=====================  Product Identification  =====================

MSDS NAME:CLEAN FLUSH, CPS230341
NIIN:00N086579
MSDS Number: CHFNZ
=== Responsible Party ===
Company:CHEVRON ENVIRONMENTAL HEALTH CENTER
Box:4054
City:RICHMOND
State:CA
ZIP:94804
Country:US
Info Phone Num:800-582-3835
Emergency Phone Num:800-231-0623;800-424-9300(CHEMTREC]
CAGE:0AHD1
=== Contractor Identification ===
Company:CHEVRON ENVIRONMENTAL HEALTH CENTER INC
Address:15299 SAN PABLO AVE
Box:4054
City:RICHMOND
State:CA
ZIP:94804
Country:US
Phone:800-582-3835
CAGE:0AHD1

=============  Composition/Information on Ingredients  =============

Name:MINERAL OIL, PETROLEUM DISTILLATE, HYDROTREATED (SEVERE)
    HEAVY PARAFFINIC; (HYDROTREATED DIST., HEAVY PARA)
CAS:64742-54-7
RTECS #:PY8035501
Fraction by Wt: >99%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)

Name:ADDITIVES
Fraction by Wt: <1%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Name:SUP DAT: INGEST: ORAL LD50 IN FEMALE RATS IS >6 G/KG.
    INHAL: BASED ON ANIMAL DATA FOR SIMILAR MATLS, INHAL LD50 (ING 4)
RTECS #:9999999ZZ

Name:ING 3: (4-HOUR) IS EXPECTED TO BE GREATER THAN 5 MG/L.
RTECS #:9999999ZZ

Name:FIRST AID PROC: NOTE TO MD: IN AN ACCIDENT INVOLVING HIGH
    PRESS EQUIP, THIS PROD MAY BE INJECTED UNDER SKIN. (ING 6)
RTECS #:9999999ZZ

Name:ING 5: SUCH ACCIDENT MAY RSLT IN SML, SOMETIME BLOODLESS,
    PUNCTURE WOUND. HOWEVER, BECAUSE OF ITS DRIVING FORCE, (ING 7)
RTECS #:9999999ZZ

Name:ING 6: MATL INJECTED INTO FINGERTIP CAN BE DEPOSITED INTO
    PALM OF HAND. W/IN 24 HRS, THERE IS USUALLY A GREAT (ING 8)
RTECS #:9999999ZZ

Name:ING 7: DEAL OF SWELL, DISCOLORATION, & INTENSE THROBBING
    PAIN. IMMED TREATMENT AT SURGICAL EMER CENTER IS RECOMMENDED.
RTECS #:9999999ZZ

Name:SPILL PROC: FOLLOW PRESCRIBED PROC FOR REPORTING &
    RESPONDING TO LARGER RELEASES. RPT SPILLS TO LOC AUTH &/OR (ING 10)
RTECS #:9999999ZZ

Name:ING 9: U.S. COAST GUARD'S NATIONAL RESPONSE CENTER AT (800)
    424-8802 AS APPROPRIATE OR REQUIRED.
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: NOT EXPECTED TO IRRITATE.
    SKIN: NOT EXPECTED TO IRRITATE. CONT NOT EXPECTED TO CAUSE ALLERGIC
    RESPONSE. IF ABSORBED THRU SKIN, IT IS CONSIDERED PRACTICALLY
    NON-TOX TO INTERNAL ORGANS. HIG H-PRESS EQUIP INFO: ACCIDENTAL
    HIGH-VELOCITY INJECTION UNDER SKIN OF MATLS OF THIS TYPE MAY RSLT
    IN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: SERIOUS INJURY. SEEK MED ATTN AT ONCE
    SHOULD ACCIDENT LIKE THIS OCCUR. INITIAL WOUND AT INJECTION SITE
    MAY NOT APPEAR TO BE SERIOUS AT FIRST; BUT, IF LEFT UNTREATED,
    COULD RSLT IN DISFIGUREM ENT/AMPUTATION OF AFFECTED PART. INGEST:
    CONSIDERED PRACTICALLY NON-TOX TO INTERNAL ORGANS. (SUP DAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

