LORD CORP -- CHEMLOK Y-4310
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CFRYC
MSDS NAME: CHEMLOK Y-4310
Responsible Party
Name: LORD CORP
Address: 2000 WEST GRANDVIEW BLVD
City: ERIE PA 16514
Info Phone: 814-868-3611
Emergency Phone Number: 814-763-2345
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: LORD CORP
Address: 2000 W GRANDVIEW BLVD
Box: 10038
City: ERIE PA 16514
Phone: 814-868-3611
Name: LORD CORPORATION, CHEMICAL PRODUCTS DIVISION
Address: 2000 WEST GRANDVIEW BLVD
City: ERIE PA 16514-0038
Phone: 814-868-3611
=======================================================
Ingredients
=======================================================
Cas: 64-17-5
RTECS #: KQ6300000
Name: ETHYL ALCOHOL; (ETHANOL)
% Wt: <75
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM; 9495
------------------------------
Cas: 67-56-1
RTECS #: PC1400000
Name: METHANOL; (METHYL ALCOHOL) (SARA 313) (CERCLA)
% Wt: <15
OSHA PEL: S, 200 PPM
ACGIH TLV: S,200PPM/250STEL; 95
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Name: SUPDAT:INGEST:INGEST IS NOT AN EXPECTED ROUTE OF ENTRY IN
INDUSTRIAL/COMMERCIAL USES. CONTAINS METHANOL; MAY
-----------------------------
Name: ING 3:BE HARMFUL/FATAL IF SWALLOWED; INGEST OF METHANOL MAY CAUSE
BLINDNESS/PERM EYE DMG. CANNOT BE MADE
-----------------------------
Name: ING 4:NON-POISONOUS. CHRONIC:MAY CAUSE LIVER/KIDNEY DMG. RPTD/PRLNG SOLV
OVEREXP MAY RSLT IN PERM CNS DMG. MAY
-----------------------------
Name: ING 5:AFFECT THE GI SYS. THIS MATL CNTNS A SMALL AMT OF METHANOL. INGEST
OF METHANOL MAY CAUSE PERM EYE DMG
-----------------------------
Name: ING 6:OR BLINDNESS. CHRONIC: SKIN CONTACT MAY CAUSE DERMATITIS.
-----------------------------
Name: FIRST AID PROC:VOMITING IMMEDIATELY AS DIRECTED BY MEDICAL PERSONNEL.
NEVER GIVE ANYTHING BY MOUTH TO AN
-----------------------------
Name: ING 8:UNCONSCIOUS PERSON. GET MEDICAL ATTENTION IMMEDIATELY.
-----------------------------
Name: SPILL PROC:WITH INERT ABSORBENT MATERIAL AND NON-SPARKING TOOLS. AVOID
CONTACT. BEFORE ATTEMPTING CLEANUP,
-----------------------------
Name: ING 10:REFER TO HAZARD CAUTION INFORMATION IN OTHER SECTIONS OF THE MSDS
FORM.
-----------------------------
Name: OTHER PREC:BRTHG OF VAP/SPRAY MISTS. DO NOT HANDLE UNTIL ALL SAFETY PREC
HAVE BEEN READ & UNDERSTOOD. EMPTY
-----------------------------
Name: ING 12:CNTNRS SHOULD NOT BE RE-USED. CANNOT BE MADE NON-POISONOUS. USE
W/ADEQ VENT. BECAUSE EMPTY CNTNRS MAY
-----------------------------
Name: ING 13:RETAIN PRODUCT RESIDUE & FLAMMABLE VAPORS, KEEP AWAY FROM
HEAT, SPARKS & FLAME; DO NOT CUT, PUNCTURE
-----------------------------
Name: ING 14:OR WELD ON OR NEAR THE EMPTY CONTAINER. DO NOT SMOKE WHERE THIS
PRODUCT IS USED OR STORED.
-----------------------------
Name: RESP PROT:APPROVED AIR-SUPPLIED RESPIRATOR. OBSERVE NIOSH REGULATIONS
(29CFR 1910.134) FOR RESPIRATOR USE.
-----------------------------
Name: VENT:EXPOSURE LIMITS. CAUTION:SOLVENT VAPORS ARE HEAVIER THAN AIR AND
COLLECT IN LOWER LEVELS OF THE WORK AREA.
