===================== Product Identification =====================
MSDS NAME:SKC-S SPOTCHECK CLEANER/REMOVER(SEE SUPPL)
NIIN:00-062-8315
MSDS Number: BCWVM
=== Responsible Party ===
Company:MAGNAFLUX CORPORATION
Address:7300 WEST LAWRENCE AVENUE
City:CHICAGO
State:IL
ZIP:60656-3504
Country:US
Info Phone Num:312-867-8000
Emergency Phone Num:312-867-8000
Preparer's Name:BRUCE C. GRAHAM
CAGE:37676
=== Contractor Identification ===
Company:ILLINOIS TOOL WORKS INC MAGNAFLUX DIV
Address:3624 WEST LAKE AVENUE
Box:City:GLENVIEW
State:IL
ZIP:60025
Country:US
Phone:847-657-5300/
CAGE:37676
============= Composition/Information on Ingredients =============
Name:SOLVENT NAPHTHA(PETROLEUM),LIGHT ALIPHATIC
CAS:64742-89-8
Fraction by Wt: 100.0%
Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: <5.0%
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:SKIN & EYE IRRITATION ON
CONTACT.
Effects of Overexposure:INHALATION:CAUSES
DIZZINESS,NAUSEA,DROWSINESS,FROM INHALATION OF SPRAY MIST;
SKIN:CAUSES IRRITATION,DISSOLVES SKIN OILS.POSSIBLE DERMATITIS ON
FREQUENT OR PROLONGED EXPOSURE; EYES:MODERATE IRRITATION BY
CONTACT OF LIQUID OR SPRAY; INGESTION:LOW TOXICITY,BUT HAZARDOUS IF
ASPIRATED INTO LUNGS BY INGESTION OR VOMITING.
Medical Cond Aggravated by Exposure:NOT STATED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR.IF NOT BREATHING,GIVE CPR.IF
BREATHING IS DIFFICULT,GIVE OXYGEN; SKIN:WASH OFF IN FLOWING WATER
OR SHOWER.RMV CONTAMINATED CLOTHING AND WASH BEFORE REUSE.USE
SOOTHING LO TION; EYES:FLUSH EYES WITH A STEADY,GENTLY FLOW OF
WATER.GET MEDICAL ASST; INGESTION:DO NOT INDUCE VOMITING.IF VOMIT
IS INHALED,IT MAY CAUSE ASPHYXIATION.GET MED ATTN IMMEDIATELY; IN
EMERGENCY CALL MD
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:54F/12.2C
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY;DO NOT
SPRAY WATER ON BURNING SKC-S.
Unusual Fire/Explosion Hazard:CONTAINERS MAY BURST IN HEAT OF
FIRE;AEROSOL CANS MAY BURST IF HEATED ABOVE 130F AND SPRAY
FLAMMABLE LIQUID AROUND AREA.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.SM QTY:WIPE UP OR MOP
UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LG
QTY:WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCIAL ABSORBEN T.TRANSFER WASTE MATL IN SALVAGE
TANKS.
====================== Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA.AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS.KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT SMOKE WHILE USING.DO NOT
HEAT ABOVE 130F(54C).AVOID FREQUENT OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A RESPIRATOR WITH ABSORBENT CARTRIDGE IN
POORLY VENTILATED AREAS.IN CONFINED,UNVENTILATED SPACES,WEAR FULL
MASK WITH AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW TLV LIMITS.
Protective Gloves:NITRILE RUBBER GLOVES
Eye Protection:CHEMICAL SPLASH/FULL GOGGLES
Work Hygienic Practices:WASH HANDS WITH SOAP AND WATER AFTER HANDLING
Supplemental Safety and Health
NSN WAS FOR GROUP I OF MIL-I-25135C;I/A/W QPL-25135-13,SKC-NF WAS GROUP
1A ITEM.DURING AUG 84,P/N SKC-S DATA WAS ENTERED UNDER THIS NSN
WHICH WAS GROUP I ITEM.THE NSN WAS ACTUALLY ASSIGNED FOR SKC-NF;
HOWEVER,EFFECTIVE 88274,NSN HAS BEEN CANCELLED AS NON-STANDARD NSN
& REPLACED BY 6850-00-145-0255.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:245F/118.3C
Vapor Pres:25MM@100F
Vapor Density:>1.0
Spec Gravity:0.75
Evaporation Rate & Reference:0.1 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR,COLORLESS LIQ;FOLLOWING PHYSICAL DATA OF LIQ
BEFORE FILLING AEROSOL CN
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Stability Condition to Avoid:HEAT,HIGH TEMPERATURE,IGNITION SOURCES.
Hazardous Decomposition Products:OXIDES OF CARBON ON COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF AS EPA HAZARDOUS WASTE
D001 (IGNITABLE WASTE),IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL,STATE,LOCAL REGULATIONS;EMPTY AEROSOL CANS BEFORE DISPOSING
OF THEM.PRESSURIZED AEROSOL CANS ARE NOT AN ACCEPTABLE WASTE.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|