===================== Product Identification =====================
MSDS NAME:HT-2302 CARBON REMOVING COMPOUND, AMS1546
NIIN:00-803-6420
Status Code:A
MSDS Number: CJHCP
=== Responsible Party ===
Company:ELDORADO CHEMICAL COMPANY, INC.
Address:14350 LOOKOUT ROAD
Box:34837
City:SAN ANTONIO
State:TX
ZIP:78265-4837
Country:US
Info Phone Num:210-653-2060/FX2106530825
Emergency Phone Num:210-653-2060/800-255-3924(CHEM-TEL)
Preparer's Name:BOB E. FLYNT
CAGE:55208
=== Contractor Identification ===
Company:ELDORADO CHEMICAL COMPANY, INC.
Address:14350 LOOKOUT ROAD
Box:34837
City:SAN ANTONIO
State:TX
ZIP:78265-4837
Country:US
Phone:800-531-1088/ 210-653-2060
Contract Num:SP0450-00-M-D060
CAGE:55208
Company:ELDORADO CHEMICAL COMPANY, INC.
Address:14350 LOOKOUT ROAD
Box:34837
City:SAN ANTONIO
State:TX
ZIP:78265-4837
Country:US
Phone:800-531-1088/ 210-653-2060
Contract Num:SP0450-99-M-C773
CAGE:55208
============= Composition/Information on Ingredients =============
Name:DICHLOROBENZENE
CAS:95-50-1
RTECS #:CZ4500000
= Wt:60.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C300 MG/M3;C50 PPM
ACGIH TLV:150 MG/M3;25 PPM
ACGIH STEL:301 MG/M3;50 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Name:CRESOL
CAS:1319-77-3
RTECS #:GO5950000
= Wt:25.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:22 MG/M3;5 PPM
ACGIH TLV:22 MG/M3;5 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:AROMATIC NAPHTHA
CAS:8030-30-6
Code:F
RTECS #:DE3030000
= Wt:5.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 MG/M3;100 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYES, SKIN, LIVER,
KIDNEY, RESPIRATORY AND GASTROINTESTINAL TRACTS (HMIS). ACUTE -
INHALATION: SEVERE HAZARD. SYSTEMIC POISON. LIVER AND KIDNEY DAMAGE
MAY RESULT. SKIN CONTACT: SEVERE HAZARD. CORROSIVE TO SKIN. SKIN
ABSORBTION. CUMULATIVE POISON. SUSPECTED CARCINOGEN BY ANIMAL
STUDIES. EYE CONTACT. CORROSIVE TO EYES ON CONTACT. SHORT EXPOSURE
WILL CAUSE HAZY VISION WHICH SHOULD RET URN TO NORMAL. INGESTION:
CORROSIVE AND POISON (HMIS). CHRONIC - CUMULATIVE POISON.
SUSPECTED CARCINOGEN BY ANIMAL STUDIES. LIVER AND KIDNEY DAMAGE MAY
RESULT.
Effects of Overexposure:SEVERE IRRITATION, PAIN, TEARING
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH WATER FOR AT LEAST 15 MIN. SEEK MEDICAL
ATTENTION IMMEDIATELY. SKIN-WASH WITH SOAP AND WATER. SEEK MEDICAL
ATTENTION. INHALATION-REMOVE TO FRESH AIR. GIVE OXYGEN IF NEEDED.
SEEK MEDICA L ATTENTION IMMEDIATELY. INGESTION-DO NOT INDUCE
VOMITING. CONSULT PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:=82.2C, 180.F
Autoignition Temp:=426.7C, 800.F
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:WATER, CO2, DRY POWDER
Fire Fighting Procedures:SCBA IS REQUIRED, AVOID SKIN CONTACT
Unusual Fire/Explosion Hazard:CONTACT WITH FLAME MAY PRODUCE TOXIC
CHLORINE FUMES AND/OR PHOSGENE GAS
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN AND CLEAN UP SPILLS WITH ABSORBENT. DO
NOT ALLOW INTO DRAINS, SEWERS, STREAMS, OR WATERWAYS.
====================== Handling and Storage ======================
Handling and Storage Precautions:N/P. STORE IN A COOL, DRY, VENTILATED
AREA AWAY FROM OPEN FLAMES AND STRONG OXIDIZING AGENTS (HMIS)
Other Precautions:NOTE: NOT INTENDED FOR CONSUMER USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OSHA/NIOSH APPROVED RESPIRATORY PROTECTION
Ventilation:MATERIAL TRANSFER OR SPILL=100 FT/MIN
Protective Gloves:CHEMICAL RESISTANT
Eye Protection:GOGGLES AND FACE SHIELD
Other Protective Equipment:RUBBER BOOTS AND RAIN SUITS MATERIAL
USE=FULL WASH RACK GEAR. EYE BATH, WASHING FACILITY, EMERGENCY
SHOWER
Work Hygienic Practices:DO NOT USE IN A CONFINED SPACE. OBSERVE GOOD
INDUSTRIAL HYGIENE PRACTICES AND RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B2
Boiling Pt:=176.7C, 350.F
Vapor Pres:10 MMHG@20C
Vapor Density:5
Spec Gravity:1.2
pH:11
VOC Grams/Liter:8.5
Evaporation Rate & Reference:0.1 (WATER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:THIN, AMBER LIQUID, STRONG DIINFECTANT TYPE ODOR
Percent Volatiles by Volume:90
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
Hazardous Decomposition Products:CHLORINE FUMES AND/OR PHOSGENE GAS
MAYBE PRODUCED DURING COMBUSTION
==================== Disposal Considerations ====================
Waste Disposal Methods:AS IS, THIS PRODUCT HAS A D026 EPA HAZAROUS
WASTE CODE. CONSULT LOCAL, STATE, AND FEDERAL REGULATORY AGENCIES
FOR PROPER DISPOSAL.
=================== MSDS Transport Information ===================
Transport Information:SHIPPING NAME (DOT): CORROSIVE LIQUID, N.O.S.
(DICHLOROBENZENE AND CRESOLS), 8, UN1760, II, MARINE POLLUTANT,
RQ=100 LBS. ***THIS PRODUCT CONTAINS MATERIALS THAT HAVE BEEN
DETERMINED BY D.O.T., IMDG , AND IATA TO BE MARINE POLLUTANTS.
AVOID CONTAMINATING ALL WATERWAYS, LAKES, STREAMS AND OTHER WATER
AREAS.
======================= Other Information =======================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|