GROWMARK, INC.
1701 TOWANDA AVENUE
BLOOMINGTON, IL 61702
402-597-8889
AP-16X
MATERIAL SAFETY DATA SHEET
This MSDS complies with OSHA'S Hazard Communication Standard 29 CFR 1910.1200 and OSHA Form 174
IDENTITY AND MANUFACTURER'S INFORMATION
NFPA Rating: Health-1; Flammability-2; Reactivity-0; Special- - HMIS Rating: Health-1; Flammability-2; Reactivity-0; Personal Protection-B
Manufacturer's Name: AMREP, INC. DOT Hazard Classification: ORM-D
Address: 990 Industrial Park Drive Identity (trade name as used on label):
Marietta, GA 30062 APX-16 PENETRATING LUBRICANT
Date Prepared: 01/09/01 Prepared By: CH MSDS Number: 6866 Revision- 1
Information Calls: (770)422-2071 NOTICE: JUDGEMENT BASED ON INDIRECT TEST DATA
EMERGENCY RESPONSE NUMBER: 1(800)255-3924
SECTION 1 - MATERIAL IDENTIFICATION AND INFORMATION
CAS Number SARA OSHA PEL ACGIH Carcinogen
COMPONENTS-CHEMICAL NAMES AND COMMON NAMES
III LIST (ppm) TLV (ppm) Ref. Source **
(Hazardous Components 1% or greater; Carcinogens 0.1% or greater)
HEXANE 110-54-3 Yes 50 50 d
ISOBUTANE 75-28-5 No 800 800 d
PROPANE 74-98-6 No 1000 1000 d
PARAFFINIC OIL 8042-47-5 No 5mg/M3 5mg/M3 d
SECTION 2 - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: N/A Specific Gravity (H2O=1): Concentrate Only = .71
Vapor Pressure: PSIG @ 70掳F (Aerosols): 60 max Vapor Pressure (Non-Aerosols)(mm Hg and Temperature): N/A
Vapor Density (Air = 1): N/E Evaporation Rate ( = 1): N/E
Solubility in Water: Nil Water Reactive: No
Appearance and Odor: Red, pearlescent spray with solvent odor.
SECTION 3 - FIRE AND EXPLOSION HAZARD DATA
FLAMMABILITY as per USA FLAME PROJECTION TEST Auto Ignition Temperature Flammability Limits in Air by % in Volume:
(aerosols) N/E % LEL: N/E % UEL: N/E
EXTREMELY FLAMMABLE
FLASH POINT AND METHOD USED (non-aerosols): N/A SPECIAL FIRE FIGHTING PROCEDURES: Use water fog to cool containers to
prevent rupturing and bursting.
EXTINGUISHER MEDIA: Foam, dry chemical, carbon dioxide.
Unusual Fire & Explosion Hazards: Do not expose aerosols to temperatures above 130掳F or the container may rupture. Provide shielding to protect personnel.
SECTION 4 - REACTIVITY HAZARD DATA
STABILITY [ X ] STABLE [ ] UNSTABLE HAZARDOUS POLYMERIZATION [ ] WILL [ X ] WILL NOT OCCUR
Incompatibility (Mat. to avoid): Strong oxidizing agents. Conditions to Avoid: Open flame, welding arcs, heat, sparks.
Hazardous Decomposition Products: Carbon dioxide, carbon monoxide.
SECTION 5 - HEALTH HAZARD DATA
PRIMARY ROUTES OF ENTRY: [ X ] INHALATION [ ] INGESTION [ ] SKIN ABSORPTION [ ] EYE [ ] NOT HAZARDOUS
ACUTE EFFECTS
Inhalation: Can cause headaches, dizziness.
Eye Contact: Irritation Skin Contact: Defatting of skin.
Ingestion: Possible chemical pneumonitis if aspirated into lungs.
CHRONIC EFFECTS: None known.
Medical Conditions Generally Aggravated by Exposure: Asthma.
EMERGENCY FIRST AID PROCEDURES
Eye Contact: Flush with water for at least 15 minutes. If irritated, seek medical attention.
Skin Contact: Wash with soap and water. Remove contaminated clothing and launder before re-wearing. If irritated, seek medical attention.
Inhalation: Remove to fresh air. Resuscitate if necessary. Get medical attention.
Ingestion: DO NOT INDUCE VOMITING. Get immediate medical attention.
SECTION 6 - CONTROL AND PROTECTIVE MEASURES
Respiratory Protection (specify type): Not normally needed.
Protective Gloves: Solvent resistant. Eye Protection: Safety glasses recommended.
Ventilation Requirements: Normal room ventilation.
Other Protective Clothing & Equipment: None
Hygienic Work Practices: Wash with soap and water after contact.
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken If Material Is Spilled Or Released: Soak up spilled liquid with absorbent material. Place in closed drum for proper disposal. Incinerate or landfill
according to local, state or federal regulations.
Waste Disposal Methods: Aerosol cans when vented to atmospheric pressure through normal use, pose no disposal hazard.
Precautions To Be Taken In Handling & Storage: Do not puncture or incinerate containers. Do not store at temperatures above 130掳F.
Other Precautions &/or Special Hazards: KEEP OUT OF REACH OF CHILDREN.
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any
kind.
** Chemical Listed as Carcinogen or Potential Carcinogen. [a] NTP [b] IARC Monograph [c] OSHA [d] Not Listed [e] Animal Data Only
|