barium sulfate bisphenol a epoxy resin; (epoxy resin) titanium oxide; (titanium dioxide) dust, nuisance; (nuisance dust) supdat: shown that some epoxy resins have mutagenic capabilities while vent: or acgih's tlv twa limit.
HERBERTS-O BRIEN INC -- RAPID CHARCOAL II, RLH605S7055
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CGTVX
MSDS NAME: RAPID CHARCOAL II, RLH605S7055
Responsible Party
Name: HERBERTS-O BRIEN INC
Address: 9800 GENARD RD
City: HOUSTON TX 77041-7624
Info Phone: 713-939-4000
Emergency Phone Number: 800-424-9300 (CHEMTREC)
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: DUPONT POWDER COATINGS
Address: 9800 GENARD RD
City: HOUSTON TX 77041-7624
Phone: 713-939-4000
=======================================================
Ingredients
=======================================================
Cas: 7727-43-7
RTECS #: CR0600000
Name: BARIUM SULFATE
% Wt: 15-40
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 25036-25-3
Name: BISPHENOL A EPOXY RESIN; (EPOXY RESIN)
% Wt: 10-30
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
Name: TITANIUM OXIDE; (TITANIUM DIOXIDE)
% Wt: 1-5
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Name: DUST, NUISANCE; (NUISANCE DUST)
% Wt: 100
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Name: SUPDAT: SHOWN THAT SOME EPOXY RESINS HAVE MUTAGENIC CAPABILITIES WHILE
OTHERS HAVE NOT.
-----------------------------
Name: VENT: OR ACGIH'S TLV TWA LIMIT.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: BARIUM SULFATE: INHAL OF DUSTS CNTNG BARIUM SULFATE
MAY BE IRRIT TO RESP TRACT. CONT W/EYES MAY ALSO CAUSE IRRIT. TITANIUM
DIOXIDE: INGEST: LOW ORAL TOX. NO TOXIC EFTS DUE TO INGEST ARE DESCRIB ED IN
LITERATURE. INHAL: IRRITATING TO UPPER RESP TRACT. EYE CONT: IRRITATING.
EPOXY RESIN: INGEST: (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: LOW ORDER OF TOX. INHAL: NOT A
LIKELY ROUTE OF EXPOS DUE TO VERY LOW VOLAT. EYE CONT: MAY CAUSE SLIGHT
IRRIT. SKIN CONT: MAY CAUSE SLIGHT IRRIT. CHRONIC: BARIUM SULFATE: PLNGD
EXPOS COULD CA USE BENIGN PNEUMOCONIOSIS CALLED BARITOSIS. TITANIUM DIOXIDE:
LAB STUDIES SHOW INHAL EXPOS TO HIGH LEVELS (SUPDAT)
Medical Cond Aggravated By Exposure: EPOXY RESIN: MAY AGGRAVATE EXISITING SKIN
CONDITIONS, A DERMAL ALLERGEN.
First Aid: EYE CONT: FLUSH W/COOL WATER FOR AT LST 15 MINS, OCCASNLY LIFTING
LIDS TO ENSURE THOROUGH RINSING. SEEK MED ASSISTANCE. SKIN CONT: WASH
THOROUGHLY W/SOAP & WATER. INHAL: REMOVE TO FRESH AIR. INGEST: D RINK 1
OR 2 GLASSES OF WATER & INDUCE VOMITING BY PLACING FINGER AT BACK OF
THROAT. SEEK MED ASSISTANCE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SWEEP UP CAREFULLY OR USE EXPLOSION-PROOF VACUUM
CLEANER, THE DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: MANAGE OR DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
Handling And Storage Precautions: KEEP CONTAINERS SEALED & AVOID STATIC
ELECTRICITY DISCHARGES. KEEP ALL EQUIP CLEAN & PROPERLY GROUNDED TO AVOID
STATIC ELECTRICITY DISCHARGE.
Other Precautions: KEEP WORK AREAS FREE OF DUST. AVOID EXCESSIVE SKIN CONTACT.
DO NOT INGEST OR INHALE. KEEP OUT OF REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: FOAM, CO*2, DRY CHEMICAL, WATER FOG, DRY SAND.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE PROPERLY FITTED NIOSH APPRVD MECHANICAL RESPIRATOR
OR MASK TO AVOID BREATHING DUST. CAREFULLY FOLLOW RESPIRATOR MANUFACTURER'S
INSTRUCTIONS FOR USE.
Ventilation: PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP AIR CONTAM
CONC BELOW APPLIC OSHA PERMISSIBLE EXPOS LEVELS
Protective Gloves: IMPERVIOUS GLOVES (FP N).
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N).
PROTECTIVE OVERALLS RECOMMENDED.
Work Hygienic Practices: REMOVE AND WASH SOILED CLOTHING.
Supplemental Safety and Health: EFTS OF OVEREXP: (250 MG/KG) OF TITANIUM
DIOXIDE CAUSES CANCEROUS TUMORS IN RATS. THIS RESPONSE OCCURS AT LOWER EXPOS
LEVELS & MAY BE DUE TO HIGH LEVELS OVERWHELMING NORM LUNG CLEARANCE
MECHANISMS. RE LEVANCE OF DATA TO HUMANS IS NOT SIGNIFICANT WHERE TLV IS
OBSERVED. EPOXY RESIN: IN VITRO LAB STUIDES HAVE
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.73604
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: NOT KNOWN
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: FUMES MAY CONTAIN CO, CO*2, NO*2 OR OTHER
NITROGEN COMPOUNDS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC COMPOUND: 0
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: RAPID CHARCOAL II, RLH605S7055
Company: DUPONT POWDER COATINGS
Street: 9800 GENARD RD
City: HOUSTON TX
Zipcode: 77041-7624
Health Emergency Phone: 800-424-9300 (CHEMTREC)
Label Required IND: Y
Date Of Label Review: 04/08/1998
Status Code: C
Label Date: 04/08/1998
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: BARIUM SULFATE: MAY BE IRRITATING TO RESPIRATORY
TRACT. EYE CONT: IRRITATION. TITANIUM DIOXIDE: INGEST: LOW ORAL TOXICITY.
INHAL: IRRITATING TO UPPER RESPIRATORY TRACT. EYE CONT: IRRITATING. EP OXY
RESIN: INGESTION: LOW ORDER OF TOXICITY. EYE CONT: SLIGHT IRRITATION. SKIN
CONT: SLIGHT IRRITATION. CHRONIC: BARIUM SULFATE: BENIGN PNEUMOCONIOSIS
CALLED BARITOSIS. TITANIUM DIOXIDE: CANCEROUS TUM ORS IN RATS. EPOXY RESIN:
MUTAGENIC CAPABILITIES POSSIBLE.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.