=======================  First Aid Measures  =======================

Eyes: FLUSH W/FRESH WATER FOR AT LEAST 15 MIN. REMOVE CONT
    LENSES IF WORN. SKIN: WASH THORO W/SOAP & WATER. REMOVE & WASH
    CONTAM CLTHG. INGEST: GIVE WATER/MILK TO DRINK & CALL MD. CONSULT
    MED PERS BEF ORE INDUCING VOMIT. IF MED ADVICE CANNOT BE OBTAINED,
    THEN TAKE PERS & PROD CONTR TO NEAREST MED EMER TREATMENT
    CTR/HOSPITAL. INHAL: MOVE TO FRESH AIR. SEE MD IF DISCOMFORT/IRRIT
    CONTINUES. (ING 5)

=====================  Fire Fighting Measures  =====================

Flash Point Method:COC
Flash Point:392F,200C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
    EQUIPMENT .
Unusual Fire/Explosion Hazard:LEAKS/RUPTURES IN HIGH PRESS SYS USING
    MATLS OF THIS TYPE CAN CREATE FIRE HAZ WHEN IN VICIN OF IGNIT
    SOURCES (E.G. OPEN FLAMES, PILOT LIGHTS, SPKS/ELEC ARCS).

==================  Accidental Release Measures  ==================

Spill Release Procedures:STOP SOURCE OF LEAK/RELEASE. CONTAIN LIQUID TO
    PREVENT FURTHER CONTAM OF SOIL, SURFACE WATER/GROUNDWATER. CLEAN UP
    SMALL SPILLS USING APPROP TECHNIQUES SUCH AS SORBENT MATLS/PUMPING.
    WHERE FEASIBLE &  APPROP, REMOVE CONTAMINATED SOIL. (ING 9)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:DO NOT USE HIGH PRESS SYS IN VICIN OF
    FLAMES, SPKS & HOT SURFACES. USE ONLY IN WELL-VENTILATED AREA. KEEP
    CONTR CLOSED. DO NOT WELD, HEAT/DRILL CONTR.
Other Precautions:REPLACE CAP/BUNG. EMPTIED CONTAINER STILL CONTAINS
    HAZ MATERIAL WHICH MAY IGNITE W/EXPLOSIVE VIOLENCE IF HEATED
    SUFFICIENTLY. CAUTION! DO NOT USE PRESSURE TO EMPTY DRUM/DRUM MAY
    RUPTURE W/EXPLOSIVE FO RCE. KEEP OUT OF REACH OF CHILDREN.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION IS NORMALLY
    REQUIRED. HOWEVER, IF OPERATING CONDITIONS CREATE AIRBORNE
    CONCENTRATIONS WHICH EXCEED THE RECOMMENDED EXPOSURE STANDARDS, THE
    USE OF A NIOSH APPROVED RES PIRATOR IS REQUIRED.
Ventilation:USE ADEQUATE VENTILATION TO KEEP THE AIRBORNE
    CONCENTRATIONS BELOW THE RECOMMENDED EXPOSURE STANDARDS.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
    ANSI DESIGN CRITERIA . WEAR PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: INHAL: CONSIDERED PRACTICALLY NON-TOX TO INTERNAL
    ORGANS. PRLNG/RPTD BRTHG OF VAP, MIST/AEROSOL AT CONCS ABOVE REC
    EXPOS STD MAY CAUSE RESP IRRIT. TOX INFO: EYES: DRAIZE EYE IRRIT
    SCO RE (RANGE, 0-110) IN RABBITS IS 2/110. SKIN: PRIMARY IRRIT
    INDEX (PII) IN RABBITS IS 0.7/8. (ING 3)

==================  Physical/Chemical Properties  ==================

Spec Gravity:0.88
Solubility in Water:INSOLUBLE
Appearance and Odor:PALE YELLOW LIQUID

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING AGENTS, SUCH AS CHLORATES, NITRATES,
    PEROXIDES, ETC.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NORMAL CONBUSTION FORMS CARBON DIOXIDE
    AND WATER VAPORS; INCOMPLETE COMBUSTION CAN PRODUCE CARBON
    MONOXIDE.

====================  Disposal Considerations  ====================

Waste Disposal Methods:MATL IS RECYCLABLE FOLLOWING USE FOR WHICH IT
    WAS INTENDED. CONT USED OIL COLLECTION CTR, LOC WASTE DISP AUTH,
    FIRE DEPARTMENT/PUBLIC HLTH AGENCY TO ENSURE LEGAL & ENVIRON SOUND
    DISPOSAL. DISPOSE OF I /A/W LOCAL, STATE & FEDERAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***