PARKS CORPORATION -- POLYURETHANE SATIN, 5-GAL 0522
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CJQVM
MSDS NAME: POLYURETHANE SATIN, 5-GAL 0522
Responsible Party
Name: PARKS CORPORATION
Address: ONE WEST STREET
City: FALL RIVER MA 02720
Info Phone: 508-679-5938
Emergency Phone Number: 508-679-5938
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: PARKS CORPORATION
Address: ONE WEST STREET
City: FALL RIVER MA 02720
Phone: 508-679-5938
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Cas: 8052-41-3
RTECS #: WJ8925000
Name: STODDARD SOLVENT; (ALIPHATIC HYDROCARBONS (STODDARD TYPE)
% low Wt: 50.
% high Wt: 55.
OSHA PEL: 2900 MG/M3;500 PPM
ACGIH TLV: 525 MG/M3;100 PPM
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 64-17-5
RTECS #: KQ6300000
Name: ETHYL ALCOHOL
% low Wt: 0.
% high Wt: 5.
OSHA PEL: 1900 MG/M3;1000 PPM
ACGIH TLV: 1880 MG/M3;1000 PPM
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 112926-00-8
RTECS #: VV7315000
Name: AMORPHOUS SYNTHETIC SILICA GEL; (SILICON DIOXIDE)
% low Wt: 3.
% high Wt: 8.
OSHA PEL: see Table Z-3
ACGIH TLV: 10 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 71-43-2
RTECS #: CY1400000
Name: BENZENE
< Wt: .1
OSHA PEL: see 1910.1028
ACGIH TLV: 32 MG/M3;10 PPM
ACGIH STEL: NOT ESTABLISHED
EPA Rpt Qty: 10 LBS
DOT Rpt Qty: 10 LBS
------------------------------
Cas: 108-88-3
RTECS #: XS5250000
Name: TOLUENE
< Wt: .1
OSHA PEL: see Table Z-2
ACGIH TLV: 188 MG/M3;50 PPM
ACGIH STEL: NOT ESTABLISHED
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYES: EXPOS MAY CAUSE MILD EYE IRRIT. SYMPS MAY
INCL STINGING, TEARING & REDNESS. SKIN: EXPOS MAY CAUSE MILD SKIN IRRIT.
PRLNG/RPTD EXPOS MAY DRY SKIN. SYMPS MAY INCL REDNESS, BURNING, DRYING &
CRACKING & SKIN BURNS. SKIN ABSORPTION IS POSS, BUT HARMFUL EFTS ARE NOT
EXPECTED FROM THIS ROUTE OF EXPOS UNDER NORMAL CNDTNS OF HANDLING & USE.
INHAL: EXPOS TO VAP/MIST IS POSS. SHORT-TERM INHAL TO X IS LOW. BRTHG SMALL
AMTS DURING NORMAL HANDLING IS NOT LIKELY TO CAUSE HARMFUL EFTS; BRTHG LGE
AMTS MAY BE HARMFUL. SYMPS MORE TYPICALLY SEEN AT AIR CONCS EXCEEDING REC
EXPOS LIMITS. SYMPS OF EXPOS MAY INCL: IRRIT (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: BASED ON AVAILABLE INFORMATION, THIS MATERIAL
CANNOT BE CLASSIFIED WITH REGARD TO CARCINOGENCITY. THIS MATERIAL IS NOT
LISTED AS A CARCINOGEN BY IARC, NTP OR OSHA.
Signs And Symptions Of Overexposure: HLTH HAZ: (NOSE, THROAT, RESP TRACT) &
CNS DEPRESS (DIZZ, DROWS, WEAK, FATIGUE, NAUS, HDCH, UNCON). INGEST: SINGLE
DOSE ORAL TOX IS LOW. SWALLOWING SMALL AMTS DURING NORMAL HNDLG IS NOT LIKELY
TO CAUS E HARMFUL EFTS; SWALLOWING LRG AMTS MAY BE HARMFUL. SYMPS MAY INCL;
GI IRRIT (NAUS, VOMIT, DIARR) & CNS DEPRESS (DIZZ, DROWS, WEAK, FATIGUE,
NAUS, HDCH, UNCON). THIS MATL CAN ENTER LUNGS DURING SWALLO WING/VOMIT &
CAN CAUSE LUNG INFLAMM &/DMG. CHRONIC: TOLUENE & BENZENE APPEAR ON
NAVY LIST OF OCCUP CHEM REPROD HAZS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO (FP N).
