED. WASH THORO AFTER HANDLING.
-----------------------------
Cas: 101-68-8
RTECS #: NQ9350000
Name: ISOCYANIC ACID, METHYLENEDI-P-PHENYLENE ESTER; (METHYLENE BISPHENYL
ISOCYANATE (MDI)) (SARA III). VP: 0.05/20C
% Wt: 5
OSHA PEL: 0.02 PPM, C
ACGIH TLV: 0.005 PPM
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 78-93-3
RTECS #: EL6475000
Name: METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III). VP: 70/20C LEL: 2%
% Wt: 35
OSHA PEL: 200 PPM;300 STEL
ACGIH TLV: 200 PPM;300 STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 108-88-3
RTECS #: XS5250000
Name: TOLUENE; (TOLUOL) (SARA III). VP: 22/20C. LEL: 1.3%
% Wt: 5
OSHA PEL: 200 PPM;150 STEL
ACGIH TLV: 50 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Name: SPILL PROC: FRICTIONAL SPARKS). VENT AREA W/EXPLO-PROOF DRIVEN EQUIP,
BECAUSE OF THE POSSIBLE PRESENCE OF FLAMM VAPS.
-----------------------------
Name: OTHER PREC: RESP REACTION. CAN CAUSE ALLERGIC SKIN REACTION. PREVENT
PROLONGED OR REPEATED BRTHG OF VAP OR SPRAY
-----------------------------
Name: ING 5: MISTS. DO NOT HANDLE UNTIL THE MFR'S SAFETY PRECAUTIONS HAVE BEEN
READ AND UNDERSTOOD. DO NOT WELD OR
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: POSSIBLE IRRIT OF RESP SYS CAUSING A VARIETY OF
SYMPTOMS SUCH AS DRYNESS OF THE THROAT, TIGHTNESS OF THE CHEST, AND SHORTNESS
OF BREATH. ANESTHETIC. RESP IRRIT. SKIN IRRIT. EYE IRRIT. MAY CAUSE CNS
DEPRESS CHARAC BY THE FOLLOWING PROGRESSIVE STEPS: HDCH, DIZZ, STAG GAIT,
CONFUSION, UNCON & COMA.(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:CHRONIC: MAY CAUSE SENSIT. MAY
CAUSE DERM. MAY CAUSE RESP SENSIT. MAY CAUSE LIVER OR KIDNEY DMG. RPTD/PRLNGD
SOLV OVEREXP MAY RESULT IN PERM CNS DMG. MAY CAUSE LONG-TERM LUNG DMG. NOTE:
TOLUE NE APPEARS ON THE NAVY LIST OF OCCUP CHEM REPROD HAZS. SEEK
CONSULTATION FROM APPROP HLTH PROFESSIONALS (SUPP DATA)
Medical Cond Aggravated By Exposure: RESP ALLERGIES. CHRONIC DISEASE OF SKIN,
NOSE, THROAT, RESP TRACT, CNS, LIVER OR KIDNEY.
First Aid: INHAL:MOVE PERSON TO FRESH AIR. RESTORE BRTHG BY ARTF RESUSCITATION,
IF NEC. TREAT SYMPTOMATICALLY. CONSULT MD. EYE: FLUSH IMMED W/LRG AMTS OF
WATER FOR @ LST 15 MIN, HOLDING EYELIDS OPEN WHILE FLUSHI NG. TAKE TO MD FOR
MED TREATMENT. SKIN:FLUSH CONTAM SKIN & CLTHG W/LRG AMTS OF WATER. REMOVE
CONTAM CLTHG. WASH AFFECTED SKIN AREAS W/SOAP & WATER. CONSULT MD IF
IRRIT PERSISTS. INGEST: (SUPP DATA)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EVAC NON-ESSENTIAL PERSONNEL. AVOID BRTHG VAPS. VENT
AREA. NOTIFY APPROP AUTHORITIES, IF NEC. AVOID CONTACT. CONTAIN & REMOVE
W/INERT ABSORB MATL & NON-SPARKING TOOLS. REMOVE ALL SOURCES OF IGNIT
(FLA ME, HOT SURFS, & ELECTRICAL, STATIC OR
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISP SHOULD BE DONE I/A/W FED (40CFR 261), STATE &
LOC ENVIRON CONTROL REGS. BEFORE ATTEMPTING CLEAN-UP, REFER TO HAZ CAUTION
INFO IN OTHER SECTS OF MSDS FORM. IF WASTE IS DETERMINED TO BE HAZ, USE LI
CENSED HAZ WASTE TRANSPORTER & DISP FACILITY.
Handling And Storage Precautions: DO NOT STORE/USE NEAR HEAT/OPEN FLAME. REFER
TO OSHA 29CFR PART 1910.106 FOR SPECIFIC STORAGE REQUIREMENTS. STORE DRUM OUT
OF SUN AND AWAY FROM HEAT.
