MSDS - Material Safety Data Sheet
Product Name: HEAVY DUTY SILICONE SPRAY LUBRICANT
MSDS No.: M914
I. Basic Information:
Manufacturer: RADIATOR SPECIALTY COMPANY
2
Address: P.O. BOX 159, 600 RADIATOR ROAD
City, ST Zip: INDIAN TRAIL, NC 28079
2 0
Emergency Contact: Rocky Mountain Poision Control Center
Emergency Telephone Number: 303-623-5716
Contact: Robert Geer
Information Telephone Number: 704-688-3430
2
2
Last Update: 02/20/2003
0
X
Chemical State: Liquid Gas Solid
A
Chemical Type: Pure Mixture
X
II. Ingredients:
Trade Secret
EHS IARC SARA
313 OSHA ACGIH Other
% Range NTP SUB Z PEL TLV Limits
CAS No. Chemical Name
111762 2-Butoxyethanol 1-2 X 25 ppm 25 ppm
8052413 Aliphatic Hydrocarbon Solvent 86-90 100 ppm 100 ppm
124389 Carbon dioxide 3-4 N/AV 5000 ppm
63148629 Dimethyl Polysiloxane 6-7 N/E N/E
64742525 Naphthenic Petroleum Distillate 2-3 5 mg/m3 5 mg/m3
64742536 Naphthenic Petroluem Oil 2-3 5 mg/m3 (m 5 mg/m3 (m
III. Hazardous Identification:
Hazard Category:
X Acute Chronic X Fire X Pressure Reactive
Hazardous Identification Information:
Flammable. Harmful or fatal if swallowed. Eye and Skin Irritant. Contents under Pressure.
Level 3 Aerosol
IV. First Aid Measures:
Route(s) of Entry:
Absorption, Eye, Inhalation, and Ingestion.
Health Hazards (Acute and Chronic):
See Signs and Symptoms below
Signs and Symptoms:
Eye Contact: Irritant. Prolonged contact may cause conjunctivitis.
Skin Contact: Irritant. Defatting of tissue, dermatitis may occur.
Inhalation: Irritant to mucous membranes. Repeated exposure may cause narcosis..
Ingestion: HARMFUL OR FATAL IF SWALLOWED.
MSDS - Material Safety Data Sheet
Product Name: HEAVY DUTY SILICONE SPRAY LUBRICANT
MSDS No.: M914
Medical Conditions Generally Aggravated by Exposure:
N/D
Emergency and First Aid Procedures:
Eye Contact: Flush eyes with clean water for 15 minutes while lifting eyelids. Get prompt medical attention.
Skin Contact: Wash with soap and water thoroughly. If adverse effects persist, get prompt medical attention. Launder
contaminated clothing before reuse.
Inhalation: Remove to fresh air. If breathing becomes difficult give oxygen and get prompt medical attention. If breathing
stops, give artificial respiration and get prompt medical attention.
Ingestion: DO NOT INDUCE VOMITING! Call Poison Control Center, physician, or hospital emergency room immediately.
Aspiration of vomitus into the lungs can cause pneumonitis, which can be fatal.
Other Health Warnings:
Vomiting and subsequent aspiration into the lungs may lead to chemical pneumonia and pulmonary edema which is a
potentially fatal condition.
V. Fire Fighting Measures:
Flash Point: 107掳F Lower Explosive Limit: N/D Upper Explosive Limit: N/D
F.P. Method: TCC
Fire Extinguishing Media: Water Fog, Foam, Carbon Dioxide, Dry Chemical
Special Fire Fighting Procedures:
Wear self-contained positive pressure breathing apparatus and protective clothes. Cool containers with a water fog. Do not
use forced water stream as this could cause the fire to spread. Use shield to protect from rupturing and venting containers.
Unusual Fire and Explosion:
At elevated temperatures containers may vent, rupture or burst, even violently.
VI. Accidental Release Measures:
Steps to be Taken in Case Material is Released or Spilled:
Eliminate all ignition sources. Persons not wearing protective equipment should be excluded from area of spill until clean-up
has been completed. Dike or contain spill and absorb with inert materials (sand, sawdust, absorbent sweeping compounds,
rags, etc). Using a non-metalic scoop, place contaminated material into an approved chemical waste container. Where
possible, vacuum spilled liquid using an explosion proof vacuum to recover material. Prevent run-off to sewers, streams, or
other bodies of water. If run-off occurs, notify proper authorities as required that a spill has occured.
VII. Handling and Storage:
Precautions to be Taken:
Use with adequate ventilation and proper protective equipment.
Store in cool, well ventilated area below 120掳F away from heat sources. Do not use near fire, sparks, or open flame. Exposure
to temperatures above 120掳 may cause container to vent, rupture, or burst. Do not puncture or incinerate container.
Other Precautions:
Flammable. Store in cool place away from oxidizers and acids.
MSDS - Material Safety Data Sheet
Product Name: HEAVY DUTY SILICONE SPRAY LUBRICANT
MSDS No.: M914
VIII. Exposure Controls/Personal Protection:
Ventilation Requirements:
See Section 2 for applicable exposure limits. Use with adequate ventilation. If TLV is exceeded, wear NIOSH approved
respirator.
Personal Protective Equipment:
See Section 2 for applicable exposure limits. For prolonged exposure wear protective safety glasses, gloves, and apron.
IX. Physical and Chemical Properties:
Boiling Point: 310掳F Melting Point: N/A
Evaporation Rate (Butyl Acetate = 1): N/D Vapor Pressure (mm Hg.): N/D
Specific Gravity (H20 = 1): 0.78000 Vapor Density (AIR = 1): N/D
Solubility In Water: Insoluble Appearance and Odor: Clear to slight yellow liquid with petroleum odor.
Other Information: N/D
X. Stability and Reactivity:
Stability:
Stable
Incompatibility (Materials to Avoid):
Oxidizing agents and acids.
Decomposition/By Products:
Normal products of combustion, carbon dioxide, smoke and Nitrogen and Sulfur Oxides
Hazardous Polymerization:
Will not occur
XI. Toxicological Information:
N/D
XII. Ecological Information:
N/D
XIII. Disposal Considerations:
DISPOSAL: This container may be recycled in a recycling centers when empty. Before offering for recycling, empty the can or
bottle by using the product according to the label. If recycling is not available, wrap the container and discard in the trash.
Dispose of unused product in accordance with all local, state government and federal laws and regulations
XIV. Transport Information:
DOT Hazard Class: ORM-D
Shipping Name: Consumer Commodity
MSDS - Material Safety Data Sheet
Product Name: HEAVY DUTY SILICONE SPRAY LUBRICANT
MSDS No.: M914
XV. Regulatory Information:
See Section 2 for SARA Reportable Chemicals.
USA TSCA: All components of this material are listed on the US TSCA Inventory.
Warning: This product contains a chemical(s) known to the State of California to cause cancer or birth defects or other
reproductive harm.
XVI. Other Information:
Do not used in confined area without proper ventilation. Contact lenses may cause further damage in case of splash into eye.
KEEP AWAY FROM CHILDREN AND ANIMALS!
N/E: Not Established
N/D: Not Determined
N/A: Not Applicable
N/AV: Not Available
While Radiator Specialty Company believes this data is accurate as of the revision date, we make no warranty with respect to the
data and we expressly disclaim all liability for reliance thereon. The data is offered soley for information, investigation, and
verification. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or
disposal of this product which may not be covered by this MSDS. The user is repsonsible for full compliance.
|