| MSDS | : | 12-090 BEAD SEALER,RUBBER CEMENT | | CAS | : | 1330-20-7
100-41-4
108-88-3
106-88-7
79-01-6
75-09-2 | | NAME | : | xylene, dimethylbenzene, xylol (iarc - group 3) *95-4*
ethyl benzene *95-4*
toluene (iarc carc- group 3) *95-4*
1,2-butylene oxide (suspected animal carc by iarc, -
stabilizers (tea & n-but)
non-hazardous ients
trichloroethylene, tce, trichloroethene (suspected animal
dichloromethane (methylene chloride) (susp human carc by
|
| |
|
|
===================== Product Identification =====================
MSDS NAME:12-090 BEAD SEALER,RUBBER CEMENT
NIIN:00F046505
MSDS Number: BYNBJ
=== Responsible Party ===
Company:BRIDGE PRODUCTS, INC A.C.D
Address:500 S. 45TH STREET E.
City:MUSKOGEE
State:OK
ZIP:74403-5000
Country:US
Info Phone Num:918-687-5427
Emergency Phone Num:918-687-5427
CAGE:EO346
=== Contractor Identification ===
Company:BRIDGE PRODUCT INC/CAMEL TIRE CARE PRODUCTS DIV
Address:500S 45TH E
Box:769
City:MUSKOGEE
State:OK
ZIP:74403-5000
Country:US
Phone:918-687-5427
CAGE:97789
Company:BRIDGE PRODUCTS,INC A.C.D.; CAMEL TIRE CARE PRODS
Address:500 SOUTH 48TH STREET E.
Box:769
City:MUSKOGEE
State:OK
ZIP:74401-0769
Country:US
Phone:918-687-5427 / FAX 918-682-1635
CAGE:EO346
============= Composition/Information on Ingredients =============
Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *95-4*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 15-15.5%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:ETHYL BENZENE *95-4*
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 3.8-3.9%
Other REC Limits:100 PPM
OSHA PEL:435 MG/CUM
ACGIH TLV:434 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:TOLUENE (IARC CARC- GROUP 3) *95-4*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <1%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:1,2-BUTYLENE OXIDE (SUSPECTED ANIMAL CARC BY IARC, -
GROUP 3) *95-4*
CAS:106-88-7
RTECS #:EK3675000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Name:STABILIZERS (TEA & N-BUT)
Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 3-6%
Name:TRICHLOROETHYLENE, TCE, TRICHLOROETHENE (SUSPECTED ANIMAL
CARCINOGEN BY IARC - GROUP 3) *95-4*
CAS:79-01-6
RTECS #:KX4550000
Fraction by Wt: 47-48.5%
Other REC Limits:50 PPM
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Name:DICHLOROMETHANE (METHYLENE CHLORIDE) (SUSP HUMAN CARC BY
ACGIH, SUSP ANIM CARC BY IARC; NTP - IARC GROUP 2B) *95-4*
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 28.2-29%
ACGIH TLV:174 MG/CUM (A2)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION & SLIGHT CORNEAL
INJURY. SKIN: IRRITATION/BURN. TRICHLOROETHYLENE MAY BE ABSORBED TO
SOME DEGREE. INGESTION: MAY BE RAPIDLY ABSORBED & RESULT IN INJURY
TO BODY SYSTEMS, COULD CAUSE SE RIOUS INJURY/DEATH. INHALATION:
IRRITATION TO UPPER RESPIRATORY TRACT & MAY INCREASE SENSITIVITY TO
EPINEPHRINE.(SEE SUP
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:PAIN, IRRITATION, BURNS, DRYNESS, FLAKING,
UNCONSCIOUSNESS, IRREGULAR HEART-BEATS, REDDENING, DIZZINESS,
DRUNKNESS. METHYLENE CHLORIDE-BURNING SENSATION, COLD, NUMB
FEELING. TRICHLOROETHYLENE-INCREASI NG BLOOD, NUMBNESS OF FINGERS.
======================= First Aid Measures =======================
Eyes: IRRIGATE IMMEDIATELY W/WATER FOR 15 MINS. SKIN: WASH
OFF IN FLOWING WATER/SHOWER. INGESTION: DON'T INDUCE VOMITING.
