| MSDS | : | 7193, SCOTCH BRAND V.C.I. CORR INHIBITING (SUPDAT) | | CAS | : | 9002-88-4
7632-00-0
112945-52-5 | | NAME | : | polyethylene mp: 230f, 110c.
nitrous acid, sodium salt; (sodium nitrite) (sara iii)
pigment
silica gel; (silica)
supdat: death may occur in cases of sev overexp. low blood
ing 5: heart rate. cns depress:signs/symps can incl hdch, dizz, drow,
ing 6: speech, gidd & uncon. ingest: not likely route of expos to
ing 7: pain, vomit, abdom tenderness, naus, blood in vomitus & in
ing 8:or more of s in prod & are reqd to be incl on msds by
ing 9: expected efts during forseeable use of prod. anemia:signs/symps
ing 10: methemoglobinemia: signs/symps can incl blue skin color &
ing 11: of sev overexp. low blood press: signs/symps can incl dizz &
ing 12: signs/symps can incl hdch, dizz, drow, musc weak, incoordination,
ing 13: vision, slurred speech, gidd, tremors & convls. other hlth
ing 14:& hndlg has not been reported to cause significant adverse
ing 15: cndtns e.g. grinding/heating, prod may rels fumes & vaps of
ing 16: process cndtns. these process rels may prdce irrit/any of hlth
ing 17: present at elevated concs. use w/approp local exhaust vent.
hygiene pract: handling & before eating. do not ingest.
|
| |
|
|
3M GENERAL OFFICES -- 7193, SCOTCH BRAND V.C.I. CORR INHIBITING (SU
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BVWVV
MSDS NAME: 7193, SCOTCH BRAND V.C.I. CORR INHIBITING (SUPDAT)
Responsible Party
Name: 3M GENERAL OFFICES
Address: 3M CENTER
City: ST PAUL MN 55144-1000
Info Phone: 612-733-1110
Emergency Phone Number: 612-733-1110
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: MINNESOTA MINING AND MFG CO, DBA 3M
Address: 3M CENTER BLDG 224-5S-04
City: SAINT PAUL MN 55144-1000
Phone: 866-556 5712 / 612-733-1110
Name: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Address: 3M CTR
City: SAINT PAUL MN 55144-1000
Phone: 612-737-4114
=======================================================
Ingredients
=======================================================
Cas: 9002-88-4
RTECS #: TQ3325000
Name: POLYETHYLENE MP: 230F, 110C.
% Wt: 90-98
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 7632-00-0
RTECS #: RA1225000
Name: NITROUS ACID, SODIUM SALT; (SODIUM NITRITE) (SARA III)
% Wt: 1-8
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
EPA Rpt Qty: 100 LBS
DOT Rpt Qty: 100 LBS
------------------------------
Name: PIGMENT
% Wt: 0-3
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 112945-52-5
RTECS #: VV7310000
Name: SILICA GEL; (SILICA)
% Wt: <0.5
OSHA PEL: 6 MG/M3
ACGIH TLV: 10 MG/M3
------------------------------
Name: SUPDAT: DEATH MAY OCCUR IN CASES OF SEV OVEREXP. LOW BLOOD
PRESS:SIGNS/SYMPS CAN INCL DIZZ & FAINTING. INCREASED
-----------------------------
Name: ING 5: HEART RATE. CNS DEPRESS:SIGNS/SYMPS CAN INCL HDCH, DIZZ, DROW,
INCOORDINATION, SLOWED RXN TIME, SLURRED
-----------------------------
Name: ING 6: SPEECH, GIDD & UNCON. INGEST: NOT LIKELY ROUTE OF EXPOS TO
PROD. IRRIT OF GI TISS:SIGNS/SYMPS CAN INCL
-----------------------------
Name: ING 7: PAIN, VOMIT, ABDOM TENDERNESS, NAUS, BLOOD IN VOMITUS & IN
FECES. WHILE FOLLOWING EFTS ARE ASSOC W/ONE
-----------------------------
Name: ING 8:OR MORE OF INGREDS IN PROD & ARE REQD TO BE INCL ON MSDS BY
U.S. OSHA HAZ COMMUNICATION STD, THEY ARE NOT
-----------------------------
Name: ING 9: EXPECTED EFTS DURING FORSEEABLE USE OF PROD. ANEMIA:SIGNS/SYMPS
CAN INCLUDE PROLONGED WEAKNESS & FATG.
