===================== Product Identification =====================
MSDS NAME:CORVE8117 VINYL ESTER LAMINATING RESIN
NIIN:00N020796
MSDS Number: BLRTK
=== Responsible Party ===
Company:INTERPLASTIC CORPORATION
Address:2015 BROADWAY NE
City:MINNEAPOLIS
State:MN
ZIP:55413
Country:US
Info Phone Num:612-331-6850
Emergency Phone Num:800-424-9300 (CHEMTREC)
CAGE:16881
=== Contractor Identification ===
Company:INTERPLASTIC CORP
Address:2015 BROADWAY NE
Box:City:MINNEAPOLIS
State:MN
ZIP:55413
Country:US
Phone:612-331-6850
CAGE:16881
============= Composition/Information on Ingredients =============
Name:INGRED 5: TO PVNT SPREADING, PUMP LIQ TO SALVAGE TANK.
REMAINING LIQ MAY BE TAKEN UP ON SAND, CLAY, EARTH, (SEE ING 5)
RTECS #:9999999ZZ
Name:INGRED 4: FLOOR ABSORB OR OTHER ABSORBENT MATERIAL AND
SHOVELED INTO CONTAINERS.
RTECS #:9999999ZZ
Name:WASTE DISP METH: LOCAL REGULATIONS. CONTAM ABSORBENT SHOULD
BE DISPOSED OF I/A/W LOCAL, STATE & FED REGULATIONS.
RTECS #:9999999ZZ
Name:RESP PROT: ENGINEERING OF ADMINISTRATIVE CONTROLS SHOULD BE
IMPLEMENTED TO REDUCE EXPOSURE.
RTECS #:9999999ZZ
Name:UNSATURATED POLYESTER RESIN; (UNSATURATED POLYESTER BASE
RESIN)
Fraction by Wt: 52.5%
Name:STYRENE, MONOMER (SARA III)
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 47.5%
OSHA PEL:100 PPM
ACGIH TLV:S,50PPM/100STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:SPILL PROC: FROM AREA OF SPILL UNTIL CLEAN-UP HAS BEEN
COMPLETED. STOP SPILL AT SOURCE, DIKE AREA OF SPILL (SEE ING 4)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE SEVERE IRRITATION,
REDNESS, TEARING, BLURRED VISION. SKIN: PROLONGED OR REPEATED
CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS.
INHAL: EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL IRRITATION,
DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE, POSSIBLE UNCON &
EVEN (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:STYRENE: GROUP 2B (IARC)
Effects of Overexposure:HLTH HAZ: ASPHYXIATION. INGEST: CAN CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, DIARRHEA. ASPIRATION
OF MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: THORO WASH EXP AREA W/SOAP & H2O. REMOVE CONTAM CLTHG.
LAUNDER CONTAM CLTHG BEFORE RE-USE. EYES: FLUSH W/LRG AMT OF H2O,
LIFTING UPPER & LOWER LIDS OCCASIONALLY. GET MED ATTN. INGEST: DO
NOT IND UCE VOMIT. KEEP PERSON WARM, QUIET & GET MED ATTN. ASPIR OF
MATL INTO LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUM WHICH CAN BE
FATAL. INHAL: IF AFFECTED, REMOVE INDIVIDUAL TO FRESH AIR. IF (SUPP
DATA)
===================== Fire Fighting Measures =====================
Flash Point:88.0F,31.1C
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:REGULAR FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
H2O/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT & POS ENDANGER
LIFE OF FIREFIGHTER, ESPECIALLY (SUP DAT)
Unusual Fire/Explosion Hazard:VAP ARE HVR THAN AIR & MAY TRAVEL ALONG
GROUND/MAY BE MOVED BY VENT & IGNITED BY PILOT LIGHTS, OTHER
FLAMES, SPARKS, HEATERS, SMOKING, ELEC MOTORS, (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: ABSORB LIQ ON PAPER, VERMICULITE,
FLOOR ABSORB/OTHER ABSORB MATL & TRANSFER TO HOOD. LRG SPILL:
ELIMINATE ALL IGNIT SOURCES (FLARES, FLAMES, INCLUDING PILOT
LIGHTS, ELEC SPARKS). PERSONS NOT WEARING PROT EQUIP SHD BE
EXCLUDED (SEE ING 3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED. STORE IN OPEN CNTNRS; PRLNGD STOR (6
MONTHS), STORE ABOVE 38C (100F).
