=====================  Product Identification  =====================

MSDS NAME:PLASITE 4300 PART 1, 4300A000A-03
NIIN:00N033933
Kit Part:Y
MSDS Number: BPVYY
=== Responsible Party ===
Company:WISCONSIN PROTECTIVE COATINGS
Address:614 ELIZABETH ST
Box:8147
City:GREEN BAY
State:WI
ZIP:54308
Country:US
Info Phone Num:414-437-6561
Emergency Phone Num:414-437-6561;800-424-9300(CHEMTREC)
CAGE:22991
=== Contractor Identification ===
Company:WISCONSIN PROTECTIVE COATING CORP
CAGE:22991

=============  Composition/Information on Ingredients  =============

Name:VINYL ESTER RESIN
CAS:68002-44-8
Fraction by Wt: 30-70%

Name:STYRENE; (STYRENE, VINYL BENZENE)
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 30-70%
OSHA PEL:100 PPM
ACGIH TLV:S,50PPM/100STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:YES	 OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION TO EYES, NOSE,
    THROAT & SKIN IN HIGH VAPOR CONC. LIQ MAY CAUSE EYE IRRIT. CHRONIC:
    LIQ MAY CAUSE SKIN SENSITIZATION. REPORTS HAVE ASSOCIATED REPEATED
    PROLONGED OCCUPATIONAL OVEREXPOS URE TO SOLVENTS WITH PERMANENT
    BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:STYRENE: GROUP 2B(IARC).
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ASTHMATIC-TYPE CONDITIONS, OTHER
    CHRONIC RESPIRATORY DISEASES OR SKIN SENSITIZATION.

=======================  First Aid Measures  =======================

First Aid:INHAL: REMOVE TO FRESH AIR. RESTORE BREATHING. TREAT
    SYMPTOMATICALLY. CONSULT A PHYSICIAN. EYES: FLUSH WITH WATER FOR AT
    LEAST 15 MINUTES. TAKE TO A PHYSICIAN. SKIN: WASH WITH SOAP AND
    WATER. REMOVE C ONTAMINATED CLOTHING. CONSULT A PHYSICIAN. INGEST:
    DRINK WATER TO DILUTE. DO NOT INDUCE VOMIT. CONSULT POISON CONTROL
    CENTER OR PHYSICIAN IMMEDIATELY. TREAT SYMPTOMATICALLY.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:88.0F,31.1C
Lower Limits:1.1%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP. H*2O
    MAY BE EFTIVE. DECOMP PROD FROM BURNING ARE NOT FULLY KNOWN BUT
    WOULD BE HLTH HAZ. SYMP MAY NOT (SUPP DATA)
Unusual Fire/Explosion Hazard:LIQ IS FLAMM. VAPS IN CORRECT CONC CAN
    EXPLODE IF EXPOS TO SPARKS/FLAME, HOT SURF, & MAY EXPLODE IF
    EXPOSED TO HEAT. H*2O MAY BE USED TO COOL CONTRS.(SUPP DATA)

==================  Accidental Release Measures  ==================

Spill Release Procedures:REMOVE ANY POSSIBLE SOURCE OF IGNITION. NO
    SMOKING. VENTILATE ENCLOSED SPACES. RECOVER FREE LIQUID. ABSORB
    W/DRY, INERT MATERIAL. AVOID BREATHING VAPORS; WEAR A NIOSH/MSHA
    APPROVED PROPERLY FITTED RES PIRATOR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:KEEP CONTAINERS CLOSED. KEEP AWAY FROM
    HEAT & OPEN FLAME. STORE IN A NO SMOKING AREA.
Other Precautions:AVOID PROLONGED OR REPEATED BREATHING OF VAPORS.
    AVOID PROLONGED CONTACT WITH SKIN. AVOID BREATHING DUST FROM
    SANDING, BLASTING, OR ABRADING DRY COATING.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IN CONFINED AREAS USE NIOSH/MSHA APPRVD
    AIR-SUPPLIED MASK WHEN SPRAYING. IN AREAS W/RESTRICTED VENT A
    NIOSH/MSHA APPRVD ORG-VAP & DUST RESPIRATOR MAY BE SUFFICIENT.
Ventilation:USE ONLY W/ADEQ VENT. USE NIOSH/MSHA APPRVD EXPLO-PROOF
    LIGHTING & VENT EQUIP. NO SMOKING/OPEN LIGHTS. LOCAL (SUPP DATA)
Protective Gloves:NEOPRENE/OTHER SOLV RESISTANT MATL.
Eye Protection:CHEM WORK GOG OR FULL LNGTH FSHLD.
Other Protective Equipment:USE NIOSH/MSHA APPROVED EXPLOSION-PROOF
    LIGHTING. CLEAN COVERALLS AND RUBBER SOLED SHOES.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE. CLEAN MATL OFF
    HANDS BEFORE EAT, USING TOILET FACILITIES/SMOKING. NO SMOKING (SUPP
    DATA)
Supplemental Safety and Health
% VOLAT:53.08 +/-4%. FIRE FIGHT PROC: BE IMMED APPARENT. OBTAIN MED
    ATTN. EXPLO HAZ: USE EXPLO-PROOF LIGHTING ONLY. VENT: EXHAUST (WHEN
    APPLYING COATING): FACE VELOCITY >60FPM. HYGIENE PRACT: WHILE US
    ING OR WHILE CONTAINERS ARE OPEN.

==================  Physical/Chemical Properties  ==================

HCC:F4
Boiling Pt:B.P. Text:293F,145C
Vapor Pres:4.50@68F
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH METAL SALTS AND UNINTENDED CONTACT WITH PEROXIDES.
Stability Condition to Avoid:INADVERTENT OVER CATALYZATION. AVOID
    EXPOSURE TO DIRECT SUNLIGHT OR TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION PRODUCES CO AND
    OTHER TOXIC GASES.

====================  Disposal Considerations  ====================

Waste Disposal Methods:RUN-OFF TO WATERWAY CREATES FIRE HAZARD. DISPOSE
    OF IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***