-----------------------------
Name: ING 10: METHEMOGLOBINEMIA: SIGNS/SYMPS CAN INCL BLUE SKIN COLOR &
DFCLTY BRTHG. COMA & DEATH MAY OCCUR IN CASES
-----------------------------
Name: ING 11: OF SEV OVEREXP. LOW BLOOD PRESS: SIGNS/SYMPS CAN INCL DIZZ &
FAINTING. INCR HEART RATE. CNS DEPRESS:
-----------------------------
Name: ING 12: SIGNS/SYMPS CAN INCL HDCH, DIZZ, DROW, MUSC WEAK, INCOORDINATION,
SLOWED RXN TIME, FATIGUE, BLURRED
-----------------------------
Name: ING 13: VISION, SLURRED SPEECH, GIDD, TREMORS & CONVLS. OTHER HLTH
HAZ INFO: EXPOS TO THIS MATL IN NORM STORAGE
-----------------------------
Name: ING 14:& HNDLG HAS NOT BEEN REPORTED TO CAUSE SIGNIFICANT ADVERSE
HLTH EFTS. HOWEVER, UNDER NORM PROCESSING
-----------------------------
Name: ING 15: CNDTNS E.G. GRINDING/HEATING, PROD MAY RELS FUMES & VAPS OF
VARIABLE COMPOSITION BASED ON SPECIFIC
-----------------------------
Name: ING 16: PROCESS CNDTNS. THESE PROCESS RELS MAY PRDCE IRRIT/ANY OF HLTH
EFTS LISTED WHEN THE EMISSIONS ARE
-----------------------------
Name: ING 17: PRESENT AT ELEVATED CONCS. USE W/APPROP LOCAL EXHAUST VENT.
-----------------------------
Name: HYGIENE PRACT: HANDLING & BEFORE EATING. DO NOT INGEST.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MILD IRRIT:SIGNS/SYMPS CAN INCL REDNESS, SWELL, PAIN
& TEARING. MECH EYE IRRIT:SIGNS/SYMPS CAN INCL IRRIT, REDNESS, SCRATCHING
OF CORNEA & TEARING. SKIN: BURNS (THERMAL, FROM CNTCT W/HOT MATL):S
IGNS/SYMPS CAN INCL BURNING PAIN, RED &SWOLLEN SKIN & BLISTERS; MILD
SKIN IRRIT (AFTER PRLNG/RPTD (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: CNTCT):SIGNS/SYMPS CAN
INCL:REDNESS, SWELL & ITCH. INHAL: HLTH EFTS NOT EXPECTED UNLESS PROD IS
HEATED. VAPS OF HEATED MATL MAY CAUSE RESP SYS IRRIT. WHILE THE FOLLOWING
EFTS ARE ASSOC W/ONE OR MORE OF INGREDS IN PROD & ARE REQD TO BE INCLD
ON MSDS BY U.S. OSHA HAZ COMMUNICATION STD, THEY ARE NOT (SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: IMMED FLUSH W/LG AMTS OF WATER. GET IMMED MED ATTN. SKIN:
FLUSH W/LG AMTS OF WATER. IF IRRIT PERSISTS, GET MED ATTN. IMMED FLUSH
AFFECTED AREA W/PLENTY OF COLD WATER & COVER W/CLEAN DRESSING. DO NOT
ATTEMPT TO REMOVE MOLTEN MATL. HAVE BURN TREATED BY MD. INHAL: IF SIGNS/SYMPS
OCCUR, REMOVE TO FRESH AIR. IF SIGNS/SYMPS CONTINUE, CALL MD. INGEST: DRINK
TWO GLASSES OF WATER. CALL MD.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OBSERVE PRECAUTIONS FROM OTHER SECTIONS. COLLECT
SPILLED MATERIAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF WASTE PRODUCT IN SANITARY LANDFILL. DISPOSAL
ALTERNATIVE: MIX W/FLAMM MATERIAL & INCINERATE IN AN
INDUSTRIAL/COMMERCIAL INCINERATOR. SINCE REGULATIONS VARY CONSULT APPLICABLE
FEDERAL, STATE & LOCAL REGULATIONS/AUTHORITIES BEFOREDISPOSAL.