Medical Cond Aggravated By Exposure: PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS MATERIAL. PRE-EXISTING LUNG DISORDERS (EG
ASTHMA-LIKE CONDITIONS) MAY BE AGGRAVATED BY EXPOSURE TO THIS MATERIAL.
First Aid: EYE: IF SYMPS DEVELOP, MOVE INDIVIDUAL AWAY FROM EXPOS & INTO
FRESH AIR. FLUSH EYES GENTLY W/H*2O WHILE HOLDING EYELIDS APART FOR AT LEAST
15 MIN. IF SYMPS PERSIST/THERE IS ANY VISUAL DIFFICULTY, SEEK MED ATTN.
SKIN: REMOVE CONTAMD CLTHG. WASH EXPOSED AREA W/SOAP & H*2O. IF SYMPS
PERSIST, SEEK MED ATTN. LAUNDER CLTHG BEFORE REUSE. INHAL: IF SYMPS DEVELOP,
IMMED MOVE INDIVIDUAL AWAY FROM EXPOS & IN TO FRESH AIR. SEEK IMMED MED
ATTN. KEEP PERS WARM & QUIET. IF PERS IS NOT BRTHG, BEGIN ARTF RESP. IF
BRTHG IS DIFFICULT, ADMIN OXYGEN. INGEST: DO NOT INDUCE VOMIT. THIS MATL IS
ASPIRATION HAZ. IF INDI VIDUAL IS DROWS/UNCON, (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SMALL SPILL: ABSORB LIQ ON VERMICULITE, FLOOR
ABSORBENT/OTHER ABSORBENT MATL. LRG SPILL: ELIM ALL IGNIT SOURCES (FLARES,
FLAMES, INCL PILOT LIGHTS, ELEC SPARKS). PERS NOT WEARING PROT EQUIP SHOULD
BE EXCLUDED FROM AREA OF SPILL UNTIL CLEAN-UP HAS BEEN COMPLETED. STOP SPILL
AT SOURCE. PVNT FROM ENTERING DRAINS, SEWERS, STREAMS/OTHER BODIES OF WATER.
PVNT FROM SPREADING. (OTHER INFO)
Waste Disposal Methods: SMALL SPILL: DISPOSE OF IN ACCORDANCE WITH ALL LOCAL,
STATE AND FEDERAL REGULATIONS. LARGE SPILL: DISPOSE OF IN ACCORDANCE WITH ALL
APPLICABLE LOCAL, STATE AND FEDERAL REGULATIONS.
Handling And Storage Precautions: STORE AWAY FROM HEAT, SPARKS AND OPEN FLAME.
AVOID PROLONGED SKIN CONTACT. DO NOT BREATHE SPRAY MIST.
Other Precautions: GROUND CONTAINERS WHEN POURING & LIMIT FREE-FALL TO FEW
INCHES TO PREVENT STATIC SPARKS. AVOID SPONTANEOUS COMBUSTION OF CONTAMINATED
RAGS/OTHER EASILY IGNITABLE ORGANIC ACCUMULATIONS BY IMMEDIATE IMM ERSION IN
WATER. EMPTIED CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES. DO NOT CUT,
PUNCTURE/WELD ON/NE AR THE CONTAINER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point: =25.6C, 78.F
Lower Limits: 1%
Extinguishing Media: REGULAR FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NEVER USE WELDING/CUTTING TORCH ON/NEAR CNTNRS
(EVEN EMPTY) BECAUSE PROD (EVEN JUST RESIDUE) CAN IGNITE EXPLOSIVELY. KEEP
CNTNRS TIGHTLY CLSD & ISOLATE FROM HEAT. VAPS ARE HEAVIER THAN AIR &
MAY TRAVE L ALONG GROUND/BE MOVED BY VENT & IGNITED BY HEAT, PILOT
LIGHTS, OTHER FLAMES & IGNIT SOURCES (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS FOR
CONCENTRATIONS ABOVE TLV LIMITS.
Ventilation: PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves: CHEMICAL RESISTANT GLOVES.
Eye Protection: ANSI APPROVED CHEMICAL WORKERS GOGGLES (FP N).
Other Protective Equipment: EYE WASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). WEAR IMPERVIOUS CLOTHING AND BOOTS TO PREVENT REPEATED OR
PROLONGED SKIN CONTACT.
Supplemental Safety and Health: FIRST AID PROC: PLACE ON LEFT SIDE WITH HEAD
DOWN. SEEK MEDICAL ATTENTION. IF POSSIBLE, DO NOT LEAVE INDIVIDUAL
UNATTENDED. EXPLO HAZ: AT LOCATIONS DISTANT FROM MATERIAL HANDLING POINT.
