HEXCEL CORP -- EPOLITE 2323 HARDENER
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BVXRC
MSDS NAME: EPOLITE 2323 HARDENER
Responsible Party
Name: HEXCEL CORP
Address: 20701 NORDHOFF ST
Box: 2197
City: CHATSWORTH CA 91311
Info Phone: 818-882-3022
Emergency Phone Number: 800-433-5072
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: HEXCEL CORP
Address: 11555 DUBLIN BLVD
Box: 2197
City: DUBLIN CA 94568
Phone: 415-828-4200
Name: HEXCEL CORPORATION;CHEMICAL PRODUCTS DIVISION
Address: 20701-NORDHOFF STREET
Box: 2197
City: CHATSWORTH CA 91311-5924
Phone: 818-882-3022
=======================================================
Ingredients
=======================================================
Cas: 101-77-9
RTECS #: BY5425000
Name: ANILINE,4,4'-METHYLENEDI-; (4,4'-METHYLENE DIANILINE) (MDA) (SARA III).
LD50:(ORAL,RAT) 250-347 MG/KG.
% Wt: 20-35
OSHA PEL: N/K (FP N)
ACGIH TLV: 0.1 PPM, S
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 108-45-2
RTECS #: SS7700000
Name: M-PHENYLENEDIAMINE; (META-PHENYLENE DIAMINE (MPDA))
% Wt: 50-65
OSHA PEL: N/K (FP N)
ACGIH TLV: 0.1 MG/M3
------------------------------
Cas: 26376-58-9
Name: AMINE TERMINATED POLYMER
% Wt: 10-25
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
RTECS #: 9999999VO
Name: VOLATILE ORGANIC COMPONENT: 140 G/L.
-----------------------------
Name: SUPDAT:TO MDA MAY CAUSE ALLERGIC SKIN RXNS & LIVER DMG. MDA CAUSED
LIVER TUMORS IN MICE & THYROID CANCER IN RATS
-----------------------------
Name: ING 5:& MICE DURING LABORATORY TESTS.
-----------------------------
Name: FIRST AID PROC:CONSCIOUS, GIVE 1-2 CUPS OF MILK/WATER TO DRINK. DO NOT
GIVE ANYTHING BY MOUTH TO UNCON PERS.
-----------------------------
Name: ING 7:CONSULT MD IMMED. NOTE:IN ALL CASES, MD SHOULD BE CONSULTED. PEOPLE
EXPOS TO MDA WILL PROBABLY NEED MED
-----------------------------
Name: ING 8:SURVEILLANCE.
-----------------------------
Name: SPILL PROC:OR OTHER ABSORB. PLACE INTO OPEN-TOPPED CNTNRS & COVER
LOOSELY; STORE FOR AT LST 12 HRS BEFORE SEALING CNTNR.
-----------------------------
Name: OTHER PREC:CONTROL DEPENDS ON HOW THIS MATL IS PROCESSED. SELECTION OF
SPECIFIC PERSONAL PROT EQUIP WILL DEPEND
-----------------------------
Name: ING 11:ON OPERATION. CONSULT OSHA STD 29 CFR 1910 & 1926 FOR MORE
INFO ON WHETHER OTHER ENGINEERING CONTROLS ARE NEEDED.
-----------------------------
Name: RESP PROT:FULL FACEPIECE RESP W/HEPA CARTRIDGE/CANISTER. NIOSH/MSHA
APPRVD FULL FACEPIECE POWERED AIR-PURIFYING
-----------------------------
Name: ING 13:RESP W/HEPA CARTRIDGES IS REQD WHEN AIRBORNE CONC IS </= 1000
TIMES PEL OF MDA. WEAR EITHER A NIOSH/MSHA
-----------------------------
Name: ING 14:APPRVD SCBA W/FULL FACEPIECE IN POS PRESS MODE/FULL FACEPIECE POS
PRESS DEMAND SUPPLIED AIR RESP W/
-----------------------------
Name: ING 15:AUXILIARY SELF-CONTAINED AIR SUPPLY IF AIRBORNE CONCENTRATION OF
MDA IS UNKNOWN.
-----------------------------
Name: EYE PROT:SHIELD. VAPOR RESISTANT GOGGLES ARE NECESSARY IF CONTACT LENSES
ARE WORN BY EMPLOYEE.
