===================== Product Identification =====================
MSDS NAME:OXYGEN
NIIN:01-431-0681
MSDS Number: CGLYS
=== Responsible Party ===
Company:BOC GROUP INC THE
Address:575 MOUNTAIN AVE
City:MURRAY HILL
State:NJ
ZIP:07974
Country:US
Info Phone Num:908-464-8100/FOR MSDS:800-734-5463
Emergency Phone Num:908-464-8100/800-424-9300(CHEMTREC)
CAGE:80382
=== Contractor Identification ===
Company:BOC GASES, A DIVISION OF THE BOC GROUP, INC
Address:575 MOUNTAIN AVENUE
Box:City:MURRAY HILL
State:NJ
ZIP:07974
Country:US
Phone:908-464-8100
CAGE:80382
============= Composition/Information on Ingredients =============
Name:OXYGEN (99.6 TO 100)
CAS:7782-44-7
RTECS #:RS2060000
Fraction by Wt: SEE ING
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT RELEVANT
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:LUNGS, CNS. ACUTE-
EYE/SKIN/ORAL:UNLIKELY (GAS). INHALE:HIGH CONCENTRATIONS (>75%) MAY
CAUSE HYPEROXIA (CNS EFFECTS) WITH SYMPTOMS OF DIZZINESS, NAUSEA,
CRAMPS, HYPOTHERMIA, RESPIRATION DIFFICULTIES,
UNCONSCIOUSNESS/FAINTING,HEARING PROBLEMS, CONVULSIONS CAPABLE OF
LEADING TO DEATH. CHRONIC- NONE.
Explanation of Carcinogenicity:OXYGEN IS NOT LISTED AS A CARCINOGEN BY
THE IARC, NTP OR OSHA.
Effects of Overexposure:COUGH, SORE THROAT, CHEST PAIN, DIZZINESS,
TINGLING SENSATION, MUSCULAR TWITCHING, UNCONSCIOUSNESS, HEARING
PROBLEMS, CONVULSIONS, DEATH
======================= First Aid Measures =======================
First Aid:PROMPT MEDICAL ATTENTION IS MANDATORY IN ALL CASES OF
OVEREXPOSURE TO OXYGEN. RESCUE PERSONNEL SHOULD BE AWARE OF EXTREME
FIRE HAZARD ASSOCIATED WITH OXYGEN-RICH ATMOSPHERE AND WEAR
NIOSH-APPROVED SEL F-CONTAINED BREATHING APPARATUS. INHALED:REMOVE
TO FRESH AIR. PROVIDE CPR IF NEEDED. TREATMENT SHOULD BE
SYMPTOMATIC AND SUPPORTIVE. PATIENT MAY EXPERIENCING HYPEROXIA.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM/DRY CHEMICAL FOR
SURROUNDING FIRE. WATER IS PREFERRED EXTINGUISHER FOR COMBUSTIBLES.
Fire Fighting Procedures:WEAR NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS IF NEEDED. MOVE CONTAINERS AWAY IF POSSIBLE. STOP FLOW OF
OXYGEN WHICH IS SUPPORTING THE FIRE.
Unusual Fire/Explosion Hazard:ACCELERATES COMBUSTION. CONTACT WITH
EASILY OXIDIZABLE ORGANIC/COMBUSTIBLE MATERIALS MAY RESULT IN
IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK IF WITHOUT RISK. VENTILATE AREA OR
MOVE LEAKING CONTAINER TO WELL-VENTILATED AREA. REMOVE ALL
FLAMMABLE MATERIALS. OXYGEN MUST NEVER BE PERMITTED TO STRIKE AN
OILY SURFACE, GREASY CLOTHES, O R OTHER COMBUSTIBLE MATERIAL.
Neutralizing Agent:NOT RELEVANT
====================== Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED AREA
AWAY FROM INCOMPATIBLES. STORE CYLINDERS UPRIGHT & SECURED, BELOW
125F/52C. PROTECT CYLINDERS FROM PHYSICAL DAMAGE
Other Precautions:OXYGEN VIGOROUSLY ACCELERATES COMBUSTION. AVOID
CONTACT WITH OILS, GREASES AND OTHER FLAMMABLE MATERIALS.
NOTE:REVERSE FLOW INTO CYLINDER MAY CAUSE RUPTURE. NEVER WORK ON A
PRESSURIZED SYSTEM. NEVER L UBRICATE USING COMBUSTIBLES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. HOWEVER,
NIOSH-APPROVED AIR-SUPPLIED RESPIRATORS ARE REQUIRED WHILE WORKING
IN CONFINED SPACES WITH THIS PRODUCT. THE RESPIRATORY PROTECTION
USE MUST CONFORM WITH OSHA RULES AS SPECIFIED IN 29 CFR 1910.134.
Ventilation:LOCAL EXHAUST TO PREVENT ACCUMULATION OF OXYGEN
CONCENTRATION (>25%). MECHANICAL (GENERAL) IS ACCETABLE.
Protective Gloves:ANY MATERIAL FOR CYLINDER HANDLING
Eye Protection:SAFETY GOGGLES/GLASSES RECOMMENDED
Other Protective Equipment:SAFETY SHOES FOR CYLINDER HANDLING, SAFETY
SHOWER, EYE WASH FOUNTAIN
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING AND AFTER
HANDLING.
Supplemental Safety and Health
OXYGEN SHOULD NOT BE USED AS A SUBSTITUTE FOR COMPRESSED AIR IN
PNEUMATIC EQUIPMENT CONTAINING FLAMMABLE LUBRICANTS. EQUIPMENT TO
CONTAIN OXYGEN MUST BE "CLEANED FOR OXYGEN SERVICE". COMPRESSED GAS
CY LINDERS SHOULD NOT BE REFILLED EXCEPT BY QUALIFIED PRODUCERS OF
COMPRESSED GASES AND WRITTEN CONSENT OF THE OWNER.
================== Physical/Chemical Properties ==================
HCC:G4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:-297F,-183C
Melt/Freeze Pt:M.P/F.P Text:-362F,-219C
Vapor Density:1.11
Spec Gravity:GAS
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS, ODORLESS GAS AT NORMAL TEMPERATURE AND
PRESSURE
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALL FLAMMABLE MATERIALS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT ATTEMPT TO DISPOSE OF RESIDUAL OR
UNUSED QUANTITIES. RETURN IN THE SHIPPING CONTAINER PROPERLY
LABELED, WITH ANY VALVE OR CAP S SECURED TO YOUR SUPPLIER FOR
PROPER DISPOSAL.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|