Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE/THROAT IRRITATION,
NERVOUS SYSTEM DEPRESSION. REPORTS HAVE ASSOCIATED
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS W/PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE. SKIN: REPEATED/PROLONGED L IQUID CONTACT MAY
CAUSE IRRITATION W/DISCOMFORT & DERMATITIS. EYES: MAY CAUSE
IRRITATION/BURNING.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA,
STAGGERING, GAIT, CONFUSION, UNCONSCIOUSNESS & BURNING. QUARTZ
CRYSTALLINE SILICA: REPEATED OVEREXPOSURE TO CRYSTALLINE SILICA MAY
LEAD TO TYPICAL X-RAY CHANGE S & CHRONIC LUNG DISEASE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE CPR.
EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH W/SOAP &
WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:100-140F
Lower Limits:0.7
Upper Limits:7
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:IT IS RECOMMENDED TO WEAR FULL PROTECTIVE
EQUIPMENT, INCLUDING SCBA. WATER FROM FOG NOZZLES MAY BE USED TO
PREVENT PRESSURE BUILD-UP.
Unusual Fire/Explosion Hazard:WHEN HEATED > FLASHPOINT, EMITS FLAMMABLE
VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLOSIVE. FINE
MIST/SPRAYS MAY BE FLAMMABLE AT TEMP < THE FLASH POINT.
Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT & BREATHING OF VAPOR. CONFINE & REMOVE W/INERT
ABSORBENT.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
CLOSED CONTAINER AFTER EACH USE. GROUND CONTAINERS WHEN POURING.
DON'T STORE > 120F.
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/O A
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION.
Respiratory Protection:WEAR A PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA FOR USE W/PAINTS DURING
APPLICATION & UNTIL ALL VAPORS & SPRAY MISTS ARE EXHAUSTED.
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO KEEP CONTAMINANTS <
APPLICABLE OSHA REQUIREMENTS & OTHER SUGGESTED EXPOSURE LIMITS.
Protective Gloves:NEOPRENE
Eye Protection:GOGGLES, SAFETY GLASSES W/SPLASH GUARD
Other Protective Equipment:SIDE SHIELDS, COVERALLS
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
Boiling Pt:B.P. Text: 210.2-437F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:APPRECIABLE
Appearance and Odor:LIQUID
Percent Volatiles by Volume:74.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS & FLAME.
Hazardous Decomposition Products:CO, CO2, SMOKE, OXIDES OF HEAVY
METALS.
Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL IAW/LOCAL, STATE & FEDERAL
REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINERS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.