-----------------------------
Name: HYGIENE PRACT:AMTS OF THE MATL GET ON WORK CLOTHES, EMPLOYEE SHOULD
SHOWER IMMED & CLTHG SHOULD BE LAUNDERED
-----------------------------
Name: ING 18:BEFORE IT IS WORN AGAIN. ANY EMPLOYEE WHO HAS BEEN EXPOS TO MDA
AT/ABOVE ACTION LEVEL (5 PPB) FOR 30/MORE
-----------------------------
Name: ING 19:DAYS A YR/WHO SHOWS SIGNS OF DERMAL EXPOS (STAINED SKIN) MUST SEE
MD FOR MED SURVEILLANCE. NOTE:ANY CLTHG
-----------------------------
Name: ING 20:THAT HAS BEEN CONTAM W/MDA MUST BE LAUNDERED BEFORE IT IS WORN
AGAIN. DESTROY CONTAM LEATHER & ABSORB
-----------------------------
Name: ING 21:SHOES. WORK CLOTHING CANNOT BE TAKEN HOME.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENT 1.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: OVEREXP TO THIS PROD CAN CAUSE FEVER, CHILLS, LOSS OF
APPETITE, VOMIT & JAUN. CONT MAY IRRIT SKIN, EYES & MUC MEMBS. MAY
STAIN SKIN. PRLNG EXPOS MAY CAUSE ALLERGIC SKIN RXNS (DERM). HARMFUL AMTS OF
TH IS MATL CAN BE ABSORBED THRU SKIN. THISMATL CONTAINS
4,4'-METHYLENEDIANILINE (MDA) WHICH MAY CAUSE (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: METHYLENE DIANILINE (4,4):IARC MONOGRAPHS,
SUPP, VOL 7, PG 56, 1987:GRP 2B. NTP 7TH ANNUAL RPT ON CARCINS, 1994:(SUPDAT)
Signs And Symptions Of Overexposure: HLTH HAZ:CANCER & IS LIVER TOXIN. RISK
OF CANCER DEPENDS ON LGTH & LEVEL OF EXPOS. IN ADDN, LONG-TERM (CHRONIC)
EXPOS MAY RSLT IN DMG TO LIVER, KIDNEYS, BLOOD, SPLEEN, THYROID & EYES.
THIS PROD CONTAI NS MPDA WHICH MAY CAUSE DMG TO LIVER & KIDNEYS WHEN
INHALED, SWALLOWED/ABSORBED THRU SKIN. THIS PROD MAY STAIN (SUPDAT)
Medical Cond Aggravated By Exposure: PRE-EXISTING EYE, SKIN & RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
First Aid: EYES:IMMED FLUSH W/PLENTY OF WATER (PREF LUKEWARM) FOR AT LST 15
MINS, KEEPING EYELIDS OPEN ALL THE TIME. SEEK IMMED MED ATTN. SKIN:IMMED WASH
W/SOAP & PLENTY OF WATER. WASH CONTAM CLTHG BEFORE RE-USE & DESTROY
CONTAM SHOES. INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP, PREF
MOUTH-TO-MOUTH. IF BRTHG IS DFCLT, GIVE OXYGEN. GET MED ATTN. INGEST:DO NOT
INDUCE VOMIT. IF PERS IS
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: IN CASE OF SPILL, CONTAIN W/SUITABLE DIKING MATL. IN
ADDN TO PROT EQUIP LISTED IN EXPOS CONTROLS/PERSONAL PROT SECTION, WEAR
IMPERMEABLE BOOTS. VENTILATE AREA THORO. KEEP ALL UNNEC PEOPLE AWAY. SPILLE D
MATL SHOULD BE ABSORBED IN SAWDUST, SAND
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N).
Handling And Storage Precautions: AVOID CONT W/EYES, SKIN & CLTHG. AVOID
BRTHG VAP. KEEP CNTNRS CLSD. KEEP MATL AWAY FROM HEAT, SPKS & OPEN
FLAMES. AVOID MOISTURE CONTAMINATION.
