===================== Product Identification =====================
MSDS NAME:POTASSIUM BROMATE
NIIN:00N009595
MSDS Number: BCSVJ
=== Responsible Party ===
Company:MALLINCKRODT INC. SCIENCE PRODUCTS DIVISION
Address:PARIS BYPASS
Box:M
City:PARIS
State:KY
ZIP:40361
Country:US
Info Phone Num:314-982-5000
Emergency Phone Num:314-982-5000
CAGE:62910
=== Contractor Identification ===
Company:MALLINCKRODT SPECIALTY CHEMICALS CO
Address:222 RED SCHOOL LANE
Box:City:PHILLIPSBURG
State:NJ
ZIP:08865
Country:US
Phone:908-859-2151
CAGE:62910
============= Composition/Information on Ingredients =============
Name:POTASSIUM BROMATE
CAS:7758-01-2
RTECS #:EF8725000
Fraction by Wt:
Other REC Limits:
OSHA PEL:
ACGIH TLV:
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL:IRRIT TO UP RESP TRACT,COUGH &
SHORT OF BREATH.INGEST:NAUSEA,VOMIT,DIARRHEA.ABD PAIN.REDU URINE
OUTPUT.LOW
BP.METHEMOGLOBINEMIA,CONVULSION.LIVER&KIDNEDAMAGE,COMA,CYANOSIS MAY
OCCUR AS LATER SYMP TOM.DEATH MAY OCCUR FROM RENAL FAILURE W/IN 1
TO 2 WKS.EST.LETHAL DOSE 1GM.EYE:IRRIT/CORNEAL
DAMAGE.CHRONIC:LIVER/KIDNEY
Effects of Overexposure:SEE HEALTH HAZARDS(ACUTE & CHRONIC)
Medical Cond Aggravated by Exposure:PERSONS W/ PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS OR IMPARED LIVER,KIDNEY OR RESPIRATORY
FUNCTION MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF SUBSTANCE.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR.GET MED ATT FOR ANY BREATH
DIFFICULTY.INGEST:INDUCE VOMITING IMMED.GIVE TWO GLASSES OF H*2O &
STICKING FINGER DOWN THROAT.NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSO N.CALL PHYS.SKIN:WASH EXPOSED AREA W/SOAP &
H*2O.GET MED ADVICE IF IRRIT DEVELOPS.EYE:WASH EYE W/ PLENTY OF
H*2O FOR AT LEAST 15 MIN.LIFT LOWER & UPPER EYELIDS
OCCASIONALLY.GET MED ATT IMMED.
===================== Fire Fighting Measures =====================
Flash Point:
Lower Limits:
Upper Limits:
Extinguishing Media:USE ANY MEANS SUITABLE FOR EXTINGUISHING
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING & NIOSH-APPROVED
SCBA W/FULL FACEPIECE OPERATED IN PRESS DEMAND OR OTHER POS.PRESS
MODE.H*2O SPRAY KEEP FIRE EXPOS CONTR COOL.
Unusual Fire/Explosion Hazard:NOT COMBUSTIBLE IS A STRONG OXIDIZER.HEAT
OF REACTION W/ REDUC AGENT/COMBUST MAY CAUSE IGNITION.CONTACT W/
OXIDIZABLE SUBS.CAUSE EXTREME VIOLENT COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA.CLEAN UP PERSONNEL MAY REQUIRE RESP
PROTECTION FROM DUST. SPILLS: SWEEP UP & CONTAINERIZE FOR
RECLAMATION OR DISPOSAL. VACUUMING OR WET SWEEPING MAY BE USED TO
AVOID DUST DISPOSAL.
Neutralizing Agent:N/K
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP IN A TIGHTLY CLOSED CONTR STORE
IN A COOL,DRY VENT AREA.PROT AGAINST PHYSICAL DAMAGE.SEPARATE FROM
COMBUSTIBLE,ORGANIC OR OTHER OXIDIZABLE MAT.
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED.COND OF USE WHERE EXPOS TO DUST
IS APPARENT DUST/MIST RESP MAY BE WORN FOR EMERGENCIES A SCBA MAY
BE USED.
Ventilation:LOCAL EXHAUST WHICH CAPTURE THE CONTAM AT ITS SOURCE IS
RECOMMENDED.PREVENT DISPERSION INTO THE WORK PLACE.
Protective Gloves:WEAR PROTECTIVE GLOVES.
Eye Protection:CHEMICAL SAFETY GOGGLES.
Other Protective Equipment:CLEAN BODY-COVERING CLOTHING
Work Hygienic Practices:OBSERVE GOOD WORK HYGIENIC PRACTICES.
Supplemental Safety and Health
SOL IN H*2O:20C.MAT TO AVOID:PHOSPHONIUM IODINE,PHOSPHORUS,LEAD
ACETATE,SELENIUM & SULFUR.HLTH HAZ(ACUTE/CHRONIC)DAMAGE.
================== Physical/Chemical Properties ==================
HCC:D1
Boiling Pt:B.P. Text:698F, 370C
Melt/Freeze Pt:M.P/F.P Text:662F 350C
Decomp Temp:Decomp Text:
Vapor Pres:NO INFO
Vapor Density:NO INFO
Spec Gravity:3.27
pH:
Evaporation Rate & Reference:NO INFO FOUND
Solubility in Water:8G1100G H*2O AT68F
Appearance and Odor:WHITE POWDER OR GRANULES ODORLESS
Percent Volatiles by Volume:
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS,REDUCING AGENTS,ORGANIC MAT,AL,ARSENIC,CALCIUM
HYDRIDE,CARBON,COPPER,POWDER METALS,METAL SULFIDES (SEE SUP DATA)
Stability Condition to Avoid:
Hazardous Decomposition Products:EMITS OXYGEN & TOXIC FUMES OF BROMINE
WHEN HEATED TO DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECLAMATION MAY BE
DELIVERED TO AN APPROVED WASTE DISPOSAL FACILITY.ENSURE COMPLIANCE
W/ LOCAL,STATE & FED REGS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|