RATING: H EALTH: 1, FLAMMABILITY: 3, REACTIVITY: 0, PROTECTION: D. PHYSICAL
DATA: VOC: <450 G/L.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: >157.2C, 315.F
B.P. Text: 315-380F
Vapor Pres: 2 MMHG @ 20C
Vapor Density: >1 (AIR=1)
Spec Gravity: 0.902 (60F/60F)
Evaporation Rate & Reference: LESS THAN 1 (ETHER = 1)
Solubility in Water: NEGLIGIBLE
Appearance and Odor: BROWNISH/CLOUDY; CHARACTERISTIC ODOR.
Percent Volatiles by Volume: 57%
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: CANNOT OCCUR.
=======================================================
Toxicological Information
=======================================================
=======================================================
Regulatory Information
=======================================================
State Regulatory Information: STATE OF CALIFORNIA'S SAFE DRINKING WATER &
TOX ENFORCEMENT ACT OF 1986 (PROP 65) DEVELOPS LIST OF CHEM THAT REQUIRE
SPECIFIC WARNINGS RELATING TO CANCER &/REPROD TOX. THIS PRODUCT CONTAINS
FOLLOWING CHEM SUBJECT TO REPORTING REQUIREMENTS OF STATE OF CALIFORNIA'S
SAFE DRINKING WATER & TOXIC ENFORCEMENT ACT OF 1986 (PROP 65). CHEMICAL:
BENZENE, CAS #: 71-43-2, QUANTITY: <10 PPM. CHEMICAL: TOLUOL, C AS #:
108-8-3, QUANTITY: 200 PPM. WARNING ON PRODUCT STATES: WARNING: USE OF THIS
PROD WILL EXPOSE Y OU TO BENZENE WHICH IS KNOWN TO CAUSE CANCER & TO
TOLUOL WHICH IS KNOWN TO CAUSE BIRTH DEFECTS/OTHER REPROD HARM.
=======================================================
Other Information
=======================================================
Other Information: FIRST AID PROC: PLACE ON LEFT SIDE W/HEAD DOW. SEEK MED
ATTN. IF POSS, DO NOT LEAVE INDIVIDUAL UNATTENTED. SPILL PROC: IF RUNOFF
OCCURS, NOTIFY AUTH AS REUIRED. PUMP/VACUUM TRANSFER SPILLED PROD TO CL EAN
CNTNRS FOR RECOVERY. ABSORB UNRECOVERABLE PROD. TRANSFER CONTAMD ABSORBENT,
SOIL & OTHER MATLS TO CNTNRS FOR DISPOSAL. PVNT RUN-OFF TO SEWERS,
STREAMS/OTHER BODIES OF WATER. IF RUN-OFF OCCURS, NOT IFY PROPER AUTH AS
REQUIRED THAT A SPILL HAS OCCURED. EXPLO HAZ: AT LOCATIONS DISTANT FROM MATL
HNDLG POINT. RATING: HEALTH: 1, FLAMMABILITY: 3, REACTIVITY: 0, PROTECTION:
D. PHYSICAL DATA: VOC: <450 G/L.
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: POLYURETHANE SATIN, 5-GAL 0522
Assigned IND: Y
Company: PARKS CORPORATION
Street: ONE WEST STREET
City: FALL RIVER MA
Zipcode: 02720
Health Emergency Phone: 508-679-5938
Label Required IND: Y
Date Of Label Review: 09/15/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: NO
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE: EYES: MAY CAUSE MILD IRRIT, STINGING,
TEARING & REDNESS. SKIN: MAY CAUSE MILD IRRIT, REDNESS, BURNING, DRYING,
CRACKING & SKIN BURNS. SKIN ABSORPTIONS POSS, BUT HARMFUL EFTS ARE NOT
EXPECTED UNDER NORMAL CNDTNS OF HANDLING& USE. INHAL: BRTHG LGE AMTS MAY
BE HARMFUL. SYMPS OF EXPOS MAY INCL: NOSE, THROAT & RESP TRACT IRRIT, CNS
DEPRESS, DIZZ, DROWS, WEAK, FATIGUE, NAUS, HDCH, & UN CON. INGEST: SINGLE
DOSE ORAL TOX IS LOW. LARGE AMTS MAY BE HARMFUL CAUSING GI IRRIT, NAUS,
VOMIT, DIARR & CNS DEPRESS. CHRONIC: CONTAINS TOLUENE & BENZENE WHICH
APPEAR ON NAVY OCCUP CHEM REPRO HAZS L IST (FP N).
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|