Other Precautions: STORE ONLY IN WELL-VENT AREAS. KEEP CLOSURE TIGHT AND
CONTAINER UPRIGHT TO PVNT LEAKAGE. DRUMS OF THIS MATL SHOULD BE GROUNDED
& BONDED WHEN POURING. EMPTY DRUMS SHOULD NOT BE REUSED. AVOID BRTHG SAND
ING DUST. CAN CAUSE ALLERGIC
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 26.0F,-3.3C
Lower Limits: 1.3%
Extinguishing Media: FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, HALON 1211
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM HEAT/ELEC
EQUIP/SPARKS/OPEN FLAME & OTHER SOURCES OF IGNIT. WATER MAY BE USED TO
COOL CLOSED CNTNRS TO PVNT (SUPP DATA)
=======================================================
Control Measures
=======================================================
Respiratory Protection: THIS PROD CONTAINS ISOCYANATES WHICH HAVE POOR ODOR
WARNING PROPERTIES. IF OCCUPATIONAL EXPOSURE LIMITS ARE EXCEEDED, A SUPPLIED
AIR RESP SHOULD BE USED. NIOSH/MSHA APPROVED AIRLINE TYPE RESPIRATORS O R
HOODS IN CONFINED AREAS.
Ventilation: SUFFICIENT VENT, IN PATTERN & VOL, SHOULD BE PROVIDED TO KEEP
AIR CONTAM CONC BELOW ACCEPT EXPOSURE LIMITS.
Protective Gloves: NEOPRENE, NITRILE OR RUBBER.
Eye Protection: ANSI APPROVED CHEM WORK GOGG (FP N).
Other Protective Equipment: DISPOSABLE OR IMPERVIOUS CLOTHING IF WORK CLTHG
CONTAM IS LIKELY. REMOVE & WASH CONTAM CLTHG BEFORE REUSE.
Work Hygienic Practices: WASH HANDS BEFORE EATING, SMOKING OR USING THE
WASHROOM. DO NOT SMOKE IN ANY CHEM HANDLING OR STORAGE AREA. FOOD
Supplemental Safety and Health: EXPLO HAZ: PRESSURE BUILDUP & POSSIBLE
AUTOIGNITION OR EXPLOSION. EFTS OF OVEREXP: CONCERNING LATEST HAZ LIST INFO
& SAFE HANDLING AND EXPOSURE INFO (FP N). FIRST AID PROC: DRINK 1-2
GLASSES OF WATER OR MILK TO DILUTE. DO NOT INDUCE VOMIT.CONSULT MD OR POIS
CONTROL CTR IMMED. TREAT SYMPTOMATICALLY.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: F3
B.P. Text: >338F,>170C
Vapor Pres: SEE INGS
Vapor Density: LTR/AIR
Spec Gravity: 0.98 (FP N)
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: NO
Appearance and Odor: TAN LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume: 40
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURES.
Materials To Avoid: H*2O, ALCOHOLS, AMINES, MATERIALS WITH ACTIVE HYDROGEN.
Hazardous Decomposition Products: CO*2, CO, OXIDES OF NITROGEN, TRACE OF HCN,
MONOMERIC ISOCYANATE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: TYRITE 7650
Company: LORD CORPORATION, CHEMICAL PRODUCTS DIVISION
Street: 2000 WEST GRANDVIEW BLVD
City: ERIE PA
Zipcode: 16514-0038
Health Emergency Phone: 814-763-2345
Label Required IND: Y
Date Of Label Review: 01/26/1994
Status Code: C
Label Date: 01/26/1994
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE LIQUID - CLASS IB. DO NOT STORE NEAR HEAT OR
OPEN FLAME. STORE OUT OF SUN. ACUTE: POSSIBLE IRRITATION OF RESPIRATORY
SYSTEM CAUSING SYMPTOMS SUCH AS DRYNESS OF THROAT, TIGHTNESS OF CHEST AND
SHORTNESS OF BREATH. ANESTHETIC. RESPIRATORY IRRITANT. SKIN IRRITANT. EYE
IRRITANT. MAY CAUSE CNS DEPRESSION WITH SYMPTOMS OF HEADACHE, DIZZINESS,
STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS OR COMA. CHRONIC: MAY CAUSE SKIN
SENSIT/DERM, RESP SENSIT AND LIVER OR KIDNEY DAMAGE. REPEATED SOLVENT
EXPOSURE MAY CAUSE PERMANENT CNS DAMAGE. MAY CAUSE LONG TERM LUNG DAMAGE.
TOLUENE APPEARS ON NAVY LIST OF OCCUP CHEM REPROD HAZS (FP N).
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|