Other Precautions: IF USED INDOORS, USE MECH EXHST VENT. WASH THORO AFTER
HNDLG. CONSULT EXPOS CONTROLS/PERSONAL PROT SECTION FOR PERSONAL
PROT/ENGINEERING CONTROLS. STORE IN A COOL, WELL VENTILATED AREA IN TIGHTLY
CLSD CNTNRS. LEVEL OF ENGINEERING
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 440F,227C
Extinguishing Media: USE WATER SPRAY, DRY CHEMICAL OR CO*2 TO EXTINGUISH FIRES.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). USE WATER TO KEEP CONTAINERS COOL.
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF AIRBORNE CONC OF MDA IS </= 10 TIMES PEL, WEAR
NIOSH/MSHA APPRVD HALF-MASK RESP W/COMBINATION ORG VAP/HEPA (HIGH EFFICIENCY
PARTICULATE IN AIR FILTER) CARTRIDGE. IF AIRBORNE CONC IS </= 50 TIMES MD
A PEL, WEAR NIOSH/MSHA APPRVD
Ventilation: USE EXHST VENT TO KEEP AIRBORNE LEVELS BELOW OSHA-REC EXPOS LIMS.
DO NOT USE THIS PROD IN POORLY VENTILATED AREA.
Protective Gloves: BUTYL OR NEOPRENE GLOVES.
Eye Protection: CHEM SPLASH-PROOF GOGGS & FACE
Other Protective Equipment: WEAR PROT CLTHG THAT IS IMPERVIOUS TO THIS PROD.
SELECTION OF BOOTS, APRON/FULL-BODY SUIT WILL DEPEND ON OPERATION.
Work Hygienic Practices: BEFORE EATING, DRINKING, SMOKING/USING TOILET
FACILITIES, WASH FACE & HANDS THORO W/SOAP & WATER. IF SIGNIFICANT
Supplemental Safety and Health: EXPLAN OF CARCIN:ANTIC TO BE CARCIN.
ANIMAL:BLADDER CANCER, LIVER, SKIN EFTS. EFTS OF OVEREXP:SKIN. SOME PEOPLE
MAY DEVELOP SKIN/RESP SENSIT TO MPDA-CNTNG PRODS. SEV RESP SENSIT MAY RSLT IN
CHRONIC LU NG DISORDERS W/SYMPS OF LUNG INSUFFICIENCY. ING 1:THIS MATL IS
HARMFUL IF ABSORBED THRU SKIN. RPTD DERMAL EXPOS
=======================================================
Physical/Chemical Properties
=======================================================
HCC: T6
Spec Gravity: 1.12
Appearance and Odor: DARK BROWN LIQUID OR CRYSTALLINE SOLID W/AMINE ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: AVOID CONT W/STRONG OXIDIZERS. AVOID CONT W/WATER,
ALCOHOLS, STRONG BASES, METAL COMPOUNDS OR SURFACE ACTIVE MATLS.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE, NITROGEN
OXIDES & ANILINE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: EPOLITE 2323 HARDENER
Company: HEXCEL CORP
Street: 11555 DUBLIN BLVD
PO Box: 2197
City: DUBLIN CA
Zipcode: 94568
Health Emergency Phone: 800-433-5072
Label Required IND: Y
Date Of Label Review: 10/25/1994
Status Code: C
Label Date: 10/25/1994
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. AVOID WATER. ACUTE:OVEREXPOSURE TO THIS
PRODUCT CAN CAUSE FEVER, CHILLS, LOSS OF APPETITE, VOMITING & JAUNDICE.
CONTACT MAY IRRITATE SKIN, EYES & MUCOUS MEMBRANES. MAY STAIN SKIN.
PROLONG ED EXPOSURE MAY CAUSE ALLERGIC SKIN REACTIONS (DERMATITIS). HARMFUL
AMOUNTS OF THIS MATERIAL CAN BE ABSORBED THROUGH SKIN. CHRONIC:CANCER HAZARD.
CONTAINS METHYLENE DIANILINE (4,4), WHICH IS LISTED AS A LIVER CARCINOGEN
(FP N). MAY DAMAGE LIVER, KIDNEYS, BLOOD, SPLEEN, THYROID &EYES. MAY
CAUSE SKIN OR RESPIRATORY SENSITIZATION.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|