===================== Product Identification =====================
MSDS NAME:CREST 1110 A EPOXY RESIN
NIIN:01-387-4774
Kit Part:Y
MSDS Number: CDRWN
=== Responsible Party ===
Company:CREST PRODUCTS CORP
Address:10550 LAWSON RIVER AVE
City:FOUNTAIN VALLEY
State:CA
ZIP:92708
Country:US
Info Phone Num:714-965-9292
Emergency Phone Num:714-965-9292
CAGE:34469
=== Contractor Identification ===
Company:CREST PRODUCTS CORP
Address:2000 S SUSAN ST
Box:City:SANTA ANA
State:CA
ZIP:92704-4415
Country:US
Phone:714-965-9292
CAGE:34469
============= Composition/Information on Ingredients =============
Name:BISPHENOL A EPOXY RESIN *97-1*
CAS:25036-25-3
Fraction by Wt: 30%
Name:EPICHLOROHYDRIN-GLYCERINE COPOLYMER
CAS:25038-04-4
Fraction by Wt: 10%
Name:EPOXY RESIN
Fraction by Wt: 25%
Name:VOLATILE ORGANIC CONTENT: 0.00 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION & BURNS.
CONJUNCTIVITIS/CORNEAL INJURY. SKIN: MAY BE ABSORBED IN HARMFUL
AMOUNTS. MAY CAUSE IRRITATION, SENSITIZATION & DERMATITIS.
INHALATION: RESPIRATORY TRACT IRRITANT. INGE STION: HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS, IRRITATION
======================= First Aid Measures =======================
Eyes: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR 15 MINS.
SKIN: FLUSH W/LARGE AMOUNTS OF WATER. INHALATION: MOVE TO FRESH
AIR. RESTORE/SUPPORT CONTINUED BREATHING, GIVE OXYGEN. INGESTION:
DON'T IN DUCE VOMITING. GIVE 1-2 GLASSES OF WATER/MILK. NEVER GIVE
ANYTHING BY MOUTH IF UNCONSCIOUS. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING W/SCBA. IF WATER IS
USED, FOG NOZZLES ARE PREFERRED. USE WATER SPRAY TO KEEP FIRE
EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. CLOSED
CONTAINERS MAY RUPTURE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROPRIATE RESPIRATORY PROTECTION FOR
LARGE RELEASES/IN CONFINED AREAS. KEEP NON-ESSENTIAL PERSONNEL
AWAY. SCOOP MATERIAL INTO AN APPROPRIATE CONTAINER FOR DISPOSAL. IF
NECESSARY, USE INERT ABSOR BENT MATERIAL TO AID IN CONTAINING THE
RELEASE.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP CLOSURE TIGHT & CONTAINER UPRIGHT
TO PREVENT LEAKAGE. STORE ONLY IN WELL-VENTILATED AREAS. KEEP
CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:DON'T HANDLE UNTIL ALL SAFETY PRECAUTIONS HAVE BEEN
READ & UNDERSTOOD. EMPTY CONTAINERS SHOULD NOT BE RE-USED. USE
W/ADEQUATE VENTILATION. AVOID BREATHING VAPORS. AVOID SKIN/EYE
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH/MSHA APPROVED AIR-PURIFYING ORGANIC
VAPOR RESPIRATOR IF OCCUPATIONAL LIMITS ARE EXCEEDED. WHERE
EXPOSURE LIMITS MAY BE EXCEEDED, USE AN APPROVED AIR-SUPPLIED
RESPIRATOR. (29CFR 1910.134)
Ventilation:SUFFICIENT IN PATTERN & VOLUME IN ORDER TO MAINTAIN AIR
CONTAMINANT LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
Protective Gloves:NEOPRENE/NITRILE/RUBBER
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS
Other Protective Equipment:CHEMICAL GOGGLES, DISPOSABLE/IMPERVIOUS
CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, SMOKING/USING TOILET FACILITY.
Supplemental Safety and Health
FOOD/BEVERAGES SHOULDN'T BE CONSUMED ANYWHERE THIS PRODUCT IS
HANDLED/STORED. WASH THOROUGHLY AFTER HANDLING.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:440F
Vapor Density:>1
Spec Gravity:0.65
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:VISCOUS WHITE PASTE W/CHARACTERISTIC ODOR
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AMINES, ACIDS, WATER, HYDROXYL, ACTIVE HYDROGEN COMPOUNDS
Stability Condition to Avoid:EXTREME HEAT/HIGH TEMPERATURES
Hazardous Decomposition Products:CO, CO2, ALDEHYDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|