HEXCEL CORP -- URALITE 6108 PART A
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CDSZM
MSDS NAME: URALITE 6108 PART A
Kit Part: Y
Responsible Party
Name: HEXCEL CORP
Address: 20701 NORDHOFF ST
Box: 2197
City: CHATSWORTH CA 91311
Info Phone: 818-882-3022
Emergency Phone Number: 800-433-5072; 800-367-7527
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: HEXCEL CORP
Address: 11555 DUBLIN BLVD
Box: 2197
City: DUBLIN CA 94568
Phone: 415-828-4200
Name: HEXCEL CORPORATION;CHEMICAL PRODUCTS DIVISION
Address: 20701-NORDHOFF STREET
Box: 2197
City: CHATSWORTH CA 91311-5924
Phone: 818-882-3022
=======================================================
Ingredients
=======================================================
Name: VENT:HANDLED INDOORS, PROVIDE MECH EXHST VENT. CONSULT STD REFERENCE
SOURCES REGARDING INDUS VENT (EG ACGIH INDUS VENT).
-----------------------------
Name: HYGIENE PRACT: SIGNIFICANT AMTS OF MATL GET ON CLTHG, SHOWER IMMED &
LAUNDER CLTHG BEFORE IT IS WORN AGAIN. MED
-----------------------------
Name: ING 22:SUPERVISION OF ALL EMPLOYEES WHO COME IN CNTCT W/ISOCYANATES IS
RECOMD. THIS SHOULD INCL PRE-EMPLOYMENT &
-----------------------------
Name: ING 23:PERIODIC MED EXAMS W/PULM FUNC TESTS. PERS W/ASTHMATIC-TYPE
CNDTNS, OTHER CHRONIC RESP CNDTNS, RECURRENT
-----------------------------
Name: ING 24: SKIN ECZEMA/SENSIT SHOULD NEVER WORK W/ISOCYANATES. PERMIT NO
FURTHER EXPOS ONCE PERSON DIAGNOSED AS SENSITIZED.
-----------------------------
Name: ING 6: TOX INFO: TDI IS SEV EYE IRRITANT CAPABLE OF INDUCING CORNEAL
OPACITY. ANIMAL STUDIES SHOW DERMAL SENSIT
-----------------------------
Name: ING 7: TO TDI WILL CAUSE RESP ALLERGIC RESPONSE. TDI IS KNOWN PULM
SENSITIZER IN HUMANS. CHRONIC ANIMAL STUDIES
-----------------------------
Name: ING 8:SHOW PRIMARY EFTS OF INHAL VAPS/AEROSOLS OF TDI ARE RESTRICTED TO
PULM SYS. EMPHYSEMA, PULM EDEMA, PNEUM &
-----------------------------
Name: ING 9: RHINITIS ARE COMMON PATHOLOGICAL EFTS. EXTENDED EXPOS TO AS LITTLE
AS 0.1 PPM TDI HAVE INDUCED PULM INFLAM.
-----------------------------
Name: FIRST AID PROC: MILK OR WATER. NEVER GIVE ANYTHING BY MOUTH TO UNCON
PERSON. CONSULT MD. NOTE TO MD: EYES:STAIN
-----------------------------
Name: ING 11:FOR EVID OF CORNEAL INJURY. IF CORNEA IS BURNED, INSTILL
ANTIBIOTIC STEROID PREPARATION. WORKPLACE VAPS
-----------------------------
Name: ING 12: HAVE PRDCED REVERSIBLE CORNEAL EPITHELIAL EDEMA IMPAIRING VISION.
SKIN:TDI IS KNOWN SENSITIZER. TREAT
-----------------------------
Name: ING 13: SYMP FOR CNTCT DERM. INGEST:TREAT SYMP; NO SPECIFIC ANTIDOTE. DUE
TO IRRIT NATURE OF TDI, INDUCED VOMIT
-----------------------------
Name: ING 14:IS NOT RECOMD. INHAL:TDI IS KNOWN PULM SENSITIZER. TREATMENT
ESSNTLY SYMP. PERS HAVING SKIN/PULM SENSIT
-----------------------------
Name: ING 15: TO THIS MATL SHOULD BE REMOVED FROM ALL EXPOS TO ANY ISOCYANATE.
-----------------------------
Name: SPILL PROC: CNTNR. NEUT W/SOLN OF 90-95% WATER, 5-8% CONCD AMMONIA &
1-2% DETERGENT BEFORE DISP. KEEP CNTNR OPEN
-----------------------------
Name: ING 17: FOR AT LEAST 24 HRS SO THAT EVOLVED CARBON DIOXIDE CAN ESCAPE.
-----------------------------
Name: RESP PROT: RESP W/ORG VAP CARTRIDGES CAN BE WORN BUT ONLY FOR SHORT
PERIODS (<1 HR). DUE TO POOR WARNING
-----------------------------
Name: ING 19:PROPERTIES OF TDI, PROPER FIT & TIMELY CARTRIDGE REPLACEMENT
IS CRUCIAL. OBSERVE OSHA REGS (29CFR 1910.134).
