Fire Reactivity
2
2 0
0
Health Special
NFPA
MATERIAL SAFETY DATA SHEET
I. PRODUCT IDENTIFICATION
Manufacturer: WD-40 Company Telephone:
Emergency only: 1-(800) 424-9300 (CHEMTREC)
Address: 1061 Cudahy Place (92110) Information: (619) 275-1400
P.O. Box 80607 Chemical Name: Organic Mixture
San Diego, California Trade Name: WD-40 Bulk Liquid
92138-0607
II. HAZARDOUS INGREDIENTS
Exposure Limit
Chemical Name CAS Number % ACGIH/OSHA
Aliphatic Petroleum Distillates 8052-41-3 45-50 100 ppm PEL
5 mg/M3 TWA (mist)
Petroleum Base Oil 64742-65-0 30-35
1200 mg/M 3 TWA
LVP Hydrocarbon Fluid 64742-47-8 12-18
鈥? 10
Non-hazardous Ingredients
III. PHYSICAL DATA
Boiling Point: 323掳F (minimum) Evaporation Rate: Not determined
Vapor Density (air=1): Greater than 1 Vapor Pressure: Not determined
Solubility in Water: insoluble Appearance: Cloudy light amber
Specific Gravity (H20=1): 0.817 @ 72掳F Odor: Characteristic odor
Percent Volatile (volume): 74% VOC: 412 grams/liter (49.5%)
IV. FIRE AND EXPLOSION
Flash Point: 131掳F Tag Closed Cup
Flammable Limits: (Solvent Portion) [Lel] 1.0% [Uel] 6.0%
Extinguishing Media: CO2, Dry Chemical, Foam.
Special Fire Fighting Procedures: None
Unusual Fire and Explosion Hazards: None
V. HEALTH HAZARD / ROUTE(S) OF ENTRY
Threshold Limit Value Aliphatic Petroleum Distillates (Stoddard Solvent) lowest TLV (ACGIH 100 ppm.)
Symptoms of Overexposure
Inhalation (Breathing): May cause anesthesia, headache, dizziness, nausea and upper respiratory irritation.
Skin contact: May cause drying of skin and/or irritation.
Eye contact: May cause irritation, tearing and redness.
Ingestion (Swallowed): May caused irritation, nausea, vomiting and diarrhea.
First Aid Emergency Procedures
Ingestion (Swallowed): Do not induce vomiting, seek medical attention.
Eye Contact: Immediately flush eyes with large amounts of water for 15 minutes.
Skin Contact: Wash with soap and water.
Inhalation (Breathing): Remove to fresh air. Give artificial respiration if necessary.
If breathing is difficult, give oxygen.
Pre-existing medical conditions such as eye, skin and respiratory disorders may be
aggravated by exposure.
DANGER!
Aspiration Hazard: If swallowed, can enter lungs and may cause chemical pneumonitis. Do not induce
vomiting. Call physician immediately.
Suspected Cancer Agent The components in this mixture have been found to be noncarcinogenic by NTP,
Yes___ No___ IARC and OSHA
X
VI. REACTIVITY DATA
X
Stability: Stable ____ Unstable____
Conditions to avoid: Heat and open flame.
Incompatibility: Strong oxidizing agents
Hazardous decomposition products: Thermal decomposition may yield carbon monoxide and/or carbon dioxide.
X
Hazardous polymerization: May occur ____ Will not occur____
VII. SPILL OR LEAK PROCEDURES
Spill Response Procedures
Absorb small quantities with sand, earth, sawdust. Large quantities pump into tank.
Waste Disposal Method
Incinerated liquid, bury saturated absorbent in land fill. Dispose of in accordance with local, state and federal regulations.
VIII. SPECIAL HANDLING INFORMATION
Ventilation: Sufficient to keep solvent vapor less than TLV.
Respiratory Protection: Advised when concentrations exceed TLV.
Protective Gloves: Advised to prevent possible skin irritation.
Eye Protection: Approved eye protections to safeguard against potential eye contact, irritation or injury.
Other Protective Equipment: None required.
IX. SPECIAL PRECAUTIONS
Keep from open flame, do not take internally. Avoid excessive inhalation of spray particles. Keep from children.
X.TRANSPORTATION DATA (49 CFR 172.101)
Domestic Surface
Description: WD-40 Bulk Lubricant
Hazard Class: Non-Regulated Per 49 CFR 173.150 (F)(2)
ID No: None
Label Required: None (Under 119 Gallons)
XI. REGULATORY INFORMATION
All ingredients for this product are listed on the TSCA inventory.
SARA Title III chemicals: None
California Prop 65 chemicals: None
CERCLA reportable quantity: None
RCRA hazardous waste no: D001 (Ignitable)
SIGNATURE: Peter Fougner TITLE: Director of Global Quality Assurance
REVISION DATE: December, 2004 SUPERSEDES: November, 2003
鈥? = Less than 鈥? = More than
NA: Not applicable NDA: No data available
We believe the statements, technical information and recommendations contained herein are reliable. However, the data is provided without warranty, expressed
or implied. It is the user鈥檚 responsibility both to determine safe conditions for use of this product and assume loss, damage or expense, direct or consequential,
arising from its use . Before using product, read label.
MSDS No.:WDB
|