Other Precautions:SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES
(VAPORS, LIQUID, AND/OR SOLID), ALL HAZARD PRECATIONS GIVEN IN THIS
DATA SHEET MUST BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED, A
NIOSH/ MSHA APPRVD AIR SUP RESP IS ADVISED IN ABSENCE OF PROPER
ENVIRONMENTAL CNTRL. OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA APPRVD
RESP UNDER SPECIFIED CNDT NS. (SEE YOUR SFTY EQUIP SUP.) (ING 7)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:NEOPRENE, NITRILE RUBBER GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS AND LEGS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: IF SPRAYED INTO CNTNRS OF HOT, BURNING LIQ. EXPLO HAZ:
STATIC DISCHARGE, OR OTHER IGNIT SOURCES AT LOCATION DISTANT FROM
MATL HNDLG POINT. FIRST AID PROC: BRTHG IS DFCLT, ADMIN O2. IF
BRTHG HAS STOPPED, GIVE ARTF RESP. KEEP PERSON WARM, QUIET, & GET
MED ATTN.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:SEE ING 2
Vapor Pres:SEE ING 2
Vapor Density:3.6
Spec Gravity:1.11-1.13
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:52.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
STRONG ALKALIES, STRONG MINERAL ACIDS AND OXIDIZING AGENTS.
Stability Condition to Avoid:EXPOSURE TO EXCESSIVE HEAT/OPEN FLAME;
CONTAMINATION WITH OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, LOW
MOLECULAR WEIGHT HYDROCARBONS, ORGANIC ACIDS.
Conditions to Avoid Polymerization:SEE MATERIALS TO AVOID.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL SPILL: ALLOW VOLATILE PORTION TO EVAPORATE
IN HOOD. ALLOW SUFFICIENT TIME FOR VAPS TO COMPLETELY CLEAR HOOD
DUCT WORK. DISP OF REMAINING MATL I/A/W FEDERAL, STATE AND LOCAL
REGS. LRG SPILL: DEST ROY BY LIQ INCINERATION I/A/W FED, ST, & (ING
6)
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|
| ALL PAGES On Chemical Property IN THIS GROUP
| | NAME | CAS |
|
NOKOMIS 3
| |
|
HEXAMETHYLENETETRAMINE N145
| 100-97-0 |
|
R382
| |
|
SF-730T1 BLACK TONER
| 1333-86-4
25767-47-9
102561-46-6 |
|
HAEMA LINE DIFF, 49-018770
| 7681-49-4 |
|
FASHION FLAIR ACRYLIC FLAT HOUSE PAINT WHIT
| 107-21-1
14808-60-7
7732-18-5
1332-58-7
25067-01-0
13463-67-7
1317-65-3 |
|
FILM SOLUTION, 302-4011
| |
|
TONER KONICA/ROYAL 1602MR & 1803MR & 2502MR
| 1333-86-4
9003-07-4 |
|
7500 TONER, 2627501
| 1333-86-4
1309-38-2
39382-25-7 |
|
5018/5028 BLACK DRY INK/BLACK TONER/COPY (S
| 9003-55-8
1309-37-1
8050-09-7
1333-86-4
3843-16-1 |
|
