| MSDS | : | 35-913/35-914 SONOLASTIC SL-1 LIMESTONE & GRAY | | CAS | : | 8052-41-3
112945-52-5
584-84-9
14807-96-6
1305-78-8
13463-67-7
14808-60-7 | | NAME | : | stoddard solvent (petroleum distillate), mineral spirits
silica, amorphous fumed (iarc, group 3) *94-3*
toluene-2,4-diisocyanate (tdi) (animal sufficient evidence
vol organic cmpd: 75.2 g/l
talc (powder), (asbestos free), talcum; hydrous magnesium
calcium oxide; lime
titanium dioxide, tio2 (suspected animal carcinogen by
silicon dioxide, crystalline quartz, sand (animal
|
| |
|
|
===================== Product Identification =====================
MSDS NAME:35-913/35-914 SONOLASTIC SL-1 LIMESTONE & GRAY
NIIN:00F036323
MSDS Number: BVRMZ
=== Responsible Party ===
Company:CHEMREX INC SONNEBORN BLDG PRODUCTS
Address:889 VALLEY PARK DRIVE
City:SHAKOPPE
State:MN
ZIP:55379
Country:US
Info Phone Num:800-243-6739/612-496-6000
Emergency Phone Num:800-243-6739/612-496-6000
Preparer's Name:MARK HORTON
CAGE:GO328
=== Contractor Identification ===
Company:CHEMREX INC SONNEBORN BLDG PRODUCTS
Address:889 VALLEY PARK DRIVE
City:SHAKOPEE
State:MN
ZIP:55379-5000
Country:US
Phone:800-243-6739/612-496-6027
CAGE:GO328
Company:SONNEBORN BUILDING PRODUCTS REXNORD CHEM PROD
Address:7711 COMPUTER AVE
Box:City:MINNEAPOLIS
State:MN
ZIP:55435
Country:US
Phone:612-835-3434;800-424-9300(CHEMTREC)
CAGE:63472
============= Composition/Information on Ingredients =============
Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 5-10%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Name:SILICA, AMORPHOUS FUMED (IARC, GROUP 3) *94-3*
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 3-7%
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.1 MG/CUM
Name:TOLUENE-2,4-DIISOCYANATE (TDI) (ANIMAL SUFFICIENT EVIDENCE
BY IARC)-GROUP 2B *94-3*
CAS:584-84-9
RTECS #:CZ6300000
Fraction by Wt: <0.1%
Other REC Limits:0.005 PPM
OSHA PEL:0.02 PPM, CEILING
ACGIH TLV:0.005 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Name:VOL ORGANIC CMPD: 75.2 G/L
RTECS #:9999999VO
Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 3-5%
ACGIH TLV:2 MG/CUM (RESP DUST)
Name:CALCIUM OXIDE; LIME
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: 1-3%
OSHA PEL:5 MG/CUM
ACGIH TLV:2 MG/CUM
Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN BY
IARC-GROUP 3) *94-3*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 3-5%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Name:SILICON DIOXIDE, CRYSTALLINE QUARTZ, SAND (ANIMAL
SUFFICIENT/HUMAN LIMITED EVIDENCE BY IARC, NTP). GROUP 2A - *94-3*
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <0.1%
Other REC Limits:0.05 MG/CUM NIOSH
ACGIH TLV:0.1 MG/CUM RESP DUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): >5800 MG/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE IRRITANT, REVERSIBLE
CORNEAL INJURY. SKIN: SEVERE IRRITANT, DERMATITIS, ALLERGIC
RESPONSE. INHALATION: SEVERE IRRITANT. ISOCYANATE: BRONCHITIS,
BRONCHIAL SPASMS, PULMONARY EDEMA. INGEST ION: IRRITATION.
REPEATED/PROLONGED OVEREXPOSURE TO SILICA MAY CAUSE SILICOSIS/LUNG
INJURY. (SEE SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITANT, TEARING, REDDENING, SWELLING,
BLISTERS, COUGHING, CHEST DISCOMFORT, SHORTNESS OF BREATH, RASH &
REDNESS.
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY/SKIN
CONDITONS.
======================= First Aid Measures =======================
Eyes: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH
THOROUGHLY W/SOAP & WATER. WIPE/FLUSH W/ISOPROPYL ALCOHOL. WASH
AGAIN THOROUGHLY W/SOAP & WATER. INHALATION: MOVE TO FRESH AIR.
