===================== Product Identification =====================
MSDS NAME:FLAT ACRYLIC HOUSE PAINT, 1205-SERIES (ALL COLORS)
NIIN:00N075740
MSDS Number: CCWWW
=== Responsible Party ===
Company:KELLY-MOORE PAINT CO INC
Address:1015 COMMERCIAL ST
City:SAN CARLOS
State:CA
ZIP:94070
Country:US
Info Phone Num:415-592-8337
Emergency Phone Num:800-424-9300(CHEMTREC)
Preparer's Name:JULIAN SCHAFER
CAGE:0Y837
=== Contractor Identification ===
Company:KELLY-MOORE PAINT CO INC
Address:987 COMMERCIAL ST
Box:City:SAN CARLOS
State:CA
ZIP:94070
Country:US
Phone:650-592-8337
CAGE:0Y837
============= Composition/Information on Ingredients =============
Name:ETHYLENE GLYCOL (SARA 313) (CERCLA). VP:0.1 @ 68F.
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 2%
OSHA PEL:50 PPM (MFR)
ACGIH TLV:50 PPM, VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Name:SILICA, CRYSTALLINE - CRISTOBALITE; (SILICA, CRYSTALLINE)
(MFR'S INVALID CAS #14464-45-1)
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: 5-25%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.05 MG/M3 RDUST
Name:PROPIONIC ACID, 2-METHYL-, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL; (TEXANOL). VP:0.04 @ 68F.
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
Name:ZINC OXIDE (SARA 313) (CERCLA)
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 1-2%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Name:PIGMENTS SUCH AS INGS 6 - 8. (THESE PIGMENTS CONTAIN ING 9)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Name:MINERAL SILICATES
CAS:1332-58-7
OSHA PEL:N/K
ACGIH TLV:N/K
Name:SILICON DIOXIDE
CAS:14808-57-0
OSHA PEL:N/K
ACGIH TLV:N/K
Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Name:PAINT PRESERVATIVES
CAS:26530-20-1
OSHA PEL:N/K
ACGIH TLV:N/K
Name:5-CHLORO-2-METHYL-4-ISOTHIOAZOLIN-3-ONE; (PAINT
PRESERVATIVE)
CAS:26172-55-4
RTECS #:NX8156850
OSHA PEL:N/K
ACGIH TLV:N/K
Name:SUPP DATA:WITH A DUST FILTER AS NEEDED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:DIZZINESS, HEADACHE, NAUSEA,
CONFUSION, IRRITATION TO UPPER RESPIRATORY TRACT, SKIN AND EYE
IRRITATION. CHRONIC:PROLONGED AND/OR REPEATED OVEREXPOSURE TO HIGH
CONCENTRATIONS OF RESPIRABLE (AIRBO RNE) CRYSTALLINE SILICA DUSTS
AS MAY BEGENERATED BY SANDING OR GRINDING OF DRIED PAINTS AND OTHER
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-CRISTOBALITE &
QUARTZ:IARC MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GRP 2A. NTP 7TH
ANNUAL RPT (SUPDAT)
Effects of Overexposure:HLTH HAZ:BLDG MATLS W/OUT WEARING PROPER NIOSH
APPRVD RESP PROT CAN CAUSE SILICOSIS, A NON-CANCEROUS LUNG DISEASE
THAT CAN RSLT IN SUBSTANTIAL IMPAIRMENT OF BRTHG FUNC. NOTE:THIS
PROD CNTNS PIGMENTS W HICH ARE NOT CONSIDERED HAZ IN WET PAINT BUT
MAY REACH HAZ LEVELS IN DUSTS GENERATED FROM SANDING/GRINDING OF
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE KNOWN. SEE YOUR MD FOR
SPECIFIC MEDICAL OPINION REGARDING YOUR CONDITION.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT MD.
EYES:FLUSH W/LARGE VOLUMES OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION. SKIN:WIPE OFF W/RAG. WASH THOROUGHLY W/SOAP &
WATER. INGES T:CONSULT HOSPITAL EMERGENCY ROOM OR POISON CONTROL
CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF STEAM PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA TO PREVENT BUILD-UP OF VAPORS.
FOR SMALL SPILLS, SOAK UP W/ABSORBANT. FOR LARGER SPILLS, DIKE AREA
W/ABSORBENT MATERIAL & SCOOP UP LIQUIDS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINERS
AWAY FROM HEAT & FLAME.
Other Precautions:PAINT PRESERVATIVES HAVE BEEN ADDED TO CONTROL
SPOILAGE AT LEVELS THAT ARE NOT CONSIDERED HAZARDOUS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPRVD PARTICLE MASK (TC-21C) TO AVOID
BRTHG SPRAY MIST/SANDING DUST IF LOC VENT IS ADEQ TO KEEP VAP CONCS
W/IN ACCEPT (TLV) LIMS. IF LOC VENT IS NOT SUFFICIENT/WHERE EXPOS
LIMS ARE EXCEEDED , WEAR SUITABLE PROPERLY FITTED (SUPDAT)
Ventilation:LOCAL CROSS-VENTILATION OR MECHANICAL EXHAUST SUFFICIENT TO
KEEP ALL HAZARDOUS VAPOR CONCS BELOW PRESCRIBED LIMITS.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:REMOVE & WASH CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
EXPLAN OF CARCIN:ON CARCINS, 1994:ANTIC TO BE CARCIN. EFTS OF
OVEREXP:DRIED PAINT. LIKE MOST NATURALLY OCCURING MINERALS, THESE
PIGMENTS CNTN CRYSTALLINE SILICA WHICH HAS BEEN INCL ON LIST OF
CHEMS "K NOWN BY STATE OF CALIFORNIA TO CAUSE CANCER". RESP
PROT:NIOSH APPRVD RESP (TC-23C OR BETTER) FOR ORGANIC VAPS (ING 12)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGS
Vapor Density:LTR/AIR
Spec Gravity:1.32-1.44
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:55-60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . DISCARD IN LAND FILL IN SEALED METAL CONTAINERS AWAY
FROM HEAT & FLAME & I/A/W LOCAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|