MSDS NAME:EMERALD GREEN EPOXY RESIN INK, ER105
NIIN:00N026139
MSDS Number: BMCVL
=== Responsible Party ===
Company:NAZDAR CO
Address:1087 N NORTH BRANCH ST
City:CHICAGO
State:IL
ZIP:60622
Country:US
Info Phone Num:312-943-8338
Emergency Phone Num:312-943-8338
CAGE:FO883
=== Contractor Identification ===
Company:NAZDAR CO
Address:1087 N NORTH BRANCH ST
City:CHICAGO
State:IL
ZIP:60622-4234
Country:US
Phone:312-943-8338
CAGE:FO883
Company:NAZDAR COMPANY
Address:1087 N NORTH BRANCH ST
Box:City:CHICAGO
State:IL
ZIP:60622-4292
Country:US
Phone:312-943-8338;800-736-7636
CAGE:76708
============= Composition/Information on Ingredients =============
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL: ANESTHETIC. IRRIT OF RESP TRACT
OR ACUTE NERVS SYS DEPRESS CHARACTERIZED BY HDACH, DIZZ, STAG GAIT,
CONFUSION, UNCON, COMA. SKIN/EYE CONT: PRIMARY IRRITATION.
RPTD/PRLNG OVEREXP BY INHAL/SKIN A BSORPTION MAY CAUSE KIDNEY,
LIVER, & BLOOD DMG. CONTAINS LEAD & CHROMATES AND MD SHLD BE SO
ADVISED. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:INORGANIC LEAD COMPOUNDS: GROUP 2B
(IARC).
Effects of Overexposure:HLTH HAZ: RPTD/PRLNG OVEREXP BY INGEST MAY
CAUSE DELAYED DMG TO BLOOD/GI/NERVS/REPROD SYS/BIRTH DEFECTS.
ANIMAL STUDIES CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON
CNS/HEMATOPOIETIC TISS/BLOOD/K IDNEYS/LIVER, ASSOC W/ADMIN OF
ETHYLENEGLYCOL MONOBUTYL ETHER (EGBE). (EXTRACTED FROM DHHS (NIOSH)
PUB#90-118) .
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM/QUIET. NOTIFY MD. EYES: FLUSH IMMED W/COPIOUS QUANTITIES OF
RUNNING WATER FOR AT LEAST 15 MIN. TAKE TO AN MD FOR DEFINITIVE
MEDICAL TREATMENT. SKIN: REMOVE W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING. INGEST: DO NOT INDUCE VOMITING IF SWALLOWED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:SEE ING 3
Lower Limits:1%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLOSED. ISOLATE FROM
HEAT/ELEC EQUIP/SPARKS/OPEN FLAME. CLOSED CONTRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DO NOT APPLY TO (SUPP DATA)
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES, & ELECTRICAL, STATIC OR FRICTIONAL SPARKS). AVOID
BREATHING VAPORS. VENTILATE AREA. REMOVE WITH INERT, ABSORBENT AND
NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED FOR STORAGE OF NFPA CLASS II
COMBUSTIBLE LIQUIDS.
Other Precautions:DO NOT TAKE INTERNALLY. CONTRS SHLD BE GROUNDED WHEN
POURING. AVOID FREE FALL OF LIQUIDS IN EXCESS OF A FEW INCHES. DO
NOT FLAME CUT/BRAZE/WELD W/O NIOSH/MSHA APPRVD RESP OR APPROP VENT.
THIS PROD CNT NS CHEMICALS SUBJECT TO RPTG (SUPP DATA)
Respiratory Protection:IF VAPOR CONCENTRATION EXCEEDS TLV, USE
NIOSH/MSHA APPRVD RESPIRATORY W/ORGANIC CHEMICAL CARTRIDGE. CONSULT
A REPUTABLE SAFETY SUPPLY COMPANY FOR PROPER RESPIRATOR SELECTION.
Ventilation:PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL/PATTERN TO KEEP
TLV OF MOST HAZ INGRED BELOW ACCEPTABLE LIMIT, LEL (ING 5)
Protective Gloves:SOLVENT RESISTANT GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT
W/CONTAMINATED CLOTHING.
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING, SMOKING, OR
USING TOILET FACILITIES.
Supplemental Safety and Health
EXPLO HAZ: HOT SURF. WATER SPRAY MAY BE INEFTIVE. H*2O MAY BE USED TO
COOL CLOSED CONTRS TO PVNT PRESS BUILDUP/POSS AUTOIGNIT/EXPLOS
EXPOS TO EXTREME HEAT. IF H*2O IS USED, FOG NOZZ ARE PREF. HAZ DECO
MP PROD: LEAD OXIDE & CHROMIUM OXIDE MAY BE PRDCED. OTHER PREC: REQ
OF SEC 313 OF TITLE III OF SARA (40 CFR PART 372).
HCC:F4
Boiling Pt:B.P. Text:360F,182C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.438
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:51
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT AVAILABLE.
Stability Condition to Avoid:NOT AVAILABLE.
Hazardous Decomposition Products:MAY PRDCE HAZ FUMES WHEN HEATED TO
DECOMP AS IN WELDING. FUMES MAY CONTAIN CO & NO*X. IN THE EVENT OF
FIRE, (SUPP DATA)
Waste Disposal Methods:DISPOSE OF I/A/W APPLICABLE LOCAL, COUNTY, STATE
AND FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.