chlorinated paraffin wax polychlorinated alkanes (chlorinated paraffins) chlorin paraffin & hydrocarb waxes residual monomer aluminum oxide (sara 313) titanium oxide; (titanium dioxide) ing 7: theoretically determined using epa publication 450/3-84-019. supdat: cntnr & liq emulsion. levels in excess of acceptable ing 9: above emulsion. all proc approp for confined space entry should be ing 10: work in bulk storage tank.
HB FULLER CO -- VAPOR-SAFE COATING, FOSTER 30-80
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CHTCY
MSDS NAME: VAPOR-SAFE COATING, FOSTER 30-80
Responsible Party
Name: HB FULLER CO
Address: 2900 GRANADA LANE
City: AOAKDALE MN 55138
Info Phone: 612-236-3785
Emergency Phone Number: 888-853-1758;800-424-9300(CHEMTREC)
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: H. B. FULLER AUTOMOTIVE PRODUCTS, INC
Address: 13650 EAST TEN MILE ROAD
Box: 306
City: WARREN MI 48090
Phone: 313-776-5000
Name: HB FULLER CO
Address: 1200 WOLTERS BLVD
City: VADNAIS HEIGHTS MN 55110
Phone: 612-481-3300
=======================================================
Ingredients
=======================================================
Cas: 63449-39-8
RTECS #: RV0450000
Name: CHLORINATED PARAFFIN WAX
% Wt: 5-10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Name: POLYCHLORINATED ALKANES (CHLORINATED PARAFFINS)
% Wt: 5-10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 108171-26-2
RTECS #: RV0480000
Name: CHLORIN PARAFFIN & HYDROCARB WAXES
% Wt: 5-10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Name: RESIDUAL MONOMER
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 1344-28-1
RTECS #: BD1200000
Name: ALUMINUM OXIDE (SARA 313)
% Wt: 10-30
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
Name: TITANIUM OXIDE; (TITANIUM DIOXIDE)
% Wt: 1-5
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
RTECS #: 9999999VO
Name: ING 7: THEORETICALLY DETERMINED USING EPA PUBLICATION 450/3-84-019.
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Name: SUPDAT: CNTNR & LIQ EMULSION. LEVELS IN EXCESS OF ACCEPTABLE
EXPOSURES CAN ACCUM IN NON-VENTED HEADSPACES
-----------------------------
Name: ING 9: ABOVE EMULSION. ALL PROC APPROP FOR CONFINED SPACE ENTRY SHOULD BE
IMPLEMENTED PRIOR TO PERFORMING ANY
-----------------------------
Name: ING 10: WORK IN BULK STORAGE TANK.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: INHAL: EXPOSURE TO VAPORS IN POORLY VENTILATED
AREAS MAY CAUSE IRRITATION OF NOSE, THROAT & RESPIRATORY TRACT. INGEST:
NOT AN ANTICIPATED ROUTE OF EXPOSURE. SMALL AMOUNTS ARE NOT ANTICIPATED TO
BE HARMFUL. CHRONIC: CHLORINATED PARAFFIN HAS BEEN IDENTIFIED AS ANIMAL
CARCINOGEN IN FEEDING STUDIES (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: CHLORINATED PARAFFIN WAX: IARC MONO, VOL 48, PG
55, 1990: GROUP 2B. NTP 7TH ANNUAL RPT ON CARCINS, 1994: ANTIC (SUPDAT)
Signs And Symptions Of Overexposure: HLTH HAZ: WITH LABORATORY ANIMALS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE: FLUSH IMMED W/WATER FOR @ LST 15 MINS. CONSULT PHYS IF IRRIT
PERSISTS. SKIN: WASH W/SOAP & WATER. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. INHAL: REMOVE TO FRESH AIR. INGEST: IF PERSON CAN SWA LLOW, GIVE 1
GLASS OF WATER/MILK. DO NOT INDUCE VOMIT. GET IMMED MED ATTN. NEVER GIVE
ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: DIKE IF NECESSARY, CONTAIN SPILL WITH INERT ABSORBENT
& TRANSFER TO CONTAINERS FOR DISPOSAL. KEEP SPILLED PRODUCT OUT OF
SEWERS, WATERSHEDS OR WATER SYSTEMS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: TO BEST OF MFR'S KNOWLEDGE, THIS PROD DOES NOT MEET
DEFINITION OF HAZ WASTE UNDER U.S. EPA HAZ WASTE REGS 40 CFR 261. SOLIDIFY
& DISPOSE OF IN APPRVD LANDFILL. CONSULT STATE, LOCAL/PROVINCIAL AUTH FOR
MORE RESTRICTIVE REQUIREMENTS.
