===================== Product Identification =====================
MSDS NAME:IMRON 5000 POLYURETHANE ENAMELS, 506H
NIIN:00N073979
MSDS Number: CCRHJ
=== Responsible Party ===
Company:EI DUPONT DE NEMOURS & CO
Address:1007 MARKET ST
City:WILMINGTON
State:DE
ZIP:19898
Country:US
Info Phone Num:800-441-7515
Emergency Phone Num:800-441-3637;800-424-9300(CHEMTREC)
CAGE:EO716
=== Contractor Identification ===
Company:E.I. DUPONT DE NEMOURS & CO
Address:1007 MARKET STREET
Box:City:WILMINGTON
State:DE
ZIP:19898
Country:US
Phone:800-441-7515;800-441-9442
CAGE:18873
Company:EI DUPONT DE NEMOURS CO/AUTOMOTIVE PRODS
Address:1007 MARKET ST
City:WILMINGTON
State:DE
ZIP:19898
Country:US
Phone:(800) 441-7515
CAGE:EO716
============= Composition/Information on Ingredients =============
Name:ACRYLIC POLYMER A
CAS:42767-92-0
OSHA PEL:N/K
ACGIH TLV:N/K
Name:ACRYLIC POLYMER B
CAS:42767-92-0
OSHA PEL:N/K
ACGIH TLV:N/K
Name:ACRYLIC POLYMER C
OSHA PEL:N/K
ACGIH TLV:N/K
Name:ACETIC ACID, BUTYL ESTER; (BUTYL ACETATE) (CERCLA). VP:8
CAS:123-86-4
RTECS #:AF7350000
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/200 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:2-HEPTANONE; (METHYL AMYL KETONE). VP:2.2
CAS:110-43-0
RTECS #:MJ5075000
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
Name:C.I. PIGMENT GREEN 7; (PHTHALOCYANINE GREEN PIGMENT)
CAS:1328-53-8
OSHA PEL:N/K
ACGIH TLV:N/K
Name:TOLUENE (SARA 313) (CERCLA). VP:36.7
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 1%
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:SUPDAT:@ DOSES THAT ARE TOXIC TO MOTHER. METHYL AMYL
KETONE:INGEST:STUDIES ON LAB ANIMALS SHOWED THAT VERY HIGH (ING 10)
RTECS #:9999999ZZ
Name:ING 9:ORAL DOSES CAUSED INCRD LIVER & KIDNEY WEIGHTS.
TOLUENE:RECURRENT OVEREXP MAY RSLT IN LIVER & KIDNEY (ING 11)
RTECS #:9999999ZZ
Name:ING 10:INJURY. HIGH AIRBORNE LEVELS HAVE PRDCED IRREGULAR
HEART BEATS IN ANIMALS & OCCAS PALPITATIONS IN HUMANS.(ING 12)
RTECS #:9999999ZZ
Name:ING 11:RATS EXPOSED TO VERY HIGH AIRBORNE LEVELS HAVE
EXHIBITED HIGH FREQUENCY HEARING DEFICITS. SIGNIFICANCE (ING 13)
RTECS #:9999999ZZ
Name:ING 12:OF THIS TO MAN IS UNKNOWN. WARNING:THIS CHEM IS
KNOWN TO ST OF CA TO CAUSE BIRTH DEFECTS/OTHER REPROD HARM.
RTECS #:9999999ZZ
Name:SPILL PROC:ALLOW TO SIT 10 MINS, MIN. TYPICAL DECONTAM
SOLNS ARE:20% SURFACTANT (TERGITOL TMN 10), 80% WATER, (ING 15)
RTECS #:9999999ZZ
Name:ING 14:0-10% AMMONIA, 2-5% DETERGENT, BALANCE WATER. PROC
CAN GENERATE PRESS. DO NOT SEAL CNTNR. AFTER 48 HRS, (ING 16)
RTECS #:9999999ZZ
Name:ING 15:CNTNR MAY BE SEALED & DISPOSED OF.
RTECS #:9999999ZZ
Name:RESP PROT:PROBS OR PRIOR RXN TO ISOCYANATES SHOULD NOT USE
OR BE EXPOSED TO PROD. DO NOT PERMIT ANYONE W/OUT (ING 18)
RTECS #:9999999ZZ
Name:ING 17:PROT IN PAINTING AREA. FOLLOW RESP MFR'S DIRECTIONS
FOR RESP USE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TOLUENE APPEARS ON NAVY LIST OF OCCUP
CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS
CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS INFO.
