MATERIAL SAFETY DATA SHEET
Pharmacal Research Laboratories Inc. 飩? BOX 369 Naugatuck, CT 06770
PO
(203) 755-4908 飩?800-243-5350 飩? FAX (203) 755-4309
HMIS DATE OF ISSUE 03/07/2007
Health-3 Fire-0 Reac-0
I. PRODUCT IDENTIFICATION
URISOLV庐
PRODUCT NAME:
PHARMACAL RESEARCH LABS., INC.
MANUFACTURER:
562 Captain Neville Drive
Waterbury, CT 06705
EMERGENCY TELEPHONE NUMBERS: FOR CHEMICAL EMERGENCY
CHEMTREC 1-800-424-9300
IN CANADA CALL CANUTEC 1-613-996-6666
II. COMPONENTS AND HAZARD INFORMATION
COMPONENTS CAS NO. OF APPROXIMATE
COMPONENTS CONCENTRATION
PHOSPHORIC ACID 7664-38-2 40 %
WARNING STATEMENTS
CAUTION: Harmful if swallowed. Avoid contact with eyes, mouth or mucous membranes.
Contains Phosphoric Acid.
CORROSIVE
KEEP OUT OF REACH OF CHILDREN
Do not mix with any other chemicals unless compatibility has been established by
the manufacturer.
III. EMERGENCY AND FIRST AID PROCEDURES
飩凤??
If in eyes: Hold eye open and rinse slowly and gently with water for 15 - 20
minutes.
飩凤??
Remove contact lenses, if present, after the first five minutes, then
continue rinsing eye.
飩凤?? a poison control center or doctor for treatment advice.
Call
飩稢all a poison control center or doctor immediately for treatment advice.
飥?
If swallowed:
飩凤??
Have person rinse mouth with water then drink large quantities of
water to cause dilution.
飩? not induce vomiting.
飥?
Do
飩稤o not give anything by mouth to an unconscious person.
飥?
飩凤??
If on skin Take off contaminated clothing.
飩凤??
or Rinse skin immediately with plenty of water for 15 - 20 minutes.
飩凤?? a poison control center or doctor for treatment advice.
clothing: Call
飩凤??
Inhalation: Move to fresh air.
飩凤??
Consult a physician if irritation of respiratory passages occur.
URISOLV飪? PAGE 1 OF 3
MATERIAL SAFETY DATA SHEET
Pharmacal Research Laboratories Inc. 飩? BOX 369 Naugatuck, CT 06770
PO
(203) 755-4908 飩?800-243-5350 飩? FAX (203) 755-4309
IV. FIRE AND EXPLOSION DATA
FLASH POINT (MINIMUM):
PHOSPHORIC ACID IS NOT COMBUSTIBLE BUT MAY REACT WITH METALS TO
LIBERATE HYDROGEN, A FLAMMABLE GAS.
HANDLING PRECAUTIONS:
KEEP IN WELL VENTILATED AREA. STORE ABOVE 10OC (50OF). USE GOGGLES OR
FACESHIELD, RUBBER GLOVES, AND BOOTS WHERE CONTACT IS EXPECTED.
EXTINGUISHING MEDIA AND FIRE FIGHTING PROCEDURES:
USE FULL PROTECTIVE CLOTHING AND SELF CONTAINED BREATHING
APPARATUS.
DECOMPOSITION PRODUCTS UNDER FIRE CONDITIONS:
AT FIRE TEMPERATURES, PRODUCT MAY EMIT TOXIC PHOSPHORUS OXIDE
FUMES.
V. HEALTH AND HAZARD INFORMATION
EFFECTS OF OVEREXPOSURE / SIGNS AND SYMPTOMS OF EXPOSURE:
SLIGHTLY TOXIC WITH REPEATED INHALATION OR INJESTION. MAY CAUSE
BURNS TO EXPOSED TISSUE.
NATURE OF HAZARD AND TOXICITY INFORMATION:
ACUTE ORAL TOXICITY 50 TO 500 mg/kg
SKIN IRRITATION MILD PRIMARY SKIN IRRITANT
primary irritation score (index) 1.12
EYE IRRITATION PRIMARY EYE IRRITANT
mean maximum score 75.3
VI. PHYSICAL DATA
THE FOLLOWING DATA ARE APPROXIMATE OR TYPICAL VALUES AND SHOULD NOT BE USED FOR PRECISE
DESIGN PURPOSES.
