paraffin waxes and hydrocarbon waxes, chlorinated; (chlorinated aluminum oxide (2:3); (aluminum oxide) (sara 313) silicic acid, calcium salt; (calcium silicate) titanium oxide; (titanium dioxide) residual monomer other prec:all procs approp for confined space entry should be completed ing 6:scaqmd method 280.)
HB FULLER CO -- VAPOR-SAFE COATING, FOSTER 30-80
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BZPVN
MSDS NAME: VAPOR-SAFE COATING, FOSTER 30-80
Responsible Party
Name: HB FULLER CO
Address: 1200 WOLTERS BLVD
City: VADNAIS HTS MN 55110
Info Phone: 612-481-3300
Emergency Phone Number: 800-228-5635
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: H.B. FULLER COMPANY
Address: 3500 LEXINGTON AVENUE N.
City: ST. PAUL MN 55126-8076
Phone: 612-236-5300/ -5309 FAX
Name: HB FULLER CO
Address: 1200 WOLTERS BLVD
City: VADNAIS HEIGHTS MN 55110
Phone: 612-481-3300
=======================================================
Ingredients
=======================================================
Cas: 63449-39-8
RTECS #: RV0450000
Name: PARAFFIN WAXES AND HYDROCARBON WAXES, CHLORINATED; (CHLORINATED
PARAFFIN). VP: NIL @ 20C.
% Wt: 1-10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 1344-28-1
RTECS #: BD1200000
Name: ALUMINUM OXIDE (2:3); (ALUMINUM OXIDE) (SARA 313)
% Wt: >10
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 1344-95-2
RTECS #: VV9150000
Name: SILICIC ACID, CALCIUM SALT; (CALCIUM SILICATE)
% Wt: 1-10
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
Name: TITANIUM OXIDE; (TITANIUM DIOXIDE)
% Wt: 1-10
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Name: RESIDUAL MONOMER
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Name: OTHER PREC:ALL PROCS APPROP FOR CONFINED SPACE ENTRY SHOULD BE COMPLETED
PRIOR TO PERFORMING ANY WORK IN BULK STOR TANK.
-----------------------------
Name: ING 6:SCAQMD METHOD 280.)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: EYES: DIRECT EYE CONTACT WITH THE PRODUCT MAY CAUSE
IRRITATION. SKIN: PROLONGED OR REPEATED CONTACT WITH LIQUID PRODUCT MAY CAUSE
IRRITATION. INHALATION: EXPOSURE TO VAPORS IN POORLY VENTILATED AREAS MAY
CAUSE IRRITATION OF THE NOSE, THROAT AND RESPIRATORY TRACT.
Explanation Of Carcinogenicity: CHLORINATED PARAFFIN WAX: IARC MONO ON THE EVAL
OF CARCIN RISK OF CHEMS TO MAN, VOL 48, PG 55, 1990: GROUP 2B. (SUPDAT)
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NO KNOWN EFFECTS ON OTHER ILLNESSES.
First Aid: INGEST: CALL MD IMMEDIATELY (FP N). EYES: FLUSH IMMEDIATELY WITH
WATER FOR AT LEAST 15 MINUTES. CONSULT MD IF IRRITATION PERSISTS. SKIN: WASH
AFFECTED AREA WITH SOAP AND WATER. LAUNDER CONTAMINATED CL OTHING BEFORE
REUSE. INHAL: REMOVE TO FRESH AIR.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: DIKE IF NECESSARY. CONTAIN SPILL WITH INERT ABSORBENT
AND TRANSFER TO CONTAINERS FOR DISPOSAL. KEEP SPILLED PRODUCT OUT OF SEWER,
WATERSHEDS OR WATER SYSTEMS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISP MUST BE I/A/W FED, STATE & LOC REGS (FP N). TO
THE BEST OF MFR'S KNOWLEDGE, PROD DOES NOT MEET DEFINITION OF HAZ WASTE UNDER
EPA HAZ WASTE REGS 40 CFR 261. DOES NOT CNTN ANY ADDED RAW MATLS W/KNO WN
LEVELS OF TCLP CONSTITUENTS AS (SUPDAT)
Handling And Storage Precautions: PROTECT FROM FREEZING - PRODUCT STABILITY MAY
BE AFFECTED.
Other Precautions: PROD CNTNS LIMITED AMTS OF RESIDUAL MONOMER. UNDER NORM
HNDLG & USE CNDTNS RESIDUAL MONOMER SHOULD NOT PRESENT HAZ. IN STOR
MONOMER WILL MIGRATE FROM EMULSION & ESTABLISH EQUILIBRIUM BETWEEN
HEADSPACE IN STOR CNTNR & LIQ EMULSION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NON FLAMMABLE
Extinguishing Media: NON-FLAMMABLE IN LIQUID STATE; USE WATER SPRAY, FOAM, DRY
CHEMICAL OR CARBON DIOXIDE ON DRIED PRODUCT.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: THERE IS THE POSSIBILITY OF PRESSURE BUILDUP IN
CLOSED CONTAINERS WHEN HEATED. WATER SPRAY MAY BE USED TO COOL THE
CONTAINERS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NORMALLY REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR IF CONDITIONS WARRANT.
Ventilation: STANDARD INDUSTRIAL VENTILATION.
Protective Gloves: RUBBER GLOVES.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
PREVENT PROLONGED OR REPEATED CONTACT BY USING APPROP PROT CLOTHING.
Work Hygienic Practices: LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health: EXPLAN OF CARCIN: NTP 7TH ANNUAL REPORT ON
CARCINS, 1994: ANTIC TO BE CARCIN. WASTE DISP: IDENTIFIED IN SECTION 261.24
OF EPA HAZ WASTE REG. LEACHATE TESTS HAVE NOT BEEN PERFORMED. STATE/LOC HAZ
WASTE REGS MAY APPLY IF THEY DIFFER FROM FEDREG. SOLIDIFY & DISP OF IN
APPRVD LANDFILL. FOR ADDNL ASSISTANCE CONSULT MFR.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >200F,>93C
Spec Gravity: 1.402 (FP N)
PH: 10
Solubility in Water: MISCIBLE
Appearance and Odor: LIQUID.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NOT ESTABLISHED.
Hazardous Decomposition Products: INCOMPLETE COMBUSTION CAN YIELD LOW MOLECULAR
WEIGHT HYDROCARBONS, CARBON MONOXIDE, HYDROGEN CHLORIDE, PHOSGENE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: VAPOR-SAFE COATING, FOSTER 30-80
Assigned IND: Y
Company: HB FULLER CO
Street: 1200 WOLTERS BLVD
City: VADNAIS HEIGHTS MN
Zipcode: 55110
Health Emergency Phone: 800-228-5635
Label Required IND: Y
Date Of Label Review: 04/10/1996
Status Code: C
Label Date: 04/10/1996
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: DECOMPOSITION PRODUCTS MAY BE TOXIC. ACUTE: EYES:
DIRECT EYE CONTACT WITH THE PRODUCT MAY CAUSE IRRITATION. SKIN: PROLONGED OR
REPEATED CONTACT WITH LIQUID PRODUCT MAY CAUSE IRRITATION. INHALATION: EX
POSURE TO VAPORS IN POORLY VENTILATED AREAS MAY CAUSE IRRITATION OF THE NOSE,
THROAT AND RESPIRATORY TRACT. CHRONIC: CANCER HAZARD. CONTAINS CHLORINATED
PARAFFIN WAX WHICH IS LISTED AS A LIVER CARCINO GEN (FP N).
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.