LORD CHEMICAL PRODUCTS DIVISIO -- Z001 CLEAR FLEXIBLE COATINGS, MOISTURE CURE Z
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BWCNH
MSDS NAME: Z001 CLEAR FLEXIBLE COATINGS, MOISTURE CURE Z001OR
Responsible Party
Name: LORD CHEMICAL PRODUCTS DIVISION
Address: 2000 WEST GRANDVIEW BLVD
Box: 10038
City: ERIE PA 16514-0038
Info Phone: 814-868-3611
Emergency Phone Number: 814-763-2345
Preparer's Name: RHE
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: LORD CHEMICAL PRODUCT
Address: 2000 WEST GRANDVIEW BLVD
Box: 10038
City: ERIE PA 16514-0038
Phone: 814-763-2345"EMERG SAFETY ENGINEER"
Name: LORD CORPORATION, CHEMICAL PRODUCTS DIVISION
Address: 2000 WEST GRANDVIEW BLVD
City: ERIE PA 16514-0038
Phone: 814-868-3611
=======================================================
Ingredients
=======================================================
Cas: 101-68-8
RTECS #: NQ9350000
Name: ISOCYANIC ACID, METHYLENEDI-P-PHENYLENE ESTER; (4,4'-PHENYLMETHANE
DIISOCYANATE) (SARA III). VP: <10.0 @ 20C.
% Wt: <2.0
OSHA PEL: 0.02 PPM, C
ACGIH TLV: 0.005 PPM
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 100-41-4
RTECS #: DA0700000
Name: BENZENE,ETHYL-;(ETHYL BENZENE) (SARA III). VP: 7.1 @ 20C.
% Wt: <10
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM; 125 STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 1330-20-7
RTECS #: ZE2100000
Name: XYLENE (SARA III). VP: 6.6 @ 20C.
% Wt: <35
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM; 150 STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 108-10-1
RTECS #: SA9275000
Name: 2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (SARA III). VP: 15 @
20C.
% Wt: <15
OSHA PEL: 100 PPM
ACGIH TLV: 50 PPM; 75 STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 108-88-3
RTECS #: XS5250000
Name: TOLUENE (SARA III). VP: 22.0 @ 20C.
% Wt: <10
OSHA PEL: 200 PPM
ACGIH TLV: 50 PPM, S
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 108-65-6
RTECS #: AI8295000
Name: ACETIC ACID,2-METHOXY-1-METHYLETHYL ESTER; (PROPYLENEGLYCOL MONOMETHYL
ETHER ACETATE). VP: 3.7 @ 20C.
% Wt: <4.0
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Name: OTHER PRECS: ALLERGIC SKIN RXN. PVNT PLNGD/RPTD BRTHG OF VAP/SPRAY MISTS.
DO NOT HANDLE UNTIL MFRS SAFETY PRECS
-----------------------------
Name: ING 7: HAVE BEEN READ & UNDERSTOOD. NEVER USE PRESSURE TO EMPTY. DRUM
IS NOT PRESS VESSEL. DO NOT PUNCTURE, DRAG
-----------------------------
Name: ING 8: OR SLIDE CNTNR. DO NOT WELD OR FLAME-CUT AN EMPTY DRUM.
-----------------------------
Name: VENT: VAPORS ARE HEAVIER THAN AIR & COLLECT IN LOWER LEVELS OF WORK
AREA. SUFF VENT (USING EXPLO PROOF EQUIP)
-----------------------------
Name: ING 10: SHOULD BE PROVIDED TO PVNT FLAMM VAP/AIR MIXTURES FROM
ACCUMULATING. ALL APPLIC AREAS SHOULD BE
-----------------------------
Name: ING 13: VENTILATED IN ACCORDANCE WITH OSHA REGULATIONS 29 CFR PART
1910.94.
-----------------------------
Name: HYGIENE PRAC: SHOULD NOT BE CONSUMED ANYWHERE THIS PRODUCT IS HANDLED OR
STORED. WASH THOROUGHLY AFTER HANDLING.
-----------------------------
Name: SUPP DATA: LIST INFORMATION AND SAFE HANDLING AND EXPOSURE INFORMATION
(FP N).
-----------------------------
Name: FIRST AID PROC: GLASSES OF WATER/MILK TO DILUTE. DO NOT INDUCE VOMIT.
CONSULT MD/POISON CONTROL CENTER IMMED.
-----------------------------
Name: ING 15: TREAT SYMPTOMATICALLY.
