T-2
MATERIAL SAFETY DATA SHEET
Radiator Specialty Company
1900 WILKINSON BLVD. CHARLOTTE, NC 28208 (704) 377-6555
POISON INFORMATION & EMERGENCY: 303-623-5716
MATERIAL SAFETY DATA SHEET US DEPARTMENT OF LABOR
May be used to comply with OSHA鈥檚 Hazard Occupational Safety and Health Administration.
Communication Standard 29 CFR 1910.1200. (Non-Mandatory Form) Form Approved OMB No.
Standard must be consulted for specific require- 1218-0072
ments.
SECTION I GENERAL INFORMATION
PRODUCT NAME TITE-SEAL庐 GASKET & JOINT SEALING COMPOUND # 2
PART NUMBER T2 -01, -03, -03V, -11
NOTE: Blank spaces are not permitted. If any item is not applicable or no information is available, the space must
be marked to indicate that.
SECTION II HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
COMPONENT WT% C.A.S. NO. TLV (ACGIH--X----OSHA-------)
Vegetable Oil 13-23 Mixture N/A
Isopropanol 9-14 67-63-0 400 ppm
Comments:
Components not identified are non-hazardous according to 29 CFR 1910.1200
SECTION III PHYSICAL/CHEMICAL CHARACTERISTICS
Specific Gravity (H2O=1) 1.5 pH Neutral
Solubility in Water Slightly soluble Solubility in Solvent Alcohols
0
Flash Point (Method) - F 60 (PM) % Volatiles By Wt. 15%
0 0
Melting Point - F N/A Boiling Point - F .N/A
Vapor Pressure (mmHg) N/A Vapor Density (Air=1) N/A
Evaporation Rate (Butyl Acetate=1) N/A
Appearance and Odor Black paste with alcoholic odor. .
SECTION IV FIRE AND EXPLOSION HAZARD DATA
EXTINGUISHING MEDIA:
Water Fog Foam X CO2 X Dry Chemical X
SPECIAL FIRE FIGHTING PROCEDURES. Wear self-contained, positive pressure breathing apparatus and
protective clothes.
UNUSUAL FIRE AND EXPLOSION HAZARDS May produce dense smoke.
T2
SECTION V REACTIVITY DATA
Stable X Unstable Corrosive NO Hazardous Polymerization? Yes No X
Incompatibilities oxidizing agents
Hazardous Decomposition or Byproducts carbon oxides, smoke.
SECTION VI HEALTH HAZARD INFORMATION
Recommended TLV of Product 400 ppm
EYE CONTACT May cause eye irritation and cornea SKIN CONTACT Excessive exposure may cause skin irritation.
damage.
INHALATION Excessive inhalation of alcohol fumes INGESTION Harmful if swallowed.
may cause headache, and irritation.
OTHER N/A
SECTION VII EMERGENCY AND FIRST AID PROCEDURES
EYE CONTACT Flush thoroughly with water for 15 minutes while lifting eyelids. Consult a physician if adverse effects
persist.
SKIN CONTACT Wash thoroughly with soap and water. Remove contaminated clothing and launder before re-use.
Move to fresh air immediately. If breathing is difficult, administer oxygen; if breathing has stopped, apply
INHALATION
artificial respiration. Keep warm and summon medical assistance.
INDUCE VOMITING! Drink 2 glasses of milk! Get medical attention immediately!
INGESTION
SECTION VIII SPECIAL PROTECTION INFORMATION
CONSUMER BULK HANDLING (Prolonged Exposure)
RESPIRATORY N/A If TLV is exceeded, wear NIOSH approved respirator.
PROTECTION
Use with adequate ventilation General
VENTILATION
N/A Goggles
EYE PROTECTION
PROTECTIVE N/A Rubber gloves
CLOTHING
SECTION IX PRECAUTIONS FOR SAFE HANDLING AND USE
SPILL OR LEAK PROCEDURE Observing health hazards described above, remove ignition sources, ventilate area, flush with water
and wipe up with rags. Transfer to waste drum. Wash stains with alkaline detergent.
WASTE DISPOSAL METHOD Dispose of in accordance with all applicable government laws and regulations.
0
STORAGE AND HANDLING PRECAUTIONS Store in a cool place below 120 F. away from acids, ignition sources and oxidizing
agents.
OTHER PRECAUTIONS WEARING CONTACT LENSES IS INADVISABLE WHILE USING THIS PRODUCT! KEEP AWAY FROM
CHILDREN AND ANIMALS! RESPECT ALL CHEMICALS!
Supersedes JULY 1992 OSHA Revised AUG. 1996
Title K. PHILLIPS-CHEMIST
While Radiator Specialty Company believes this data is accurate
as of the revision date, we make no warranty with respect to the data
and we expressly disclaim all liability for reliance thereon. The data
is offered solely for information, investigation, and verification.
|