=====================  Product Identification  =====================

MSDS NAME:ROYCO 481
NIIN:00-231-6676
MSDS Number: BDLBP
=== Responsible Party ===
Company:ROYAL LUBRICANTS COMPANY INC.
Address:MERRY LN
Box:518
City:EAST HANOVER
State:NJ
ZIP:07936
Country:US
Info Phone Num:201-887-7410/201-887-8404
Emergency Phone Num:201-887-7410/800-424-9300(CHEMTREC)
CAGE:07950
=== Contractor Identification ===
Company:ROYAL LUBRICANTS CO INC  (REPLACED BY CAGE CODE 07950)
Address:MERRY LANE
Box:518
City:EAST HANOVER
State:NJ
ZIP:07936
Country:US
Phone:201-887-7410
CAGE:6V632
Company:ROYAL LUBRICANTS COMPANY INC.
Address:215 MERRY LN
Box:518
City:EAST HANOVER
State:NJ
ZIP:07936
Country:US
Phone:973-887-7411/7410
CAGE:07950

=============  Composition/Information on Ingredients  =============

Name:HYDROTREATED LIGHT NAPHTHENIC DISTILLATE/MINERAL OIL
CAS:64742-53-6
RTECS #:PY8036000
Fraction by Wt: 95 - 98%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)

Name:SOLVENT REFINED,HYDROTREATED MIDDLE PETROLEUM DISTILLATE
CAS:64742-46-7
RTECS #:JN9379645
Fraction by Wt: 2 - 3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST

Name:MINOR ADDITIVES
Fraction by Wt: < 2%
Other REC Limits:NONE RECOMMENDED

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
    & GI TRACTS. ACUTE- LUBRICATING OILS ARE GENERALLY CONSIDERED NO
    MORE THAN MINIMALLY IRRITATING TO EYES & SKIN. INHALATION OF VAPOR
    (GENERATED AT HIGH TEMPERATURE S ONLY)/OIL MIST MAY CAUSE MILD
    IRRITATION OF RESPIRATORY TRACT. ASPIRATION HAZARD IF SWALLOWED.
    CHRONIC- DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, DERMATITIS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
    DISORDERS OR EYE PROBLEMS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF
    THIS PRODUCT.

=======================  First Aid Measures  =======================

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH
    AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:IMMEDIATELY FLUSH WITH
    WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. SKIN:WASH WITH PLENTY OF
    SOAP & WATE R. ORAL:DO NOT INDUCE VOMITING. SEEK MEDICAL ATTENTION.
    IF VOMITING OCCURS, KEEP HEAD BELOW HIPS. DO NOT GIVE ANYTHING BY
    MOUTH TO AN UNCONSCIOUS PERSON.

=====================  Fire Fighting Measures  =====================

Flash Point Method:COC
Flash Point:290F,143C
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
    USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
    REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
    WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
    SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC GASES MAY BE FORMED.

==================  Accidental Release Measures  ==================

Spill Release Procedures:PICK UP SPILL WITH INERT MATERIAL SUCH AS
    SAND, CLAY, EARTH. SHOVEL INTO CONTAINERS FOR DISPOSAL. PREVENT
    RUN-OFF TO ENTER WATERWAYS, SEWERS. THIS IS AN OIL. SPILLS INTO OR
    LEADING TO SURFACE WATER TH AT CAUSE A SHEEN MUST BE REPORTED:
    800-424-8802.
Neutralizing Agent:NOT RELEVANT

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED PLACE
    AWAY FROM STRONG OXIDIZERS. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID CONTACT WITH EYES AND SKIN. WASH THOROUGHLY
    AFTER HANDLING. LAUNDER CLOTHING BEFORE REUSE. AVOID INHALING
    MISTS. DO NOT TAKE INTERNALLY.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NONE NORMALLY REQUIRED. IF WORKING IN CONFINED
    AREAS, IF EXCESSIVE MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES
    EXCEED RECOMMENDED PERMISSIBLE EXPOSURE LIMITS (PEL), WEAR
    NIOSH-APPROVED ORGANIC VAPO R RESPIRATOR.
Ventilation:GENERAL ROOM VENTILATION SHOULD BE SUFFICIENT.
Protective Gloves:NITRILES IF PROLONGED/REPEATED CONTACT
Eye Protection:SAFETY GOGGLES IF SPLASHING ANTICIPATED
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
    INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
    RECOMMENDED PROCEDURES. DISCARD CONTAMINATED LEATHER GLOVES AND
    SHOES.
Supplemental Safety and Health
NOTE TO PHYSICIAN: IF > 2 ML PER KG HAS BEEN INGESTED AND VOMITING HAS
    NOT OCCURED, EMESIS SHOULD BE INDUCED WITH SUPERVISION. KEEP
    VICTIM'S HEAD BELOW HIPS. IF SYMPTOMS SUCH AS LOSS OF GAG REFLEX,
    CO NVULSION/UNCONSCIOUSNESS OCCUR, GASTRICLAVAGE USING A CUFFED
    ENDOTRACHEAL TUBE SHOULD BE CONSIDERED.

==================  Physical/Chemical Properties  ==================

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>480F,>249C
Vapor Pres:<0.5 @ 68F
Vapor Density:>5
Spec Gravity:0.87
Viscosity:10.3 CS @100F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT YELLOW OIL - SLIGHT HYDROCARBON ODOR

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:FLAME, HEAT
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
    LIQUID, PARTICULATES & GASES WILL EVOVLE. CARBON MONOXIDE & OTHER
    COMPD. MAY FORM.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
    IN COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
    INCINERATION OR REUSE IS RECOMMENDED. IT IS NOT HAZARDOUS WASTE BY
    RCRA CRITERIA (40 CFR 261).

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***