-----------------------------
Name: SPILL PROC: IF NEC. CONTAIN & REMOVE W/INERT ABSORB MATL &
NON-SPARKING TOOLS. AVOID CONTACT.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:POSS IRRIT OF RESP SYSTEM CAN OCCUR CAUSING A
VARIETY OF SYMPS SUCH AS DRYNESS OF THROAT, TIGHTNESS OF CHEST &
SHORTNESS OF BREATH. ALLERG CNDTNS CAN OCCUR IN CERTAIN INDIVIDUALS W/HIGH
SENSITIV ITY TO ISOCYANATES. THIS MAY RSLT IN ASTHMA-LIKE SYMPS. ANESTHETIC.
RESP, SKIN & EYE IRRIT. MAY CAUSE(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: CNS DEPRESS CHARACT BY FOLLOWING
PROGRESSIVE STEPS: HDCH, DIZZ, STAGGERING GAIT, CONFUSION, UNCON/COMA. MAY
CAUSE HDCH & NAUS. CHRONIC: MAY CAUSE: SKIN SENSIT, DERMATITIS, RESP
SENSIT, LIVER /KIDNEY DMG. RPTD/PLNGD SOLV OVEREXP MAY RSLT IN PERM CNS DMG.
MAY CAUSE LONG-TERM LUNG DMG. MAY AFFECT (SUPP DATA)
Medical Cond Aggravated By Exposure: RESP ALLERGIES. CHRONIC DISEASES OF SKIN.
CHRONIC DISEASES OF THE NOSE, THROAT & RESP TRACT. CHRONIC DISEASES OF
CNS SYSTEM. CHRONIC DISEASES OF EYES. CHRONIC DISEASES OF GI TRACT.
First Aid: INHAL: MOVE PERS TO FRESH AIR. RESTORE BRTHG BY ARTF RESP, IF NEC.
TREAT SYMP. CONSULT MD. EYES: FLUSH EYES IMMED W/LGE AMTS OF WATER FOR AT
LEAST 15 MINS, HOLDING EYELIDS OPEN WHILE FLUSHING. GET PRO MPT MED ATTN.
SKIN: FLUSH CONTAMD SKIN & CLTHG W/LGE AMTS OF WATER. REMOVE CONATMD
CLTHG. WASH AFFECTED SKIN AREAS W/SOAP & WATER. CONSULT MD IF IRRIT
PERSISTS. INGEST: DRINK 1 OR 2
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EVAC NON-ESSENTIAL PERS. REMOVE ALL SOURCES OF
IGNIT(FLAME, HOT SURFS & ELEC, STATIC/FRICTIONAL SPARKS). AVOID BRTHG
VAPS. USE NIOSH/MSHA APPRVD SCBA. VENT AREA W/EXPLOS-PROO DRIVEN EQUIP, POSS
PRESEN CE OF FLAMM VAPS. NOTIFY APPROP AUTHS,
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF I/A/W/ LOCAL, STATE & FEDERAL (40 CFR
PART 261) ENVIRONMENTAL CONTROL REGULATIONS. BEFORE ATTEMPTING CLEAN-UP,
REFER TO HAZ CAUTION INFO IN MSDS FORM. IF WASTE IS DETERMINED TO BE HAZ, USE
LICENSED HAZ WASTE TRANSPORTER & DISP FACILITY.
Handling And Storage Precautions: DO NOT STORE/USE NEAR HEAT/OPEN FLAME. REFER
TO OSHA 29 CFR PART 1910.106 "FLAMM & COMBUST LIQS" FOR SPECIFIC STOR
REQS.
Other Precautions: KEEP CLOSURE TIGHT & CNTR UPRIGHT TO PVNT LEAKAGE. STORE
DRUM OUT OF SUN & AWAY FROM HEAT. STORE ONLY IN WELL-VENT AREAS. METAL
CNTNRS OF MATL SHOULD BE GROUNDED & BONDED WHEN POURING. DO NOT GET IN E
YES. AVOID SKIN CONT. CAN CAUSE
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 67F,19.4C
Lower Limits: 1.0%
Upper Limits: 13.1%
Extinguishing Media: DRY CHEMICAL, WATER FOG, CO*2, FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP(FP
N). IF H*2O IS USED,FOG NOZZ ARE PREF. DURING FIRE, IRRIT &/TOX GASES
& PARTICULATE FROM DECOMP MAY BE PRESENT.
