| MSDS | : | NO 1 DIESEL FUEL | | CAS | : | 8008-20-6
111-65-9
111-84-2
71-43-2
108-88-3
106-42-3
108-38-3
95-47-6
108-67-8
95-63-6
526-73-8 | | NAME | : | kerosene (aliphatic hydrocarbon) (may include any/all the
paraffinic hydrocarbons (includes ients 3 & 4)
octane
nonane
naphthenes
aromatic hydrocarbons (includes ients 7, 8, 9, 10,
benzene (sara iii)
toluene (sara iii)
p-xylene (p-dimethylbenzene) (sara iii)
m-xylene (m-dimethylbenzene) (sara iii)
o-xylene (o-dimethylbenzene) (sara iii)
1,3,5-trimethylbenzene (mesitylene)
1,2,4-trimethylbenzene (sara iii)
1,2,3-trimethylbenzene
sulfur compounds
|
| |
|
|
===================== Product Identification =====================
MSDS NAME:NO 1 DIESEL FUEL
NIIN:00-419-0450
MSDS Number: BKSRJ
=== Responsible Party ===
Company:PHILLIPS CHEMICAL COMPANY
Address:758 ADAMS BLDG
City:BARTLESVILLE
State:OK
ZIP:74004
Country:US
Info Phone Num:918-661-8327
Emergency Phone Num:918-661-3865/8118
CAGE:FO153
=== Contractor Identification ===
Company:PHILLIPS CHEMICAL CO/BARTLESVILLE, OK 74004
CAGE:FO153
Company:PHILLIPS PETROLEUM CO
Address:613 ADAMS
Box:City:BARTLESVILLE
State:OK
ZIP:74004
Country:US
Phone:800-234-6603
CAGE:46935
============= Composition/Information on Ingredients =============
Name:KEROSENE (ALIPHATIC HYDROCARBON) (MAY INCLUDE ANY/ALL THE
FOLLOWING INGREDIENTS.)
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
Name:PARAFFINIC HYDROCARBONS (INCLUDES INGREDIENTS 3 & 4)
Fraction by Wt: >50%
Other REC Limits:NONE RECOMMENDED
Name:OCTANE
CAS:111-65-9
RTECS #:RG8400000
Fraction by Wt: >1.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM/375 STEL
ACGIH TLV:300 PPM/375STEL;9293
Name:NONANE
CAS:111-84-2
RTECS #:RA6115000
Fraction by Wt: >3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM; 9192
Name:NAPHTHENES
Fraction by Wt: <33%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Name:AROMATIC HYDROCARBONS (INCLUDES INGREDIENTS 7, 8, 9, 10,
11, 12, 13 & 14.)
Fraction by Wt: <17%
Other REC Limits:NONE RECOMMENDED
Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: <0.8%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:P-XYLENE (P-DIMETHYLBENZENE) (SARA III)
CAS:106-42-3
RTECS #:ZE2625000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:M-XYLENE (M-DIMETHYLBENZENE) (SARA III)
CAS:108-38-3
RTECS #:ZE2275000
Fraction by Wt: <3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/15OSTEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:O-XYLENE (O-DIMETHYLBENZENE) (SARA III)
CAS:95-47-6
RTECS #:ZE2450000
Fraction by Wt: <1.4%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:1,3,5-TRIMETHYLBENZENE (MESITYLENE)
CAS:108-67-8
RTECS #:OX6825000
Fraction by Wt: <1.4%
Other REC Limits:NONE SPECIFIED
Name:1,2,4-TRIMETHYLBENZENE (SARA III)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: <3.8%
Other REC Limits:NONE SPECIFIED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9192
Name:1,2,3-TRIMETHYLBENZENE
CAS:526-73-8
RTECS #:DC3300000
Fraction by Wt: 1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Name:SULFUR COMPOUNDS
Fraction by Wt: <0.3%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:PRODUCT IS IRRITATING TO BODY TISSUES.
COMPONENTS OF THE BLEND HAVE BEEN DESIGNATED AS CARCINOGENIC,
MUTAGENIC, IRRITANT AND KIDNEY/LIVER/REPRODUCTIVE TOXIN. IN
ADDITION, DIESEL EXHAUST, HAS BEEN ASS OCIATED WITH LUNG CANCER IN
ANIMALS.