MULTI-PURPOSE LUBRICANT (DRI-SLIDE), 251
| 85595-45-5
26566-95-0
64742-88-7
1317-33-5
7782-42-5
64742-52-5 |
|
RED INSULATING VARNISH, TM 3060
| 108-88-3
67-64-1
71-55-6
1330-20-7
74-98-6 |
|
SAF-T SOLVENT, TM-3265
| 67-56-1
71-55-6
124-38-9 |
|
QUICK-EAS, TM 793
| 68815-10-1
64742-75-2
74-98-6 |
|
TRIM-GRIP ADHESIVE, TM 3081
| 64742-68-3
108-88-3
74-98-6
67-64-1
110-54-3 |
|
DUSTER/EASY DUSTER, 7000
| 75-71-8 |
|
SEALED LEAD-ACID BATTERY
| 7664-93-9
1309-60-0
7439-92-1
7446-14-2 |
|
SPC OIL SORBENTS
| |
|
INSL-TRON ACRYLIC ALIPHATIC ENAMEL, AU0320
| 108-88-3
108-65-6
763-69-9 |
|
TRA-DUCT 2902 RESIN
| 25068-38-6
26447-14-3
7440-22-4 |
|
TRA-DUCT 2902 HARDENER
| 90-72-2 |
|
THERMOCOUPLE ALLOY, 855015
| 7440-02-0
7440-47-3
7439-96-5
7440-33-7
7440-21-3
7429-90-5
1309-37-1
7440-50-8 |
|
957-INSTANT SCREEN OPENER 15 OZ
| 64742-95-6
108-94-1
68476-85-7 |
|
CORVE8710 VINYL ESTER RESIN
| 100-42-5
1321-74-0
28106-30-1 |
|
CORVE8117 VINYL ESTER LAMINATING RESIN
| 100-42-5 |
|
RUBBER & VINYL COVE BASE ADHESIVE, TA-714
| 8052-41-3
107-21-1 |
|
AQUA-FAS MASTIC WHITE, FOSTER 38-00
| 1344-09-8
108-05-4 |
|
STATE GRS
| 110-54-3
71-55-6
74-98-6
75-28-5 |
|
VINYL DRESSING
| 7440-66-6
111-90-0
50-00-0
107-13-1
100-42-5
78-51-3 |
|
A-O 6000 AARII HT EPOXY MORTAR & GROUT, PAR
| 25068-38-6
7631-86-9 |
|
A-O 6000 AARII HT EPOXY MORTAR & GROUT, PAR
| 7631-86-9
56-81-5
7631-86-9 |
|
ACTIVATED ALUMINAS
| 1344-28-1
12401-86-4
60676-86-0
1309-37-1
7732-18-5 |
|
BUG & TAR STICK, T-524
| 64742-94-5
71-41-0 |
|
PROPANE CYLINDER, PT-1600
| 74-98-6
74-84-0
75-28-5
106-97-8 |
|
AMORPHOUS SILICA PRECIPITATED SILICIC ACID,
| 63231-67-4 |
|
AMORPHOUS SILICA PRECIPITATED SILICIC ACID,
| 63231-67-4 |
|
AMORPHOUS SILICA PRECIPITATED SILICIC ACID,
| 63231-67-4 |
|
INSTANTBOND, 125
| 123-31-9
7446-09-5 |
|
COPPER CHEMETS, VACUETTES AND VACU-VIALS, R
| 4733-39-5
144-62-7
7631-90-5
67-64-1
64-19-7
1336-21-6
77-18-5 |
|
ORGANIC PHOSPHOROUS SUPPRESSOR R5442, Z442
| 7787-56-6 |
|
ORGANIC PHOSPHOROUS REAGENT B R5421, Z421
| |
|
ORGANIC PHOSPHOROUS REAGENT D R5416, Z416
| 13823-29-5 |
|
ORGANIC PHOSPHOROUS REAGENT A R5413, Z413
| |
|
ORGANIC PHOSPHOROUS REAGENT C R5415, Z415
| 7647-01-0 |
|
AQUATECH TABS
| 87-90-1 |
|
AQUATECH MAXI TABS
| 87-90-1 |
|
AQUATECH JUMBO STICKS
| 87-90-1 |
|
GUARDEX CHLORINATING CARTRIDGE
| 87-90-1 |
|
GUARDEX CHLORINATING STICKS
| 87-90-1 |
|
MONO-COAT, E179FF
| 71-55-6
67-63-0 |
|
|