===================== Product Identification =====================
MSDS NAME:T16-16 TITE-SEAL UNDERCOATING AEROSOL
NIIN:00-269-0025
MSDS Number: BTPKD
=== Responsible Party ===
Company:RADIATOR SPECIALTY COMPANY
Address:1400 W. INDEPENDENCE BLVD
City:CHARLOTTE
State:NC
ZIP:28208
Country:US
Info Phone Num:707-377-6555
Emergency Phone Num:707-377-6555
Preparer's Name:I LIEBMAN
CAGE:77628
=== Contractor Identification ===
Company:RADIATOR SPECIALTY COMPANY
Address:1900 WILKINSON BLVD.
Box:34689
City:CHARLOTTE
State:NC
ZIP:28208
Country:US
Phone:704-377-6555/303-623-5716
CAGE:77628
============= Composition/Information on Ingredients =============
Name:ASPHALT OXIDE *94-2*
CAS:64742-93-4
Fraction by Wt: 20%
Name:TALC/PYROPHYLLITE
Fraction by Wt: 6%
Name:ATTAPULGITE CLAY, HYDROUS MAGNESIUM ALUMINUM SILICATE
CAS:12174-11-7
RTECS #:RT6400000
Fraction by Wt: 4%
Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 3%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 5%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Name:ISOBUTANE/PROPANE MIXTURE
Fraction by Wt: 4-10%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. SKIN:
IRRITATION. INGESTION: HARMFUL/FATAL. INHALATION: NAUSEA, HEADACHE,
DIZZINESS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: SEVERE IRRITATION. SKIN: IRRITATION.
INGESTION: HARMFUL/FATAL. INHALATION: NAUSEA, HEADACHE, DIZZINESS.
======================= First Aid Measures =======================
Eyes: FLUSH W/WATER THOROUGHLY FOR 15 MINS. SKIN: WASH W/SOAP
& WATER THOROUGHLY. INHALATION: MOVE TO FRESH AIR IMMEDIATELY.
INGESTION: DON'T INDUCE VOMITING. DON'T ADMINISTER
EPINEPHRINE/ADRENALIN. O BTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>145F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WATER SPRAY TO COOL. PROTECT EYES FROM
VENTING, RUPTURING, & BURSTING CONTAINERS.
Unusual Fire/Explosion Hazard:AT ELEVATED TEMPERATURES, CONTAINERS MAY
VENT, RUPTURE, BURST VIOLENTLY.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE IGNITION SOURCES.
CONFINE, WIPE W/RAGS, TRANSFER TO WASTE DUMP. OBSERVE HEALTH
HAZARDS.
====================== Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL PLACE BELOW 120F AWAY
FROM ACIDS, OXIDIZING AGENTS & IGNITION SOURCES.
Other Precautions:WEARING CONTACT LENSES IS INADVISABLE. DON'T
PUNCTURE/INCINERATE CONTAINERS. KEEP AWAY FROM CHILDREN & ANIMALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:BULK HANDLING: IF TLV IS EXCEEDED, WEAR NIOSH
APPROVED RESPIRATOR.
Ventilation:CONSUMER: ADEQUATE. BULK HANDLING: GENERAL.
Protective Gloves:BULK HANDLING: RUBBER.
Eye Protection:BULK HANDLING: GOGGLES.
Other Protective Equipment:BULK HANDLING: APRON.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>275F
Vapor Density:>1
Spec Gravity:1.03
Evaporation Rate & Reference:(BU AC=1): <1
Solubility in Water:INSOLUBLE
Appearance and Odor:COARSE FAN SPRAY W/BLACK SPRAYED FILM. ASPHALTIC
ODOR.
Percent Volatiles by Volume: 70/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ACIDS
Stability Condition to Avoid:HIGH TEMPERATURES, IGNITION SOURCES
Hazardous Decomposition Products:ACRID SMOKE, CO2, CO, OXIDES OF
NITROGEN, OXIDES OF SULFUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/FEDERAL, STATE, LOCAL
REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|