-----------------------------
Cas: 584-84-9
RTECS #: CZ6300000
Name: BENZENE, 2,4-DIISOCYANATO-1-METHYL-; (2,4-TOLUENE DIISOCYANATE) (SARA
302/313) (CERCLA)
% Wt: 7-12
OSHA PEL: 0.02 PPM, C
ACGIH TLV: 0.005 PPM; 0.02 STEL
EPA Rpt Qty: 100 LBS
DOT Rpt Qty: 100 LBS
------------------------------
Cas: 91-08-7
RTECS #: CZ6310000
Name: BENZENE, 2,6-DIISOCYANATO-1-METHYL-; (2,6-TOLUENE DIISOCYANATE) (SARA
302/313) (CERCLA)
% Wt: 5-10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
EPA Rpt Qty: 100 LBS
DOT Rpt Qty: 100 LBS
------------------------------
Cas: 9057-91-4
Name: POLYETHER POLYOL POLYMER W/TOLUENE DIIOSCYANATE; (TDI-POLYOL POLYMER)
WITH INGREDIENT 4
% Wt: 80-90
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 39279-01-1
Name: POLYETHER POLYOL POLYMER W/TOLUENE DIISOCYANATE
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
RTECS #: 9999999VO
Name: VOLATILE ORGANIC COMPOUND: 143.3 G/L
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Name: SUPDAT: CAUSE IRRIT OF MOUTH, STOM TISS & DIGEST TRACT. SYMPS INCL
SORE THROAT, ABDOM PAIN, NAUS, VOMIT & DIARR.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50: (ORAL, RAT) 4130-6170 MG/KG
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: THIS PROD CNTNS TDI. TDI VAPS CAN IRRIT MUC MEMBS CAUSING
RUNNY NOSE, SORE THROAT, COUGH, CHEST DISCOMFORT & SHORTNESS OF BRTH.
EXPOS TO VAPS ABOVE PEL MAY RSLT IN BRONCH, BRONCHIAL SPASMS & PULM EDEM
A (FLUID IN LUNGS). CHEM/HYPERSENS PNEUM W/FLU-LIKE SYMPS (FEVER, CHILLS) CAN
OCCUR. THESE SYMPS MAY BE(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: TOLUENE DIISOCYANATE (2,4) & (2,6): IARC
MONOGRAPHS, SUPPLEMENT, VOL 7, PG 56, 1987:GROUP 2B.
Signs And Symptions Of Overexposure: HLTH HAZ:DELAYED & OCCUR SEVERAL HRS
AFTER EXPOS. CERTAIN PEOPLE MAY DEVELOP SENSIT TO TDI & WILL EXHIBIT
ASTHMA-LIKE ATTACKS AT ANY ISOCYANATE CONC. CROSS-SENSIT TO DIFFERENT
ISOCYANATES MAY ALSO OCC UR. SENSIT MAY BE TEMPORARY/PERM. CHRONIC OVEREXP TO
ISOCYANATES MAY ALSO CAUSE LUNG DMG, INCL PERM DECRD LUNG (SUPDAT)
Medical Cond Aggravated By Exposure: PRE-EXISTING EYE, SKIN & RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOS TO THIS PROD. THESE MED CONDITIONS INCL
ASTHMA, BRONCHITIS, EMPHYSEMA, OTHER RESPIRATORY DISORDERS, SKIN ALLERGIES
& ECZEMA.
First Aid: EYES: IMMED FLUSH EYES W/PLENTY OF WATER (PREF LUKEWARM) FOR AT LST
15 MIN, KEEPING EYELIDS OPEN ALL THE TIME. SEEK IMMED MED ATTN. SKIN: IMMED
WASH SKIN W/SOAP & PLENTY OF WATER. WASH CONTAMD CLTHG B EFORE REUSE
& DESTROY CONTAMD SHOES. INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE
ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. GET MED ATTN. INGEST: DO NOT
INDUCE VOMIT. GIVE 1 TO 2 GLASSES OF
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: IN CASE OF SPILL, CONTAIN W/SUITABLE DIKING MATL. IN
ADDN TO PROT EQUIP LISTED, WEAR IMPERMEABLE BOOTS. VENT AREA THOROUGHLY. KEEP
ALL UNNEC PEOPLE AWAY. SPILLED MATL SHOULD BE ABSORBED IN SAWDUST, SA ND OR
OTHER ABSORBENT. PLACE IN OPEN-TOP
Neutralizing Agent: NEUT W/SOLUTION OF 90-95% WATER, 5-8% CONCENTRATED AMMONIA
& 1-2% DETERGENT.
Waste Disposal Methods: CONTROLLED INCINERATION OR BURIED LANDFILL DISPOSAL
SHOULD BE IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL ENVIRONMENTAL
REGULATIONS. RCRA WASTE CODE: TDI: U223. CERCLA HAZARDOUS SUBSTANCES &
RQ: T DI (RQ: 100 POUNDS).