Handling And Storage Precautions: STORE AWAY FROM AREAS WHERE PROD MAY COME
INTO CNTCT W/FOOD/PHARMACEUTICALS. STORE AWAY FROM ACID. STORE AWAY FROM
HEAT. STORE OUT OF DIRECT SUNLIGHT.
Other Precautions: KEEP CONTAINER DRY.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NOT DETERMINED.
=======================================================
Control Measures
=======================================================
Respiratory Protection: AVOID INHALATION OF THERMAL DECOMPOSITION PRODUCTS. USE
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: PROVIDE APPROPRIATE LOCAL EXHAUST WHEN PRODUCT IS HEATED.
Protective Gloves: IMPERVIOUS GLOVES (FP N).
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGLES (FP N).
Other Protective Equipment: EMERGENCY EYE WASH & DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: DO NOT EAT, DRINK OR SMOKE WHEN USING THIS PROD. WASH
EXPOSED AREAS THORO W/SOAP & WATER. WASH HANDS AFTER
Supplemental Safety and Health: MFR'S TRADE NAME/PART NO: FILM 190/193 SERIES.
% VOLAT: <0.5% BY WT. EFTS OF OVEREXP: EXPECTED EFTS DURING FORSEEABLE USE
OF PROD: ANEMIA (DECR NUMBER OF RED BLOOD CELLS/AMT OF HEMOGLOBIN):SIGNS
& SYM PS CAN INCL PRLNG WEAK & FATG. METHEMOGLOBINEMIA: SIGNS/SYMPS
CAN INCL BLUE SKIN COLOR & DFCLTY BRTHG. COMA &
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: SEE ING 1
Appearance and Odor: TRANSLUCENT CLEAR OR GREEN FILM.
Percent Volatiles by Volume: SUPDAT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NOT DETERMINED.
Hazardous Decomposition Products: DECOMP PRODS MAY INCL CARBON DIOXIDE, CARBON
MONOXIDE, SHORT CHAIN ALDEHYDES, ACETIC ACID, ACROLEIN & NITROGEN OXIDES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: 7193, SCOTCH BRAND V.C.I. CORR INHIBITING (SUPDAT)
Company: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Street: 3M CTR
City: SAINT PAUL MN
Zipcode: 55144-1000
Health Emergency Phone: 612-733-1110
Label Required IND: Y
Date Of Label Review: 10/27/1994
Status Code: C
Label Date: 10/27/1994
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYES: REDNESS, SWELLING, PAIN, TEARING.
IRRITATION, REDNESS, SCRATCHING OF CORNEA. SKIN: BURNS (THERMAL, FROM CONTACT
WITH HOT MATERIAL). SIGNS/SYMPTOMS CAN INCLUDE BURNING PAIN, RED &
SWOLLEN SKIN & BLISTERS; MILD SKIN IRRITATION (AFTER PROLONGED/REPEATED
CONTACT): REDNESS, SWELLING & ITCHING. INHALATION: VAPORS OF HEATED
MATERIAL MAY CAUSE RESPIRATORY SYSTEM IRRITATION. INGESTION: IRRITAT ION OF
GASTROINTESTINAL TISSUES, NAUSEA, VOMITING, BLOOD IN VOMITUS & FECES.
CHRONIC: MAY CAUSE ANEMIA, CENTRAL NERVOUS SYSTEM DEPRESSION & INCREASED
HEART RATE.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|