===================== Product Identification =====================
MSDS NAME:SPX RECYCLED ANTIFREEZE-AUTOMOTIVE TYPE (50% IN WATER)
NIIN:00F048256
MSDS Number: BZFFH
=== Responsible Party ===
Company:PRESTONE PRODUCTS CORPORATION
Address:39 OLD RIDGEBURY ROAD
City:DANBURY
State:CT
ZIP:06810-5109
Country:US
Info Phone Num:203-830-7800
Emergency Phone Num:203-830-7800
Preparer's Name:JAMES L OTTOWITZ
CAGE:EO340
=== Contractor Identification ===
Company:PRESTONE PRODUCTS CORPORATION
Address:55 FEDERAL ROAD
City:DANBURY
State:CT
ZIP:06810
Country:US
Phone:203-830-7865
CAGE:EO340
============= Composition/Information on Ingredients =============
Name:ETHYLENE GLYCOL, GLYCOL *96-1*
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 40-75%
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 25-60%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INGESTION: MAY CAUSE CNS EFFECTS.
CARDIAC FAILURE & PULMONARY EDEMA MAY DEVELOP. SEVERE KIDNEY DAMAGE
OF ETHYLENE GLYCOL MAY BE FATAL. SEVERE POISONING & LIVER INJURY
MAY OCCUR. INHALATION: MAY CAUSE IRRITATION OF THE NOSE & THROAT.
EYES: MAY CAUSE PERSISTENT CONJUNCTIVITIS. SKIN: MAY CAUSE
SENSITIZATION & DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DISCOMFORT, PAIN, NAUSEA, VOMITING, DIZZINESS,
DROWSINESS, MALAISE, BLURRING VISION, IRRITABILITY, LUMBAR PAIN,
OLIGURIA, UREMIA, IRREGULAR EYE MOVEMENTS, CONVULSIONS, COMA,
WEAKNESS OF FACIAL MUSCLES , DIMINISHED HEARING, DIFFICULTY
W/SWALLOWING, HEADACHE, REDNESS, NYSTAGMUS.
Medical Cond Aggravated by Exposure:EXISTING KIDNEY DISEASE.
======================= First Aid Measures =======================
First Aid:INGESTION: GIVE 2 GLASSES OF WATER & INDUCE VOMITING. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. SKIN: WASH AREAS
W/SOAP & COPIOUS AMOUNTS OF WATER. INHALATION: REMOVE TO FRESH AIR.
GIVE O XYGEN/CPR IF NEEDED. EYES: FLUSH W/COPIOUS AMOUNTS OF CLEAN
WATER, USING STEADY STREAM FOR A MINIMUM OF 15 MINS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:(SEE SUPP)
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures:USE POSITIVE PRESSURE SCBA WHEN ENTERING A
CONFINED SPACE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROTECTIVE EQUIPMENT. SMALL:
FLUSH W/LARGE QUANTITIES OF WATER. LARGE: COLLECT FOR DISPOSAL.
====================== Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE IN OPEN/UNLABELED
CONTAINERS. KEEP CONTAINER AWAY FROM OPEN FLAMES & EXCESSIVE HEAT.
DON'T STORE IN OPEN/UNLABELED CONTAINERS.
Other Precautions:AVOID PROLONGED/REPEATED SKIN & EYE CONTACT. DON'T
DRINK ANTIFREEZE/SOLUTION. AVOID BREATHING VAPORS/MISTS. DON'T
CUT/WELD ON/NEAR CONTAINER, EVEN EMPTY. DON'T REUSE EMPTY
CONTAINERS UNLESS PROPERLY C LEANED. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE TLV MAY BE EXCEEDED, A NIOSH/MSHA APPROVED
RESPIRATOR W/AN ORGANIC VAPOR CARTRIDGE & A DUST/MIST PRE-FILTER/A
SUPPLIED AIR RESPIRATOR IS RECOMMENDED. FOR FIRE FIGHTING, USE
SCBA.
Ventilation:GENERAL FOR NORMAL USE AT AMBIENT TEMPS. LOCAL EXHAUST: TO
MAINTAIN EXPOSURE LEVELS BELOW APPLICABLE LIMITS.
Protective Gloves:CHEMICAL RESISTANT/NEOPRENE
Eye Protection:SPLASH PROOF GOGGLES
Other Protective Equipment:POLY VINYL COATED, PROTECTIVE CLOTHING,
SUITABLE WASHING & EYE FLUSHING FACILITIES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:226F
Melt/Freeze Pt:M.P/F.P Text:-34F
pH:9-10.5
Solubility in Water:100%
Appearance and Odor:GREEN ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES, STRONG ACIDS, STRONG OXIDIZING AGENTS & MATERIALS
REACTIVE W/HYDROXYL COMPOUNDS.
Stability Condition to Avoid:HIGH TEMPS, OPEN FLAMES, EXCESSIVE HEAT.
Hazardous Decomposition Products:THERMAL: CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN A FURNACE WHERE PERMITTED
IAW/FEDERAL, STATE & LOCAL REGULATIONS. AT VERY LOW CONCENTRATION
IN WATER, ETHYLENE GLYCOL IS READILY BIODEGRADABLE IN A BIOLOGICAL
WASTEWATER TREATMENT PLANT.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|