ACUTE:INGEST:GI DISTRESS. INHAL :MAY CAUSE NOSE & THROAT IRRIT.
RPTD & PRLNGD OVEREXP TO SOLVS MAY LEAD TO PERM BRAIN & NERVOUS SYS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:DMG. EYE WATERING, HDCH, NAUS, DIZZ &
UNCOORDINATION ARE SIGNS SOLV LEVELS ARE TOO HIGH. EXPOS TO
ISOCYANATES MAY CAUSE RESP SENSIT; EFT MAY BE PERM & MAY BE DELAYED
SEVERAL HRS AFTER EXPOS. RPTD OVEREXP TO ISOCYANATES MAY CAUSE
DECR IN LUNG FUNC WHICH MAY BE PERM; PERS W/BRTHG PROBS/PRIOR RXN
TO THEM (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL PHYS IMMED & HAVE NAMES OF INGREDIENTS AVAILABLE.
INHAL:REMOVE TO FRESH AIR. IF BRTHG DFCLTY PERSISTS/OCCURS LATER,
CONSULT PHYS. EYE:IMMED FLUSH W/PLENTY OF WATER FOR @ LEAST 15
MINS; CAL L PHYS. SKIN:WASH W/SOAP & WATER. IF IRRIT OCCURS, CONT
PHYS.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:100F,38C
Lower Limits:0.9%
Upper Limits:23%
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROTECTIVE EQUIPMENT
. WATER FROM FOG NOZZ MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE FLASH POINT, EMITS
FLAMM VAPS WHICH, WHEN MIXED W/AIR, CAN BURN OR BE EXPLO. FINE
MISTS/SPRAYS MAY BE FLAMM @ TEMPS BELOW FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT BREATHE VAPS OR GET IN EYES/ON SKIN.
WEAR POS PRESS SUPPLIED AIR VAP/PARTICULATE RESP (NIOSH APPRVD TC
19C), EYE PROT, GLOVES & PROT MATL. REMOVE SOURCES OF IGNIT. ABSORB
W/INERT MATL. VENT ARE A. POUR LIQ DECONTAM SOLN OVER SPILL & (ING
14)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPARKS & FLAME. CLOSE CNTNR AFTER EACH USE. GROUND
CNTNRS WHEN POURING. DO NOT STORE ABOVE 120F.
Other Precautions:DO NOT SAND, FLAME CUT, BRAZE OR WELD DRY COATING
WITHOUT NIOSH APPROVED RESPIRATOR OR APPROPRIATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPS/MISTS. WEAR NIOSH APPRVD POS
PRESS SUPPLIED AIR RESP (TC-19C) WHILE MIXING ACTIVATOR W/ANY
PAINT/CLEAR ENAMEL, DURING APPLIC & UNTIL ALL VAPS & SPRAY MISTS
ARE EXHAUSTED. PERS W/HI STORY OF LUNG/BRTHG (ING 17)
Ventilation:PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES
Other Protective Equipment:COVERALLS. ANSI APPRVD EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR SMOKING.
Supplemental Safety and Health
EFTS OF OVEREXP:MUST NOT BE EXPOS TO VAPS/SPRAY MIST OF PROD.
SKIN/EYE:MAY CAUSE IRRIT/BURNING OF EYES. RPTD/PRLNGD LIQ CONT MAY
CAUSE SKIN IRRIT W/DISCOMFORT & DERM. BUTYL ACETATE:MAY CAUSE
ABNORM LI VER FUNC. TESTS FOR EMBRYOTOXIC ACITVITY IN ANIMALS HAS
BEEN INCONCLUSIVE. HAS BEEN TOX TO FETUS IN LAB ANIMALS (ING 9)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>135F,>57C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.09
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:7-100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO*2, SMOKE, OXIDES OF HEAVY
METALS IN INGREDIENT SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW MATL TO CONTAMINATE GROUND WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL I/A/W FEDERAL, STATE, & LOCAL
REQUIREMENTS. DO NOT INCINERATE IN CLOSED CONTAINERS.
======================= Other Information =======================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|