Explanation of Carcinogenicity:CONTAINS B [71-43-2] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE:IRRITATION, STINGING.
SKIN:PROLONGED/REPEATED SKIN CONTACT MAY CAUSE SEVERE SKIN
IRRITATION. INHALED:HEADACHE, NAUSEA, SEDATION. INGESTED:G/I
IRRITATION. IF SWALLOWED, MAY BE ASPIRATED RESULTING IN
INFLAMMATION AND POSSIBLE FLUID ACCUMULATION IN LUNGS.
Medical Cond Aggravated by Exposure:NO INFORMATION GIVEN ON MSDS BY
MFR.
======================= First Aid Measures =======================
First Aid:IF IRRITATION PERSISTS OR IS SEVERE, SEE A DOCTOR. EYE:FLUSH
W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH SOAP & WATER. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. INHALED:REMOVE TO
FRES H AIR. AID/RESTORE BREATHING IF NECESSARY. INGESTED:DO NOT
INDUCE VOMITING. GIVE 2 LARGE GLASSES OF MILK OR WATER TO DILUTE &
GET IMMEDIATE MEDICAL CARE. NOTHING BY MOUTH IF UNCONSCIOUS.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>100F,>38C
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:EVACUATE AREA. USE NIOSH APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT TO FIGHT FIRE. USE WATER SPRAY TO COOL EXPOSED
CONTAINERS. DIRECT WATER SPRAY MAY SPREAD FIRE
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG GROUND OR FLOOR, THEN 'FLASH BACK' FROM A DISTANT
IGNITION SOURCE. TOXIC FUMES & GASES ARE PRODUCED BY FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR PROTECTIVE EQUIPMENT. SHUT
OFF SOURCE IF POSSIBLE & CONTAIN SPILL. PROTECT FROM IGNITION. KEEP
OUT OF WATER SOURCES AND SEWERS. ABSORB IN DRY INERT MATERIAL.
TRANSFER TO DISPOSAL D RUMS USING NON-SPARKINGG EQUIPMENT.
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY MFR.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, FLAME.
STORE IN WELL VENTILATED AREA. GROUND CONTAINERS DURING TRANSFER.
STORE IN CLOSED CONTAINER.
Other Precautions:DO NOT GET IN EYS, ON SKIN OR CLOTHING. DO NOT
BREATHE VAPORS. DO NOT SWALLOW-MAY BE ASPIRATED INTO LUNGS. WEAR
PROTECTIVE EQUIPMENT IF CONDITIONS WARRENT. USE WITH ADEQUATE
VENTILATION. REMOVE & LAUN DER CONTAMINATED CLOTHING BEFORE RESE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR CONCENTRATIONS EXCEEDING RECOMMENDED LEVEL,
USE NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR. FOR SPILL OR IF
CONCENTRATION IS UNKNOWN, USE NIOSH/MSHA SUPPLIED AIR RESPIRATOR.
IF IDLH, USE SCBA.
Ventilation:USE ADEQUATRE VENTILATION TO CONTROL BELOW RECOMMENCED
EXPOSURE LEVELS.
Protective Gloves:IMPERVIOUS (NEOPRENE OR NITRILE)
Eye Protection:SAFDETY GLASSES, GOGGLES OR FACE SHIELD
Other Protective Equipment:PROTECTIVE GARMENTS TO PREVENT SKIN CONTACT.
Work Hygienic Practices:MFR: ? HMIS:USE GOOD INDUSTRIAL HYGIENE
PRACTICE. AVOID UNNECESSARY CONTACT. WASH THOROUGHLY BEFORE EATING
OR DRINKING.
Supplemental Safety and Health
KEY2:KT
================== Physical/Chemical Properties ==================
HCC:F4
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:<1
Spec Gravity:0.84
Viscosity:8 CST @ -4F
Evaporation Rate & Reference:<1 ETHER = 1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID, MILD ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXYGEN AND STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CARBON OXIDES AND VARRIOUS
HYDROCARBONS AR FORMED WHEN BURNED.
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:(INSURE CONFORMITY WITH ALL APPLICABLE DISPOSAL
REGULATIONS.) INCINERATE OR OTHERWISE MANAGE AT A RCRA PERMITTED
MANAGEMENT FACILITY.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|