Unusual Fire/Explosion Hazard: KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM HEAT,
ELEC EQUIP, SPARKS, OPEN FLAME & OTHER SOURCES OF IGNIT. CLSD CNTNRS MAY
RUPTURE WHEN EXPOS TO EXTREME(SUPP DATA)
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPRVD AIRLINE TYPE RESPIRATORS/HOOD IN
CONFINED ARES. PROD CONTAINS ISOCYANATES WHICH HAVE POOR ODOR WARNING
PROPERTIES. IF OCCUP EXPOS LMTS ARE EXCEEDED. A NIOSH/MSHA APPRVD SUPPLIED
AIR RESPIRATOR SHOULD BE USED.
Ventilation: SUFF VENT, IN PATTERN & VOL, SHOULD BE PROVIDED TO KEEP AIR
CONTAM CONC BELOW APPLIC EXPOS LMTS. CAUTION: SOLV
Protective Gloves: NEOPRENE, NITRILE OR RUBBER GLOVES.
Eye Protection: ANSI APPRVD CHEM WORKER GOGGLES (FP N).
Other Protective Equipment: USE DISP/IMPERVIOUS CLTHG IF WORK CLTHG CONTAM IS
LIKELY. REMOVE & WASH CONTAMD CLTHG BEFORE REUSE.
Work Hygienic Practices: WASH HANDS BEFORE EATINGS, SMOKING/USING WASH ROOM. DO
NOT SMOKE IN ANY CHEM HNDLG/STOR AREA. FOOD/BEVERAGES
Supplemental Safety and Health: EXPLOS HAZ: HEAT. WATER MAY BE USED TO COOL
CLSD CNTNRS TO PVNT PRESS BUILD-UP & POSS AUTO IGNIT/EXPLO. EFTS OF
OVEREXP: GI SYSTEM. MAY AFFECT BLOOD & BLOOD FORMING ORGANS. TOLUENE
APPEARS ON THE NAVY LISTING OF OCCUP CHEMICAL REPRO HAZARDS. SEEK
CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >232F,>111C
Vapor Pres: SEE INGS
Vapor Density: HVR/AIR
Spec Gravity: 0.936 (FP N)
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: INSOL IN WATER
Appearance and Odor: CLEAR LIQUID W/SOLVENT ODOR.
Percent Volatiles by Volume: 69.9
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURES. SOURCES OF IGNITION.
Materials To Avoid: AMINES, ACIDS, WATER, HYDROXYL OR ACTIVE HYDROGEN CMPDS.
STRONG ACIDS, BASES & STRONG OXIDIZERS.
Hazardous Decomposition Products: MONOMERIC ISOCYANATE, TRACES OF HYDROGEN
CYANIDE, NITROGEN DIOXDE. CARBON MONOXIDE, CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: Z001 CLEAR FLEXIBLE COATINGS, MOISTURE CURE Z001OR
Assigned IND: Y
Company: LORD CHEMICAL PRODUCT
Street: 2000 WEST GRANDVIEW BLVD
PO Box: 10038
City: ERIE PA
Zipcode: 16514-0038
Health Emergency Phone: 814-763-2345
Label Required IND: Y
Date Of Label Review: 11/28/1994
Status Code: C
Label Date: 11/28/1994
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE LIQUID CLASS IB. ACUTE:POSS IRRIT OF RESP
SYSTEM CAN OCCUR CAUSING A VARIETY OF SYMPS SUCH AS DRYNESS OF THROAT,
TIGHTNESS OF CHEST & SHORTNESS OF BREATH. ALLERG CNDTNS CAN OCCUR IN
CERTAIN INDIVIDUALS W/HIGH SENSITIVITY TO ISOCYANATES. THIS MAY RSLT IN
ASTHMA-LIKE SYMPS. ANESTH. RESP, SKIN & EYE IRRIT. MAY CAUSE CNS DEPRESS
CHARACT BY HDCH, DIZZ, STAGGERING GAIT, CONFUSION, UNCON/COMA. MAY CAUSE
HDCH & NAUSEA. CHRONIC: MAY CAUSE SKIN & RESP SENSITIZATION. MAY
CAUSE LIVER/KIDNEY DAMAGE. PLNGD SOLV OVEREXP MAY CAUSE CNS DMG. CONTAINS
TOLUENE WHICH APPEARS ON THE NAVY LIST OF OCCUPATIO NAL CHEMICAL REPRODUCTIVE
HAZARDS (FP N).
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|