Handling And Storage Precautions: KEEP THE CONTAINERS CLOSED. KEEP MATERIAL
AWAY FROM HEAT, SPARKS AND OPEN FLAMES. IF USED INDOORS, USE MECHANICAL
EXHAUST VENTILATION.
Other Precautions: AVOID CONTACT W/EYES, SKIN & CLTHG. AVOID BREATHING
VAPOR. WASH THOROUGHLY AFTER HANDLING. CONSULT SECTION ON PERSONAL
PROTECTION/ENGINEERING CONTROLS. STORE IN A COOL, WELL VENTD AREA IN TIGHTLY
CLSD CNTNRS. AVOID MOISTURE CONTAMINATION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 280F,138C
Extinguishing Media: USE WATER SPRAY, DRY CHEMICAL OR CARBON DIOXIDE TO
EXTINGUISH FIRES. USE WATER TO KEEP CONTAINERS COOL.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: VAPORS ARE EXCEEDINGLY IRRITATING WHEN INHALED.
=======================================================
Control Measures
=======================================================
Respiratory Protection: WHENEVER TDI-CONTAINING PRODS ARE HEATED, SPRAYED OR
USED IN POORLY VENTD AREA, CONCS GREATER THAN PEL CAN OCCUR. NIOSH APPRVD POS
PRESS, SUPPLIED-AIR RESP OR SCBA IS REQD. IF TDI CONC DOES NOT EXCEED PEL,
NIOSH APPRVD AIR-PURIFYING
Ventilation: USE EXHST VENT TO KEEP AIRBORNE LEVELS BELOW OSHA-RECOMD EXPOS
LIMS. DO NOT USE PROD IN POORLY VENTD AREA. IF
Protective Gloves: IMPERVIOUS GLOVES.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
SELECTION OF BOOTS, APRON OR FULL-BODY SUIT WILL DEPEND ON THE OPERATION.
Work Hygienic Practices: BEFORE EATING, DRINKING, SMKNG OR USING TOILET
FACILITIES, WASH FACE & HANDS THOROUGHLY W/SOAP & WATER. IF
Supplemental Safety and Health: EFTS OF OVEREXP:FUNC. SKIN CNTCT MAY CAUSE
REDNESS, SWELL, RASH, SCALES OR BLISTERS. PRLNGD SKIN CNTCT CAUSES IRRIT THAT
MAY RSLT IN CHEM SENSIT. EYE CNTCT W/PROD CAUSES TEARING, REDNESS &
SWELL. IF L EFT UNTREATED, CORNEAL DMG CAN OCCUR & DMG IS SLOW TO HEAL.
CHRONIC OVEREXP TO VAPS MAY LEAD TO CONJ. INGEST CAN
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 460F,238C
Vapor Pres: 0.025 @77F
Vapor Density: 6
Spec Gravity: 1.11
Solubility in Water: N/A (REACTS)
Appearance and Odor: WATER-WHITE TO YELLOW LIQUID WITH A SWEET CHARACTERISTIC
ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: MOISTURE CONTAMINATION MAY RESULT IN CARBON
DIOXIDE GAS PRESSURE.
Materials To Avoid: AVOID CONTACT WITH WATER, ALCOHOLS, STRONG BASES, METAL
COMPOUNDS OR SURFACE ACTIVE MATERIALS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOIXDE, OXIDES OF
NITROGEN, TRACES OF HCN AND TDI VAPORS/MIST.
Hazardous Polymerization Indicator: YES
Conditions To Avoid Polymerization: AVOID CONTACT WITH WATER OR OTHER COMPOUNDS
WHICH CAN REACT WITH ISOCYANATES.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: URALITE 6108 PART A
Company: HEXCEL CORP
Street: 11555 DUBLIN BLVD
PO Box: 2197
City: DUBLIN CA
Zipcode: 94568
Health Emergency Phone: 800-433-5072; 800-367-7527
Label Required IND: Y
Date Of Label Review: 05/20/1997
Status Code: C
Label Date: 05/20/1997
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: Slight
Hazard And Precautions: ACUTE: INHALATION: MUCOUS MEMBRANE IRRITATION WITH
RUNNY NOSE, SORE THROAT, COUGH, CHEST DISCOMFORT AND SHORTNESS OF BREATH.
BRONCHITIS, BRONCHIAL SPASMS, PULMONARY EDEMA AND CHEMICAL OR HYPERSENSITIV E
PNEUMONITIS CAN OCCUR. SKIN: REDNESS,SWELLING, RASH, SCALING, BLISTERING.
EYES: TEARING, REDNESS AND SWELLING. CORNEAL DAMAGE POSSIBLE. INGESTION:
IRRITATION OF MOUTH, STOMACH TISSUE AND DIGESTIVE T RACT WITH SORE THROAT,
ABDOMINAL PAIN, NAUSEA, VOMITING AND DIARRHEA. CHRONIC:CANCER HAZARD.
CONTAINS TOLUENE DIISOCYANATE (2,4) & (2,6) WHICH ARE LISTED AS
CARCINOGENS (FP N). RESPIRATORY AND SKIN SE NSITIZATION. LUNG DAMAGE.
CONJUNCTIVITIS.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|