DOW CORNING CORP -- 93-076-1/2 CATALYST
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BWZYP
MSDS NAME: 93-076-1/2 CATALYST
Responsible Party
Name: DOW CORNING CORP
Address: SOUTH SAGINAW ROAD
City: MIDLAND MI 48686
Info Phone: 517-496-6000
Emergency Phone Number: 800-424-9300(CHEMTREC)
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: DOW CORNING CORP
Address: 3901 S SAGINAW RD
Box: 997
City: MIDLAND MI 48686-0997
Phone: 517-496-6000/517-496-6315
Name: DOW CORNING CORP
Address: 2200 W SALZBURG RD
City: AUBURN MI 48611
Phone: 517-496-4388
=======================================================
Ingredients
=======================================================
Cas: 77-58-7
RTECS #: WH7000000
Name: STANNANE, DIBUTYLBIS(LAUROYLOXY)-; (DIBUTYLTIN DILAURATE)
% Wt: 18
OSHA PEL: 0.1 MG SN/M3 SKIN
ACGIH TLV: 0.1 MG SN/M3
------------------------------
Cas: 11099-06-2
Name: SILICA ACID, ETHYL ESTER (ETHYL SILICATE); (ETHYL POLYSILICATE)
% Wt: 19
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 1317-65-3
RTECS #: EV9580000
Name: CALCIUM CARBONATE; (LIMESTONE)
% Wt: 27
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Name: UNIDENTIFIED COMPONENTS; (UNIDENTIFIED IMPURITIES)
% Wt: 1
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Name: SUPDAT:BEFORE EATING/SMKG. COMMENTS:AVOID BRTHG VAP & EYE & SKIN
CONT. USE ONLY W/ADEQ VENT. DO NOT TAKE INTERNALLY.
-----------------------------
Name: EYE PROT:AND FULL LENGTH FACESHIELD (FP N).
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES:DIRECT CONT MAY BURN, IRRIT SEVERELY, OR PERM INJURE
DEPENDING ON EXPOS. SKIN:SINGLE RELATIVELY SHORT EXPOS (<24 HRS) IRRITS.
RPTD PRLNGD CONT (24-48 HRS) IRRITS SERIOUSLY, MAY BURN MILDLY. INHAL :SHORT
VAP EXPOS MAY CAUSE DROW & IRRITNOSE & THROAT. DEGREE OF EFTS DEPENDS
ON CONC & LENGTH OF (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZS:EXPOS. INGEST:SM AMTS
TRANSFERRED TO MOUTH BY FINGERS DURING USE, ETC., SHOULD NOT INJURE. LG AMTS
MAY INJURE SLIGHTLY. COMMENT:THESE LISTED POTNTL EFTS OF OVEREXP ARE BASED ON
ACTUAL DATA, RSLTS OF STUDIES PERFORMED UPON SIMILARCOMPOSITIONS, COMPONENT
DATA &/OR EXPERT REVIEW OF PROD. OVEREXP TO ANY (SUPDAT)
Medical Cond Aggravated By Exposure: OVEREXPOSURE TO ANY CHEMICAL MAY RESULT IN
ENHANCEMENT OF PRE-EXISTING ADVERSE MEDICAL CONDITIONS AND ALLERGIC
REACTIONS.
First Aid: EYES:IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION. SKIN:WIPE OFF AND FLUSH WITH WATER FOR 15 MINUTES. GET
MEDICAL ATTENTION IF IRRITATION DEVELOPS. INHALATION:REMOVE TO FRESH AIR.
GET MEDICAL ATTENTION IF ILLEFFECTS PERSIST. INGEST:GET MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE PRODUCT AND USE ABSORBENT MATERIAL TO TAKE
CARE OF ANY OIL-LIKE RESIDUES. FOR PERSONNEL PROTECTIVE EQUIPEMENT SEE
CONTROL MEASURES.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DOW CORNING SUGGESTS THAT ALL LOCAL, STATE AND FEDERAL
REGULATIONS CONCERNING HEALTH AND POLLUTION BE REVIEWED TO DETERMINE APPROVED
DISPOSAL PROCEDURES. CONTACT DOW CORNING IF THERE ARE ANY DISPOSAL
QUESTIONS.
Handling And Storage Precautions: STORE BELOW 90F/32C. USE REASONABLE CARE.