GIVE OXYGEN/CPR AS NEEDED. INGESTION: DON'T INDUCE VOMITING. KEEP
VICTIM'S HEAD BELOW HIPS TO AVOID ASPIRATION OF VOMITUS INTO THE
LUNGS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:145F
Lower Limits:0.9
Upper Limits:7
Extinguishing Media:WATER SPRAY (FOG), FOAM, DRY CHEMCAL/CO2
Fire Fighting Procedures:WEAR SCBA/AIR MASKS. CONTIANERS SHOULD BE KEPT
COOL W/WATER SPRAY. A WATER STREAM DIRECTED INTO THE FIRE MAY CAUSE
FROTHING W/SUBSEQUENT SPREAD OF FIRE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO HEAT. VAPOR IS HEAVIER THAN AIR & MAY TRAVEL ALONG THE
GROUND/FLOOR & IGNITE AT LOCATIONS DISTANT FROM THE SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE/REMOVE IGNITION SOURCES. SMALL: WIPE
UP W/RAGS/TOWELS/PUT IN LOOSELY COVERED CONTAINERS IN A
WELL-VENTILATED AREA. LARGE: WEAR RESPIRATOR. DIKE/IMPOUND/COVER
W/ABSORBENT. USE NON-SPARKING TO OLS TO SWEEP/SHOVLE INTO
CONTAINERS. (SEE SUPP)
====================== Handling and Storage ======================
Handling and Storage Precautions:DON'T BREATHE VAPORS. USE ONLY
W/ADEQUATE VENTILATION. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:DON'T TAKE INTERNALLY. WEAR PROTECTIVE CLOTHING AT
ALL TIMES. AVOID CONTACT W/EYES, CLOTHING & SKIN. KEEP OUT OF REACH
OF CHILDREN. AVOID USING NEOPRENE GLOVES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATORY PROTECTION
WHEN THE PRODUCT IS MIXED/APPLIED IN A POORLY VENTILATED AREA/IF
WORKPLACE LEVELS OF INGREDIENTS EXCEED THE TLV.
Ventilation:USE LOCAL EXHAUST AS NEEDED TO KEEP VAPOR/DUST LEVELS BELOW
RECOMMENDED LIMITS.
Protective Gloves:NATURAL, BUTYL RUBBER, POLYVINYL ALCOHOL
Eye Protection:GOGGLES
Other Protective Equipment:NITRILE GLOVES, CLEAN PROTECTIVE CLOTHING TO
COVER ARMS & LEGS.
Work Hygienic Practices:WASH THOROUGHLY AFTER USING. REMOVE/LAUNDER
CONTAMINATED CLOTHING/SHOES BEFORE REUSE.
Supplemental Safety and Health
ORAL LD50 INFORMATION IS FOR TOLUENE DIISOCYANATE. CHRONIC HEALTH
HAZARDS CONT'D: REPEATED EXPOSURE TO ISOCYANTES CAN LEAD TO SKIN
SENSITIZATION, CHEMICAL ASTHMA/ASTHMATIC CONDITIONS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:240-450F
Vapor Pres:4
Vapor Density:>1
Spec Gravity:1.1
Evaporation Rate & Reference:SLOWER THAN N-BU AC
Solubility in Water:<0.1%
Appearance and Odor:SMOOTH PIGMENTED VISCOUS LIQUID W/TYPICAL PAINT
THINNER ODOR.
Percent Volatiles by Volume:8-10
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, AMINES, STRONG OXIDANTS, STRONG BASES/ACIDS.
Stability Condition to Avoid:HEAT, ELEVATED TEMPERATURES, SOURCES OF
IGNITION, MOISTURE
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN, HYDROGEN
CYANIDE GAS, OTHER ACRIDS & TOXIC FUMES.
Conditions to Avoid Polymerization:MOISTURE & MATERIALS THAT REACT
W/ISOCYANATES
==================== Disposal Considerations ====================
Waste Disposal Methods:RINSE AREA W/WATER & FLUSH RINSINGS TO SANITARY
SEWER/SOAK UP W/ABSORBENTS. DON'T DISCHARGE UNDILUTED PRODUCT TO
THE SANITARY SEWER/LAKES/STREAMS/PONDS. DISPOSE IAW/LOCAL, STATE &
FEDERAL REGULATIONS. DON'T INCINERATE CLOSED CONTAINERS. NA1993.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|