Handling And Storage Precautions: AVOID TEMPERATURES EXTREMES IN STORAGE.
CONSULT TECHNICAL DATA SHEET FOR SPECIFIC STORAGE INSTRUCTIONS.
Other Precautions: WEAR APPROP PROTE EQUIP WHEN WORKING W/PROD. PROD CNTNS
LIMITED AMTS OF RESIDUAL MONOMER. UNDER NORM HNDLG & USE CNDTNS RESIDUAL
MONOMER SHOULD NOT PRESENT HAZARD. IN STOR MONOMER WILL MIGRATE FROM EM
ULSION & ESTABLISH EQUILIBRIUM (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: >200F,>93C
Extinguishing Media: NON-FLAMMABLE IN LIQUID STATE; USE WATER SPRAY, FOAM, DRY
CHEMICAL OR CARBON DIOXIDE ON DRIED PRODUCT.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: THERE IS POSSIBILITY OF PRESS BUILDUP IN CLSD
CNTNRS WHEN HEATED. WATER SPRAY MAY BE USED TO COOL CNTNRS. HAZ COMBUST PROD:
INCOMPLETE COMBUST CAN YIELD(SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NORMALLY REQUIRED. USE NIOSH APPROVED RESPIRATOR IF
CONDITIONS WARRANT.
Ventilation: GENERAL DILUTION VENTILATION.
Protective Gloves: RUBBER GLOVES.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N).
APPROPRIATE PROTECTIVE CLOTHING.
Work Hygienic Practices: LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health: EXPLO HAZ: LOW MOLECULAR WT HYDROCARBONS,
CARBON MONOXIDE, HYDROGEN CHLORIDE, PHOSGENE. EXPLAN OF CARCIN: TO BE
CARCINOGEN. CHLORIN PARAFFIN & HYDROCARBON WAXES: MONO, VOL 48, PG 55,
1990: GROUP 2B. N TP 7TH ANNUAL RPT ON CARCINS, 1994: ANTICIPATED TO BE
CARCINOGEN. OTHER PREC: BETWEEN HEADSPACE IN STORAGE
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >200F,>93C
Spec Gravity: 1.4
PH: 10
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: NOT KNOWN
Appearance and Odor: WHITE TO STANDARD LIQUID. MILD, SWEET ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NOT ESTABLISHED.
Hazardous Decomposition Products: HYDROGEN CHLORIDE, PHOSGENE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: OLATILE ORGANIC COMPOUND, LESS WATER. 25 G VOC/LITER OF
MATERIAL, LESS WATER & EXECMPT SOLVENTS. (VOC
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: VAPOR-SAFE COATING, FOSTER 30-80
Assigned IND: Y
Company: HB FULLER CO
Street: 1200 WOLTERS BLVD
City: VADNAIS HEIGHTS MN
Zipcode: 55110
Health Emergency Phone: 888-853-1758;800-424-9300(CHEMTREC)
Label Required IND: Y
Date Of Label Review: 06/09/1998
Status Code: C
Label Date: 06/09/1998
Origination
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: INHAL: EXPOSURE TO VAPORS IN POORLY
VENTILATED AREAS MAY CAUSE IRRITATION OF NOSE, THROAT & RESPIRATORY
TRACT. INGEST: NOT AN ANTICPATED ROUTE OF EXPOSURE. SMALL AMOUNTS ARE NOT AN
TICIPATED TO BE HARMFUL. CHRONIC: CANCER HAZARD. CONTAINS CHLORINATED
PARAFFINS WHICH ARE LISTED AS ANIMAL LIVER CARCINOGENS (FP N).
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.