===================== Product Identification =====================
MSDS NAME:AROMATIC NAPHTHA TT-N-97
NIIN:00-223-9066
MSDS Number: BTPKB
=== Responsible Party ===
Company:CHEMICAL COMMODITIES AGENCY INC
Address:27447 PACIFIC ST
City:HIGHLAND
State:CA
ZIP:92346-2640
Country:US
Info Phone Num:714-864-2310
Emergency Phone Num:714-864-2310
Preparer's Name:C A EISENHARD
CAGE:60777
=== Contractor Identification ===
Company:CHEMICAL COMMODITIES AGENCY, INC.
Address:27447 PACIFIC STREET
Box:City:HIGHLAND
State:CA
ZIP:92346-2640
Country:US
Phone:909-864-2310
CAGE:60777
============= Composition/Information on Ingredients =============
Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 45%
Other REC Limits:375 MG/CUM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 36%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:ALIPHATIC HYDROCARBON *94-2*
CAS:64752-48-9
Fraction by Wt: 19%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE & THROAT IRRITATION,
DEATH. EYES: IRRITATION, BURNING. SKIN: DERMATITIS.
PROLONGED/REPEATED EXPOSURE TO HIGH CONCENTRATIONS MAY CAUSE LIVER,
KIDNEY & NEURAL DYSFUNCTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, HEADACHE, VOMITING, COMA,
BURNING, DRYNESS, LOSS OF APPETITE, NOSE BLEEDING.
Medical Cond Aggravated by Exposure:SKIN, EYE & RESPIRATORY CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED. EYES:
FLUSH W/WATER FOR 15 MINS. SKIN: WASH AREA W/SOAP & WATER.
INGESTION: DON'T INDUCE VOMITING. ASPIRATION HAZARD. OBTAIN MEDICAL
ASSISTANCE IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point: 35F
Lower Limits: 1
Upper Limits: 7
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2, ALCOHOL FOAM. DON'T
USE A DIRECT WATER STREAM.
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE GEAR. USE WATER
SPRAY TO COOL NEARBY CONTAINERS & STRUCTURES EXPOSED TO FIRE.
EXTINGUISH ALL NEARBY SOURCES OF IGNITION.
Unusual Fire/Explosion Hazard:AVOID ACCUMULATION OF WATER BECAUSE THIS
PRODUCT WILL FLOAT & MAY REIGNITE ON THE SURFACE OF THE WATER.
VAPORS MAY TRAVEL TO A DISTANT IGNITION SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:EXTINGUISH ALL IGNITION SOURCES. MAKE SURE ALL
HANDLING EQUIPMENT IS ELECTRICALLY GROUNDED. MOP UP & PLACE INTO
DOT CONTAINERS. FOR LARGER SPILLS DIKE W/SOIL/OTHER NON-COMBUSTIBLE
ABSORBENT MATERIALS & THEN PUMP INTO DOT CONTAINERS.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, FLAMES,
INCOMPATIBLE MATERIALS. STORE IN A COOL, DRY, WELL-VENTILATED AREA.
Other Precautions:VENT CONTAINERS FREQUENTLY (MORE OFTEN IN WARM
WEATHER) TO RELIEVE PRESSURE. DON'T USE PRESSURE TO EMPTY
CONTAINER. DON'T CUT, GRIND, WELD/DRILL ON/NEAR THIS CONTAINER.
VAPORS ARE HEAVIER THAN AIR & W ILL COLLECT IN LOW PLACES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:BASED UPON CONTAMINATION LEVELS IN THE WORK
PLACE. FOR EXAMPLE: A SUPPLIED AIR RESPIRATOR.
Ventilation:LOCAL MECHANICAL EXHAUST
Protective Gloves:IMPERVIOUS
Eye Protection:CHEMICAL GOGGLES
Other Protective Equipment:IMPERVIOUS CLOTHING, EYE WASH FOUNTAIN,
QUICK DRENCH SHOWER
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
DON'T ENTER AREAS UNLESS RESPIRATORY PROTECTION IS WORN/AN OBSERVER IS
PRESENT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text: 220F
Vapor Density: 3.4
Spec Gravity:0.85
Evaporation Rate & Reference:(BU AC = 1): 2
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID W/AROMATIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME
Hazardous Decomposition Products:CO, CO2 & UNIDENTIFIED ORGANIC
COMPOUNDS IN BLACK SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP OUT OF SEWERS, STORM DRAINS, SURFACE WATERS
& SOIL. DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|