HB FULLER CO -- 00-0120
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CGQFD
MSDS NAME: 00-0120
Responsible Party
Name: HB FULLER CO
Address: 3530 LEXINGON AVE
City: ST PAUL MN 55126-8076
Info Phone: 612-481-3300
Emergency Phone Number: 800-228-5635;800-424-9300(CHEMTREC)
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: H B FULLER COMPANY
Address: 3530 LEXINGTON AVENUE N
City: ST PAUL MN 55126-8076
Phone: 888-853-1758/651-236-5300
Name: HB FULLER CO
Address: 1200 WOLTERS BLVD
City: VADNAIS HEIGHTS MN 55110
Phone: 612-481-3300
=======================================================
Ingredients
=======================================================
Name: PETROLEUM WAX
% Wt: 10-30
OSHA PEL: 2 MG/M3 (MFR)
ACGIH TLV: 2 MG/M3 (MFR)
-----------------------------
Cas: 108-05-4
RTECS #: AK0875000
Name: ACETIC ACID, VINYL ESTER; (VINYL ACETATE) (SARA 302/313) (CERCLA)
% Wt: <0.1
OSHA PEL: 10 PPM
ACGIH TLV: 10 PPM; 15 STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CONTACT W/MOLTEN MATL WILL CAUSE BURNS. EYES: VAPORS &
FUMES RELEASED AT OR ABOVE APPLICATION TEMPS MAY CAUSE IRRIT. SKIN: NO KNOWN
EFFECTS. INHAL: VAPORS & FUMES MAY CAUSE IRRIT OF NOSE, THROAT & RES
PIRATORY TRACT. OVEREXP MAY CAUSE HEADACHES & DIZZINESS. RPTD EXPOS MAY
LEAD TO RESPIRATORY SENSIT. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: INGEST: NOT AN ANTICIPATED ROUTE
OF EXPOS. SMALL AMOUNTS ARE NOT ANTICIPATED TO BE HARMFUL. CHRONIC: NO
ANTICIPATED CHRONIC EFFECTS. THIS PROD MAY CONTAIN LOW LEVELS OF VINYL
ACETATE; IT HAS BEEN IDENTIFIED AS AN ANIMAL CARCINOGEN BY IARC. OVEREXP TO
VINYL ACETATE SHOULD NOT OCCUR W/NORMAL HANDLING & USE.
Medical Cond Aggravated By Exposure: NO KNOWN EFFECTS ON OTHER ILLNESSES.
First Aid: EYES: IMMED FLUSH W/POTABLE WATER FOR AT LEAST 15 MIN, SEEK
ASSISTANCE FROM MD (FP N). SKIN: FOR BURNS:IMMERSE CONTACT AREA IMMED IN
COLD, CLEAN WATER. DO NOT ATTEMPT TO REMOVE SET PRODUCT. REMOVAL CO ULD
RESULT IN SEVERE TISSUE DAMAGE. COVER CONTACT AREA W/CLEAN WET COMPRESSES
& TAKE SUBJECT TO MD IMMED. NOTE TO MD: MATL SHOULD NOT BE FORCIBLY
PULLED FROM SKIN. MINERAL OIL MAY BE USED TO LOOSEN MA TL. INHAL: REMOVE TO
FRESH AIR. CALL MD IF SYMPTOMS PERSISTS. INGEST: IF PERSON CAN SWALLOW, GIVE
ONE GLASS OF WATER OR MILK. DO NOT INDUCE VOMITING. GET IMMED MED ATTN. NEVER
GIVE ANYTHING BY MOUTH T O AN UNCON PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ALLOW TO SOLIDIFY AT ROOM TEMPERATURE, SCRAPE UP AND
PLACE IN DISPOSAL CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: TO THE BEST OF MFR'S KNOWLEDGE, THIS PROD DOES NOT MEET
THE DEFINITION OF HAZ WASTE UNDER US EPA HAZ WASTE REGS 40 CFR 261. DISPOSE
OF IN AN APPRVD LANDFILL. CONSULT FED, STATE, LOCAL OR PROVINCIAL AU
THORITIES FOR MORE RESTRICTIVE REQUIREMENTS.
Handling And Storage Precautions: AVOID BREATHING VAPORS/FUMES OF HEATED
PRODUCT. PREVENT CONTACT W/MOLTEN PRODUCT. CONSULT THE TECHNICAL DATA SHEET
FOR SPECIFIC STORAGE INSTRUCTIONS.
Other Precautions: IF THIS MATERIAL IS HEATED TO TEMPERATURES SUFFICIENT TO
PRODUCE SMOKE OR FUMES, THE TLV-TWA OF 0.1 MG/M3 (AS FORMALDEHYDE) FOR ROSIN
CORE SOLDER PYROLYSIS PRODUCTS SHOULD BE OBSERVED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point Text: >400F,>204C
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, CHEMICAL FOAM OR WATER FOG.
USING A DIRECT, STRAIGHT WATER STREAM MAY TEND TO SPREAD FIRE.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). AVOID USING DIRECT STRAIGHT WATER STREAM ON MOLETN MATL TO
REDUCE SPLATTERING & SPREADING OF FIRE.
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NORMALLY REQUIRED. USE NIOSH APPROVED RESPIRATOR IF
CONDITIONS WARRANT.
Ventilation: HOT MELTS SHOULD BE USED W/GOOD VENT. AT APPLICATION TEMP USE OF
LOCAL EXHAUST OVER PREMELTING RESERVOIR IS ENCOURAGED.
Protective Gloves: THERMALLY PROTECTIVE GLOVES.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGS AND FULL LENGTH FACESHIELD (FP
N).
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N). AT
ELEVATED TEMPS PREVENT CONTACT BY WEARING LONG SLEEVED SHIRT.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 0.98
Appearance and Odor: SOLID, CHARACTERISTIC COLOR; NEUTRAL ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NOT ESTABLISHED.
Hazardous Decomposition Products: NOT ESTABLISHED.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC COMPOUND: NEGLIG LEVELS EXPECTED AT AMBIENT
TEMP & PRESSURE. LOW MOLECULAR WEIGHT HYDROCARBONS
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: 00-0120
Assigned IND: Y
Company: HB FULLER CO
Street: 1200 WOLTERS BLVD
City: VADNAIS HEIGHTS MN
Zipcode: 55110
Health Emergency Phone: 800-228-5635;800-424-9300(CHEMTREC)
Label Required IND: Y
Date Of Label Review: 02/19/1998
Status Code: C
Label Date: 02/19/1998
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: CONTACT WITH MOLTEN MATERIAL WILL
CAUSE BURNS. EYES: VAPORS AND FUMES RELEASED AT OR ABOVE APPLICATION
TEMPERATURES MAY CAUSE IRRITATION. INHALATION: VAPORS AND FUMES MAY CAUSE IRR
ITATION OF NOSE, THROAT AND RESPIRATORYTRACT. MAY CAUSE HEADACHES AND
DIZZINESS. CHRONIC: REPEATED EXPOSURE MAY LEAD TO RESPIRATORY SENSITIZATION.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.