Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MANUFACTURER STATES,"PRODUCT HAS BEEN
USED FOR YEARS WITH NO KNOWN ILL EFFECTS. IT CONTAINS NO KNOWN
CARCINOGENS OT MUTAGENS AS DEFINED BY OSHA OR IARC." PRODUCT IS
VERY MILDLY IRRITATING TO BODY TI SSUES. MOST LIKELY HAZARD IS
THAT OF BREATHING THE MIST OR VAPORS SHOULD THE PRODUCT BE HEATED
OR MISTED.
Explanation of Carcinogenicity:THE PRODUCT CONTAINS NO INGREDIENT THAT
IS LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE:MILD IRRITATION. SKIN:POSSIBLE MILD
IRRITATION. INHALED:RESPIRATORY IRRITATION,POSSIBLE PULMONARY EDEMA
IF MIST IS INHALED. INGESTED:NONE GIVEN BY MANUFACTURER
(SUPPLIER).
Medical Cond Aggravated by Exposure:NONE REPORTED
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE. INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF
NECESSARY. INGESTED:D O NOT INDUCE VOMITING. GIVE 2 LARGE GLASSES
OF MILK OR WATER AND GET IMMEDIATE MEDICAL CARE. GIVE NOTHING BY
MOUTH IF UNCONSCIOUS. IF IRRITATION PERSISTS OR IS SEVERE,SEE A
DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:400F/204C
Autoignition Temp:Autoignition Temp Text:470F
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,FOAM,SAND/EARTH,WATER
FOG.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS.WATER
MAY CAUSE FROTHING.
Unusual Fire/Explosion Hazard:NONE
Spill Release Procedures:RECOVER AS LIQUID IF POSSIBLE. ADSORB
REMAINDER ON EARTH,SAND,SAWDUST,ETC. KEEP OUT OF DRAINS, SEWERS,
AND WATERWAYS. STORE IN CLOSED CONTAINERS PENDING DISPOSAL.
Neutralizing Agent:NONE
====================== Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA.
Other Precautions:NONE
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR OIL
MIST IF EXPOSURE IS ABOVE THE TLV/PEL. SEE 29 CFR 1910.134 FOR
REGULATIONS PERTAINING TO RESPIRATOR USE.
Ventilation:NORMAL ROOM VENTILATION SHOULD BE SUFFICIENT. SUPPLEMENT
WITH LOCAL EXHAUST IF NEEDED (OIL MIST).
Protective Gloves:NEOPRENE OR BUTYL RUBBER (OIL RESISTANT)
Eye Protection:SAFETY GLASSES OR SPLASH GOGGLES S
Other Protective Equipment:AS NEEDED TO PREVENT PROLONGED/REPEATED
CONTACT.
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE PRACTICE. MINIMIZE
PERSONAL CONTACT. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MSDS RECEIVER FROM NAVY. NAVY IDENTIFIED NSN. ALSO DOD LABEL WAS
SUPPLIED, THIS PROBABLY FILLED OUT BY NAVY.
Boiling Pt:B.P. Text:700F/371C
Melt/Freeze Pt:M.P/F.P Text:0F,-18C
Spec Gravity:0.88
Viscosity:5.6-7.4 CS
Solubility in Water:NIL
Appearance and Odor:FLUID OIL
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HEAT,IGNITION SOURCES SUCH AS SPARKS &
OPEN FLAME.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE, LOCAL REGULATIONS.
MFR SUGGESTS RECYCLE OR IF THAT IS NOT PRACTICLE TO INCINERATE.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.