===================== Product Identification =====================
MSDS NAME:VP-31A PENETRANT (POST 10/86)
NIIN:00-063-2838
MSDS Number: BCWWG
=== Responsible Party ===
Company:MET-L-CHEK COMPANY
Address:1639 EUCLID STREET
City:SANTA MONICA
State:CA
ZIP:90404-3770
Country:US
Info Phone Num:213-450-1111
Emergency Phone Num:213-450-1111
CAGE:98733
=== Contractor Identification ===
Company:MET-L-CHEK COMPANY
Address:1639 EUCLID ST
Box:00000
City:SANTA MONICA
State:CA
ZIP:90404
Country:US
Phone:310-450-1111/FAX 310452-4046
CAGE:98733
============= Composition/Information on Ingredients =============
Name:DISTILLATE (PETROLEUM),HYDROTREATED MIDDLE; ON MSDS MFR
SIMPLY NOTED AS "PETROLEUM HYDROCARBON" FOR ABOVE CAS NO.
CAS:64742-46-7
RTECS #:JN9379645
OSHA PEL:5MG/CUM
ACGIH TLV:5MG/CUM
Name:ISOBUTANE/PROPANE MIXTURE(AS PROPELLANT)
OSHA PEL:1000PPM (PROPANE)
ACGIH TLV:ASPHYXIANTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE MILD IRRITATION TO SKIN &
RESP TRACT SYSTEM.
Effects of Overexposure:INHALATION:MAY CAUSE IRRITATION TO NOSE AND
RESPIRATORY SYSTEM.EARLY TO MODERATE CNS DEPRESSION MAY BE
EVIDENCED BY DIZZ,GIDDINESS,HEADACHE,NAUSEA;EYES:VAPOR MAY CAUSE
IRRITATION;SKIN:LIQUID CONTACT M AY IRRITATE MILDLY;INGESTION:NOT
LISTED.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN,EYE,AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR.GIVE CPR IF
NEEDED;EYES/SKIN:FLUSH WITH RUNNING WATER FOR AT LEAST 15
MINUTES.GET MEDICAL HELP IF IRRITATION OCCURS OR
PERSISTS;INGESTION:IF VICTIM IS CONSCIOUS,INDUCE V OMITING.NOTHING
MY MOUTH IF UNCONSCIOUS,GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:N/R (AEROSOLS)
Extinguishing Media:WATER FOG,"ALCOHOL" FOAM,DRY CHEMICAL OR CO*2.DO
NOT USE DIRECT STREAM OF WATER.
Fire Fighting Procedures:CONTAINERS EXPOSED TO INTENSE HEAT FROM FIRES
SHOULD BE COOLED WITH WATER SPRAY TO PREVENT VAPOR PRESSURE
BUILD-UP.DON'T STORE ABOVE 120F.
Unusual Fire/Explosion Hazard:AEROSOL CANS MAY RUPTURE/EXPLODE DUE TO
VAPOR PRESSURE BUILDUP IF EXPOSED TO INTENSE HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES.WEAR PROTECTIVE
CLOTHING & APPROPRIATE RESPIRATOR.SOAK UP RESIDUE WITH ABSORBENT
CLAY,SAND,EARTH,OR OTHER MATERIAL.PLACE RAGS & ABSORBED WASTE AND
DAMAGED BY EMPTY CANS IN D OT COVERED NON-LEAKING CONTAINERS.
====================== Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HOT PLACES & IGNITION
SOURCES.DO NOT STORE OR HANDLE IN ALUMINUM EQUIPMENT AT TEMP ABOVE
120F.
Other Precautions:DURING TRANSFER OF LIQUID IN BULK,GROUND THE HANDLING
EQUIPMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR IF EXPOSURE
EXCEEDS TLV LIMITS.
Ventilation:PER MFR,LOCAL EXHAUST OR MECHANICAL(GEN) TO MAINTAIN TLV
Protective Gloves:CHEMICAL RESISTANT
Eye Protection:GOGGLES
Other Protective Equipment:EYE WASH FOUNTAINS AND SAFETY SHOWERS
Work Hygienic Practices:WASH WITH SOAP & WATER BEFORE
EATING,DRINKING,SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
VP-31A IS REPLACEMENT OF VP-31;VP-31A IS A QUALIFIED ITEM OF
QPL-25135-15 OF MIL-I-25135,REV D,WHILE THIS NON-STANDARD NSN IS
FOR GROUP II OF MIL-I-25135,REV C.THIS NSN MAY BE CANCELLED ON
LATER DATE.
================== Physical/Chemical Properties ==================
HCC:V3
Spec Gravity:0.86(BULK)
Solubility in Water:APPRECIATE
Appearance and Odor:LIQUID BEFORE FILLING IN AEROSOL CANS IS DEEP
REDDISH-PURPLE LIQ HYDROCARBN ODO
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:HEAT,SPARKS,IGNITION SOURCES
Hazardous Decomposition Products:CARBON MONOXIDE & UNIDENTIFIED ORGANIC
COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DIPOSE OF AS EPA HAZARDOUS WASTE #D001,IGNITABLE
WASTE.EMPTY AEROSOL CAN BEFORE DISPOSING OF THEM.PRESSURIZED
AEROSOL CANS ARE NOT ACCEPTABLE WASTE.COMPLY ALL FEDERAL,STATE &
LOCAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|