INHALATION: REMOVE TO FRESH AIR. GIVE MOUTH TO MOUTH
RESUSCITATION/OXYGEN IF N EEDED. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:>140F
Lower Limits:1
Upper Limits:44.8
Extinguishing Media:WATER FOG, DRY CHEMICAL, FOAM/CO2.
Fire Fighting Procedures:WEAR POSITIVE PRESSURE SCBA/AIR-SUPPLIED FULLY
ENCAPSULATING SUIT. DON'T USE A DIRECT WATER STREAM. USE WATER
SPRAY TO COOL CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:MAY FORM FLAMMABLE VAPOR-AIR MIXTURES.
PRODUCT MAY FLOAT & REIGNITE ON SURFACE WATERS. VAPORS ARE > AIR &
MAY TRAVEL ALONG SURFACE TO DISTANT SOURCE/FLASHBACK.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: MOP/WIPE UP/SOAK UP IMMEDIATELY. REMOVE
TO OUT OF DOORS. LARGE: EVACUATE AREA. CONTAIN LIQUID; TRANSFER TO
CLOSED METAL CONTAINERS. KEEP OUT OF WATER SUPPLY. ALWAYS WEAR
APPROPRIATE PROTECTIVE EQUIPMENT.
====================== Handling and Storage ======================
Handling and Storage Precautions:HANDLE W/REASONABLE CARE. STORE IN A
COOL, DRY PLACE. DON'T ENTER AREAS WHERE VAPORS OF PRODUCT ARE USED
UNLESS SPECIAL BREATHING APPARATUS IS USED.
Other Precautions:AVOID BREATHING VAPORS. CONCENTRATED VAPORS OF
PRODUCT ARE > AIR & MAY COLLECT IN LOW AREAS SUCH AS PITS,
DEGREASERS, STORAGE TANKS & OTHER CONFINED AREAS. EMPTY CONTAINERS
HAVE RESIDUES, GASES & MIST S & ARE SUBJECT TO PROPER WASTE
DISPOSAL
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN RESPIRATORY PROTECTION IS REQUIRED, USE AN
APPROVED AIR-PURIFYING RESPIRATOR. WHERE EXPOSURE MAY EXCEED IN
CONFINED/POORLY VENTILATED AREAS, USE AN APPROVED POSITIVE-PRESSURE
SCBA.
Ventilation:USE ONLY ADEQUATE VENTILATION TO CONTROL AIRBORNE
CONCENTRATIONS < EXPOSURE GUIDLINES. LOCAL EXHAUST FOR SOME
OPERATIONS
Protective Gloves:IMPERVIOUS
Eye Protection:CHEMICAL GOGGLES
Other Protective Equipment:PROTECTIVE CLOTHING, BOOTS, APRON/FULL BODY
SUIT.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
HLTH HZRD CONT'D: INHALATION-MAY CAUSE ALCOHOL INTOLERANCE/EXCESSIVE
EXPOSURE MAY IMPAIR THE BLOODS ABILITY TO TRANSPORT OXYGEN. ALCOHOL
CONSUMED BEFORE/AFTER EXPOSURE MAY INCREASE ADVERSE EFFECTS & M AY
CAUSE CENTRAL PERIPHERAL NERVOUS SYSTEM EFFECTS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:104-289F
Vapor Pres:25-355
Vapor Density:>1
Spec Gravity:1.3
Solubility in Water:SLIGHT AT 77F
Appearance and Odor:COLORLESS LIQUID W/IRRITATING ODOR AT HIGH
CONCENTRATIONS
Percent Volatiles by Volume:>85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES, CAUSTIC SODA/POTASH. OXIDIZERS, METALLIC ALUMINUM & ZINC
POWDERS, AMINES, SODIUM, POTASSIUM & MAGNESIUM.
Stability Condition to Avoid:OPEN FLAMES, WELDING ARCS/HIGH TEMPS
Hazardous Decomposition Products:CO, CO2, HYDROGEN CHLORIDE, PHOSGENE &
CHLORINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN DISPOSING OF THE USUSED CONTENTS, SEND TO
LICENSED RECLAIMERS/TO PERMITTED INCINERATORS/ANY DISPOSAL PRACTICE
IAW/FEDERAL, STATE & LOCAL REGULATIONS. NON-FLAMMABLE LIQUID
UN1710.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|