-----------------------------
Name: ING 17:SUFFICIENT VENT (USING EXPLOSION-PROOF EQUIPT) SHOULD BE PROVIDED
TO PVNT FLAMM VAPOR/AIR MIX FROM ACCUMULATING.
-----------------------------
Name: OTHER PROT EQUIP:LIKELY. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE
REUSE.
-----------------------------
Name: HYGIENE PRACT:FOOD/BEVERAGES SHOULD NOT BE CONSUMED ANYWHERE THIS PROD IS
HANDLED/STORED. WASH THORO AFTER HANDLING.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EMER OVERVIEW:CLEAR LIQ, W/SOLV ODOR. FLAMM LIQ & VAP.
POISON, MAY BE FATAL/CAUSE BLINDNESS IF SWALLOWED. HARMFUL IF ABSORBED THRU
SKIN. MAY CAUSE SKIN & EYE IRRIT. MAY CAUSE RESP TRACT IRRIT. VAP HAR
MFUL; MAY AFFECT THE BRAIN/NERVOUS SYS CAUSING DIZZ, HEADACHE/NAUSEA. ACUTE:
EYE CONTACT: (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:MAY CAUSE EYE IRRIT. SKIN
CONTACT:MAY BE ABSORBED THRU THE SKIN IN HARMFUL AMTS. MAY CAUSE SKIN IRRIT.
MAY CAUSE DERM. INHAL:POSS IRRIT OF THE RESP SYS CAN OCCUR CAUSING A VARIETY
OF SYMP SUC H AS DRYNESS OF THE THROAT, TIGHTNESS OF THE CHEST, &
SHORTNESS OF BRTH. MAY CAUSE CNS DEPRESS CHARACTERIZED (SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE:FLUSH IMMED W/LRG AMT OF H*2O FOR AT LEAST 15 MIN HOLDING
EYELIDS OPEN WHILE FLUSHING. GET PROMPT MED ATTN. SKIN:FLUSH CONTAMD SKIN
W/LRG AMTS OF H*2O WHILE REMOVING CONTAMD CLTHG. WASH AFFECTED S KIN AREA
W/SOAP & H*2O. GET MED ATTN IFSYMPS OCCUR. INHAL:MOVE PERS TO FRESH AIR.
RESTORE & SUPPORT CONTINUED BRTHG. IF BRTHG IS DIFFICULT, GIVE OXYGEN.
GET IMMED MED ATTN. INGEST:INDUCE
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: KEEP NON-ESSNTL PERS A SAFE DIST AWAY FROM THE SPILL
AREA. REMOVE ALL SOURCES OF IGNIT (FLAME, HOT SURF, & ELEC,
STATIC/FRICTIONAL SPARKS). AVOID BRTHG VAPS. USE NIOSH APPRVD SELF-CNTND
BRTHG EQUIP. N OTIFY APPROP AUTH IF NEC. CONTAIN & REMOVE
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL SHOULD BE DONE IN ACCORDANCE WITH FEDERAL
(40CFR PART 261), STATE AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS. IF WASTE
IS DETERMINED TO BE HAZARDOUS, USE LICENSED HAZARDOUS WASTE TRANSPORTER AND
DISPOSAL FACILITY.
Handling And Storage Precautions: DO NOT STORE OR USE NEAR HEAT, SPARKS, OR
OPEN FLAME. REFER TO OSHA 29CFR PART 1910.106 "FLAMMABLE AND COMBUSTIBLE
LIQUIDS" FOR SPECIFIC STORAGE REQ.
Other Precautions: STORE ONLY IN WELL-VENT AREAS. DO NOT PUNCTURE, DRAG/SLIDE
CNTNR. KEEP CNTNR CLSD WHEN NOT IN USE. KEEP CLOSURE TIGHT & CNTNR
UPRIGHT TO PVNT LEAKAGE. GROUND & BOND CNTNRS WHEN TRANSFERRING MATL.
AVOI D SKIN & EYE CONTACT. AVOID
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 56.0F,13.3C
Lower Limits: 4.3%
Upper Limits: 36.5%
Extinguishing Media: CO*2, DRY CHEMICAL, WATER FOG, FOAM.
Fire Fighting Procedures: USE NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
WATER SPRAY MAY BE INEFT. IF H*2O IS USED, FOG NOZZLE ARE PREFERABLE. DURING
A FIRE, IRRIT &/TOX (SUPDAT)
Unusual Fire/Explosion Hazard: FLAMM LIQ & VAP. KEEP CNTNRS TIGHTLY CLSD.