SPECIFIC GRAVITY 1.3
pH <1
PRODUCT APPEARANCE Light green liquid
COMPLETE
SOLUBILITY IN WATER @ 1 ATM AND 25飩?
C
URISOLV飪? PAGE 2 OF 3
MATERIAL SAFETY DATA SHEET
Pharmacal Research Laboratories Inc. 飩? BOX 369 Naugatuck, CT 06770
PO
(203) 755-4908 飩?800-243-5350 飩? FAX (203) 755-4309
VII. REACTIVITY
CONTACT WITH REACTIVE METALS (e.g. MILD STEEL-ALUMINUM) MAY PRODUCE
FLAMMABLE/EXPLOSIVE HYDROGEN. ACID MIXTURES CAN REACT VIOLENTLY
WITH STRONG ALKALI (BASES)
VIII. SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: DIKE AND
SALVAGE OR NEUTRALIZE WITH LIME OR SODA ASH AND DISPOSE INTO
TREATMENT SYSTEM IN ACCORDANCE WITH ALL FEDERAL, STATE, AND LOCAL
LAWS
鈥淓MPTY鈥? CONTAINER WARNINGS:
DO NOT REUSE EMPTY CONTAINER. TRIPLE RINSE WITH WATER. DISPOSE OF IN
CONFORMANCE WITH FEDERAL, STSTE, AND LOCAL REGULATIONS.
IX. PROTECTION AND PRECAUTIONS
VENTILATION:
ADEQUATE VENTILATION TO KEEP HAZARDOUS INGREDIENTS BELOW TLV.
MUST MEET MAXIMUM EXPOSURE LIMIT FOR ACID MIST OF 1 mg/m3 FOR 8
HOURS.
RESPIRATORY PROTECTION:
FOR MIST USE NIOSH/MSHA ACID RESPIRATOR
PROTECTIVE GLOVES:
RUBBER, LATEX, OR OTHER ACID RESISTANT MATERIAL
EYE PROTECTION:
CHEMICAL SPLASH GOGGLES OR FACESHIELD
PERSONAL HYGIENE:
DO NOT GET IN EYES, ON SKIN OR CLOTHING. WASH THOROUGHLY
AFTER USE
X. TRANSPORTATION INFORMATION
TRANSPORTATION INCIDENT INFORMATION:
CLASSIFIED AS A CORROSIVE-PROTECT AGAINST PHYSICAL DAMAGE
DOT IDENTIFICATION NUMBER
NA 1760
SHIPPING DESCRIPTION
COMPOUNDS, CLEANING LIQUID, (PHOSPHORIC ACID), 8,NA 1760 , PG III
NMFC ITEM# 48580, SUB 3
THE INFORMATION AND RECOMMENDATIONS CONTAINED HEREIN ARE, TO THE BEST OF PHARMACAL鈥橲
KNOWLEDGE AND BELIEF, ACCURATE AND RELIABLE AS OF THE DATE ISSUED. PHARMACAL DOES NOT
WARRANT OR GUARANTEE THEIR ACCURACY OR RELIABILITY, AND PHARMACAL SHALL NOT BE LIABLE FOR
ANY LOSS OR DAMAGE ARISING OUT OF THERE USE THEREOF.
THE INFORMATION AND RECOMMENDATIONS ARE OFFERED FOR THE USER鈥橲 CONSIDERATION AND
EXAMINATION, AND IT IS THE USER鈥橲 RESPONSIBILITY TO SATISFY ITSELF THAT THEY ARE SUITABLE AND
COMPLETE FOR ITS PARTICULAR USE.
THE HAZARDOUS MATERIALS IDENTIFICATION SYSTEM (HMIS) AND NATIONAL FIRE PROTECTION
ASSOCIATION RATINGS HAVE BEEN INCLUDED BY PHARMACAL RESEARCH LABORATORIES INC. IN ORDER TO
PROVIDE ADDITIONAL HEALTH AND HAZARD INFORMATION. THE RATINGS RECOMMENDED ARE BASED UPON
CRITERIA SUPPLIED BY THE DEVELOPERS OF THESE RATING SYSTEMS, TOGETHER WITH PHARMACAL鈥橲
INTERPRETATION OF THE AVAILABLE DATA.
URISOLV飪? PAGE 3 OF 3
|