KEEP CONTAINER CLOSED & AWAY FROM WATER & MOISTURE. PROD EVOLVES
ETHYL ALCOHOL ON EXPOS TO WATER/HUMID AIR.
Other Precautions: PROVIDE VENT TO CTL EXPOS W/IN INGS LIMS/USE RESP PROT.
COMMENTS:TRACES OF FORMALDEHYDE (CARCIN) MAY FORM IF HEATED IN AIR ABOVE
GUIDELINES WHEN HNDLG AT ELEVATED TEMPS. REVIEW OSHA FORMALDEHYDE REGS FOR
DETAILED INFO ON SAFE HNDLG(SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: CC
Flash Point Text: 212F,100C
Extinguishing Media: WATER FOG, CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE RESPIRATORY PROTECTION UNLESS LOCAL EXHAUST
VENTILATION IS ADEQUATE OR AIR SAMPLING DATA SHOW EXPOSURES ARE WITHIN TLV
AND PEL GUIDELINES. SUITABLE RESPIRATOR:NIOSH/MSHA APPROVED AIR-SUPPLIED OR S
ELF-CONTAINED.
Ventilation: LOCAL EXHAUST:RECOMMENDED. MECHANICAL (GENERAL):RECOMMENDED.
Protective Gloves: RUBBER OR PLASTIC GLOVES ARE RECOM.
Eye Protection: ANSI APPROVED CHEM WORKERS GOGGS
Other Protective Equipment: ANSI APPROVED EMERGENCY EYE BATH AND DELUGE SHOWER
(FP N).
Work Hygienic Practices: WASHING AT MEALTIME & END OF SHIFT IS ADEQ. REMOVE
CONTAM CLTHG & SHOES AS SOON AS PRACTICAL & CLEAN THORO BEFORE REUSE.
Supplemental Safety and Health: EFTS OF OVEREXP:CHEM MAY RSLT IN ENHANCEMENT OF
PRE-EXISTING ADVERSE MED CNDTNS & ALLERGIC RXNS. OTHER PREC:REQS. THESE
PREC ARE FOR ROOM TEMP HNDLG. USE AT ELEVATED TEMPS/AEROSOL/SPRAY APPLICATNS,
MA Y REQ ADDED PREC. GOOD PRACTICE REQS THAT GROSS AMT OF ANY CHEM BE REMOVED
FROM SKIN AS SOON AS PRACTICAL, ESP
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
Vapor Pres: <5 @ 77F
Spec Gravity: 1.1 & 77F
Solubility in Water: NOT DETERMINED
Appearance and Odor: LIGHT PINK PASTE, SOME ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXPOSURE TO MATLS TO AVOID UNTIL READY TO USE.
Materials To Avoid: OXIDIZING MATERIAL CAN CAUSE A REACTION. WATER, MOISTURE,
OR HUMID AIR-ETHYL ALCOHOL VAPORS FORM.
Hazardous Decomposition Products: TIN OXIDES, CALCIUM OXIDE, SILICON DIOXIDE,
CARBON DIOXIDE, AND TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: 93-076-1/2 CATALYST
Company: DOW CORNING CORP
Street: 3901 S SAGINAW RD
PO Box: 997
City: MIDLAND MI
Zipcode: 48686-0997
Health Emergency Phone: 800-424-9300(CHEMTREC)
Label Required IND: Y
Date Of Label Review: 03/22/1995
Status Code: C
Label Date: 03/22/1995
Origination Code: G
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: CORROSIVE. ACUTE:EYES:DIRECT CONTACT MAY BURN, IRRITATE
SEVERELY, OR PERMANENTLY INJURE DEPENDING ON EXPOSURE. SKIN:A SINGLE
RELATIVELY SHORT EXPOSURE (LESS THAN 24 HOURS) IRRITATES. REPEATED PROLONGE D
CONTACT (24-48 HOURS) IRRITATES SERIOUSLY, MAY BURN MILDLY. INHALATION:SHORT
VAPOR EXPOSURE MAY CAUSE DROWSINESS AND IRRITATE NOSE AND THROAT. DEGREE OF
EFFECTS DEPENDS ON CONCENTRATION AND LENGTH O F EXPOSURE. INGEST:SMALL
AMOUNTS TRANSFERRED TO THE MOUTH BY FINGERS DURING USE, ETC., SHOULD NOT
INJURE. SWALLOWING LARGE AMOUNTS MAY INJURE SLIGHTLY. CHRONIC:NONE LISTED BY
MANUFACTURER.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|