ISOLATE FROM HEAT, ELEC EQUIP, SPARKS, OPEN FLAME, & OTHER SOURCES OF
IGNIT. CLSD CNTNRS MAY RUPTURE WHEN (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH APPRVD CHEM/MECH FILTER RESP DESIGNED TO
REMOVE A COMBINATION OF PARTICULATES & ORG VAP IF OCCUP LIM ARE EXCEEDED.
FOR EMER SITUATION, CONFINED SPACE USE/OTHER CNDTNS WHERE EXPOS LIMS MAY BE
GREATLY EXCEEDED, USE AN NIOSH
Ventilation: SUFFICIENT VENT IN PATTERN & VOL SHOULD BE PROVIDED IN ORDER
TO MAINTAIN AIR CONTAMINANT LEVELS BELOW REC
Protective Gloves: NEOPRENE/NITRILE/RUBBER GLOVES.
Eye Protection: ANSI APPROVED CHEM WORKERS GOGGS (FP N).
Other Protective Equipment: ANSI APPRVD EMER EYE WASH & DELUGE SHOWER (FP N).
USE DISPOSABLE/IMPERVIOUS CLTHG IF WORK CLTHG CONTAM IS
Work Hygienic Practices: WASH HANDS BEFORE EATING, SMOKING/USING TOILET
FACILITY. DO NOT SMOKE IN ANY CHEM HANDLING/STORAGE AREA.
Supplemental Safety and Health: FIRE FIGHT PROC:GASES & PARTICULATE MAY BE
GENERATED BY THERMAL DECOMP/COMBUST. EXPLO HAZ:EXPOSED TO EXTREME HEAT. USE
WATER SPRAY TO KEEP FIRE EXPOSED CNTNRS COOL. EFTS OF OVEREXP:BY THE
FOLLOWING PR OGRESSIVE STEPS:HDCH, DIZZ, STAGGERING GAIT, CONFUSION,
UNCONSCIOUSNESS/COMA. MAY CAUSE HDCH & NAUSEA.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >148F,>64C
Vapor Density: HVR/AIR
Spec Gravity: 0.81 (H*2O = 1)
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: INSOLUBLE
Appearance and Odor: CLEAR LIQUID; SOLVENT ODOR.
Percent Volatiles by Volume: 92.9
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURES. SOURCES OF IGNITION.
Materials To Avoid: STRONG ACIDS, BASES, AND STRONG OXIDIZERS.
Hazardous Decomposition Products: OXIDES OF NITROGEN. CARBON MONOXIDE, CARBON
DIOXIDE. OXIDES OF SILICON.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: CHEMLOK Y-4310
Assigned IND: Y
Company: LORD CORP
Street: 2000 W GRANDVIEW BLVD
PO Box: 10038
City: ERIE PA
Zipcode: 16514
Health Emergency Phone: 814-763-2345
Label Required IND: Y
Date Of Label Review: 11/05/1997
Status Code: C
Label Date: 11/05/1997
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: EXTREMELY FLAMMABLE. ACUTE: EYE:IRRITATION. SKIN:MAY BE
ABSORBED THROUGH THE SKIN IN HARMFUL AMOUNTS. MAY CAUSE SKIN IRRITATION. MAY
CAUSE DERMATITIS. INHAL:POSSIBLE IRRITATION OF THE RESPIRATORY SYST EM CAN
OCCUR CAUSING A VARIETY OF SYMPTOMS SUCH AS DRYNESS OF THE THROAT, TIGHTNESS
OF THE CHEST, AND SHORTNESS OF BREATH. MAY CAUSE CNS DEPRESSION. INGEST:
HARMFUL/FATAL. MAY CAUSE BLINDNESS/PERMANEN T EYE DAMAGE. CHRONIC:
LIVER/KIDNEY DAMAGE. PERMANENT CNS DAMAGE. GI EFFECTS. DERMATITIS, BLINDNESS.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|
| ALL PAGES On Chemical Property IN THIS GROUP
| | NAME | CAS |
|
MEDIUM GRAY LO-VOC PVC CEMENT, 31866
| |
|
MEDIUM GRAY LO-VOC PVC CEMENT, 31867
| |
|
MEDIUM GRAY LO-VOC PVC CEMENT, 31868
| |
|
MEDIUM GRAY LO-VOC PVC CEMENT, 31869
| |
|
1 GREASELESS LUBRICANT, 00116
| 64742-47-8
64742-30-9
124-38-9 |
|
H-152
| |
|
RTV SILICONE SEALANT
| |
|
EPOCAST HARDENER 946, FPC5000
| |
|
BUTYL FLEX CAULK
| |
|
SCOTCHWELD 2216 B/A GRAY EPOXY ADHESIVE PART B
| 25068-38-6
1332-58-7 |
|
289244-502 TONER FOR DPC LZR 600/900, SHARP, (SUPDAT)
| |
|
80-6106-2549-5, ADHESIVE FOR 1600 HAT HALT (SUP DAT)
| |
|
7542 SCOTCHBRAND MULTI-PURPOSE PRIMER, FH-5000-3628-7
| 7732-18-5
868-77-9 |
|
SCOTCH-SEAL 800 INDUSTRIAL SEALANT, 62-0800-2631-3
| 78-93-3
9003-18-3
8050-31-5
471-34-1
108-10-1
78-51-3
1327-39-5
13463-67-7
1309-37-1
69-72-7
1314-13-2 |
|
BC-01 INK CARTRIDGE BLACK, F45-0022-000
| |
|
PF-5060 PERFORMANCE FLUID, 98-0211-5603-3
| 86508-42-1 |
|
NO FLASH ELECTRO CONTACT CLEANER, 04018
| 1717-00-6
67-63-0
124-38-9 |
|
7070 ODC FREE CLEANER, 20162
| 64742-48-9
5989-27-5 |
|
CITRUS BASE INDUSTRIAL CLEANER (AEROSOL)
| |
|
PIG REPAIR PUTTY, TPY201
| |
|
CARBON DIOXIDE, GAS
| 124-38-9 |
|
SCOTCH-GRIP 1099 PLASTIC ADHESIVE,0-54586-00006-0
| 67-64-1
9003-18-3
9003-35-4
55185-45-0
69-72-7
1314-13-2 |
|
41650 SUPER BONDER(R) 416 GAP FILLING INST ADH
| 7085-85-0
9011-14-7
123-31-9 |
|
IPA 403
| |
|
1258 PRIMASET PT-30
| |
|
MICROFINISH (AEROSOL)
| |
|
ENERPAC HF G HOF HYDRAULIC OIL
| |
|
LATEX CONCRETE SEALANT
| |
|
HEA
| 14808-60-7
94-36-0
62395-94-2
100-42-5 |
|
THIXON 404
| |
|
NO. 5062 DEVOUR REMOVE AERO, 5062
| 75-09-2
67-56-1 |
|
NO 5195 GASKET-IN-A-CAR, 5195
| 4253-34-3
17689-77-9
112945-52-5 |
|
INPRO-CLEAN 2500, 4407
| |
|
MANGANOUS SULFATE, 1071
| 7785-87-7 |
|
HYDROGEN SULFITE TEST PAPER, 25377
| |
|
NO 2356 STIX VERTICAL DEGR, 2356
| 111-76-2 |
|
SPILFYTER MERC-I-CATOR POWDER, 5230 SERIES
| |
|
NO 2769 KEEP UP DISINFECTANT, 2769
| 111-76-2 |
|
BLASTER
| |
|
CYANIDE, IC-CN-M
| 151-50-8
1310-58-3 |
|
COMPONENT B FOR 656-58 SERIES PART B, X-502
| 123-54-6
3779-63-3
88230-35-7
110-12-3 |
|
CHEMLOK 8560
| |
|
VM&P NAPHTHA HYDROCARBON, S1119
| 64742-89-8 |
|
5053 ACCENT BASE, WALMART COLORPLACE LATEX (SUPDAT)
| 471-34-1
25265-77-4
107-21-1
1332-58-7 |
|
WALMART INT FLAT DEEP BASE, 5052
| 471-34-1
25265-77-4
107-21-1
13463-67-7
1332-58-7 |
|
OVEN BRITE, 08771
| 34590-94-8
1310-73-2
7732-18-5 |
|
PRIMASHEET 1000
| |
|
TAPOUT
| |
|
CHEMLOK Y-4310
| 64-17-5
67-56-1 |
|
CHEMLOK 253X
| |
|
|