===================== Product Identification =====================
MSDS NAME:PED 12-0-12 INSULATING VARNISH
NIIN:00-166-1682
Status Code:A
MSDS Number: CJRGH
=== Responsible Party ===
Company:THE P. D. GEORGE COMPANY
Address:5200 N 2ND ST
City:ST LOUIS
State:MO
ZIP:63147-3122
Country:US
Info Phone Num:314-621-5700
Emergency Phone Num:800-935-5053
CAGE:97160
=== Contractor Identification ===
Company:THE P. D. GEORGE COMPANY
Address:5200 N 2ND ST
Box:City:ST LOUIS
State:MO
ZIP:63147-3122
Country:US
Phone:314-621-5700
CAGE:97160
Company:THE SMITH GROUP INC.
Address:811 E. CAYUGA STREET
Box:City:PHILADELPHIA
State:PA
ZIP:19124-3893
Country:US
Phone:215-743-8200
Contract Num:SP0430-99-M-TF52
CAGE:2B613
============= Composition/Information on Ingredients =============
Name:ETHYL BENZENE
CAS:100-41-4
RTECS #:DA0700000
< Wt:7.
OSHA PEL:435 MG/M3;100 PPM
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:543 MG/M3;125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:XYLENE (MIXED ISOMERS)
CAS:1330-20-7
RTECS #:ZE2100000
< Wt:18.
OSHA PEL:100 PPM/435 MG/M3
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:ALIPHATIC NAPHTHA
CAS:64742-89-8
< Wt:15.
OSHA PEL:500 MG/M3
ACGIH TLV:300 PPM/1370 MG/M3
Name:MINERAL SPIRITS INCLUDING THE TWO FOLLOWING INGREDIENTS.
CAS:8052-41-3
RTECS #:WJ8925000
< Wt:8.
OSHA PEL:2900 MG/M3;500 PPM
ACGIH TLV:525 MG/M3;100 PPM
Name:1,3,5-TRIMETHYLBENZENE
CAS:108-67-8
RTECS #:OX6825000
= Wt:2.5
Other REC Limits:NOT PROVIDED.
OSHA PEL:NOT DETERMINED.
ACGIH TLV:NOT DETERMINED.
Name:1,2,4-TRIMETHYLBENZENE
CAS:95-63-6
RTECS #:DC3325000
= Wt:2.5
Other REC Limits:NOT PROVIDED.
OSHA PEL:NOT DETERMINED.
ACGIH TLV:NOT DETERMINED.
Name:ALIPHATIC SOLVENT NAPHTHA (CAS 64742-89-8 ALREADY IN FOR
ALIPHATIC NAPHTHA, <15%)
< Wt:22.
OSHA PEL:500 MG/M3
ACGIH TLV:300 PPM/1370 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Health Hazards Acute and Chronic:ACUTE EFFECTS OF OVEREXPOSURE:
INHALATION: HIGH CENCENTRATIONS OF VAPORS/MIST MAY CAUSE NOSE AND
THROAT IRRITAITON. MAY AFFECT BRAIN/NERVOUS SYSTEM, CAUSING
DIZZINESS, HEADACHE/NAUSEA. SKIN CONTACT: C AN CAUSE IRRITATION
WHICH MAY INCLUDE SYMPTOMS OF REDDENING, SWELLING, RASH,
SCALING/BLISTERING. EYE CONTACT: VAPORS MAY BE IRRITATING. DIRECT
CONTACT MAY CAUSE CORNEAL INJURY. SKIN ABSORPTION: MAY BE HARMFUL
IF ABSORBED THROUGH SKIN. INGESTION: HARMFUL. MAY CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND/OR DIARRHEA.
CHRONIC EFFECTS OF OVEREXPOSURE: MAY CAUSE CNS, LIVER AND KIDNEY
EFFECT S AND RESPIRATORY AND EYE IRRITATION.
Explanation of Carcinogenicity:THIS MATERIAL (OR ITS COMPONENTS) WAS
FOUND TO BE TERATOGENIC IN ANIMAL STUDIES.
Effects of Overexposure:NOT PROVIDED.
Medical Cond Aggravated by Exposure:OVEREXPOSURE MAY AGGRAVATE EXISTING
EYE, SKIN, AND/OR RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: IF INHALED, REMOVE TO FRESH AIR. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. CONSULT A PHYSICIAN. EYE CONTACT: IN CASE OF CONTACT,
IMMEDIATELY FL USH EYES WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES. CONSULT A PHYSICIAN. SKIN CONTACT: IN CASE OF CONTACT,
IMMEDIATELY FLUSH SKIN WITH SOAP AND WATER FOR AT LEAST 15 MINUTES.
REMOVE CONTAMINATED CL OTHING AND SHOES. CLEAN BEFORE REUSE.
CONSULT A PHYSICIAN. INGESTION: IF SWALLOWED, CONSULT A PHYSICIAN.
THIS MATERIAL (OR ITS COMPONENTS) MAY PRESENT AN ASPIRATION HAZARD.
NEVER GIVE ANYTHING BY MOUT H TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:=25.6C, 78.F
Lower Limits:1%
Upper Limits:NO DATA
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM AND VAPORIZING
LIQUID TYPE EXTINGUISHING AGENTS HAVE ALL BEEN FOUND SUITABLE FOR
USE ON FLAMMABLE LIQUID FIRES OF MODERATE SIZE.
Fire Fighting Procedures:REMOVE ALL IGNITION SOURCES.WATER SPRAY MAY BE
INEFFECTIVE AND MAY CAUSE FIRE TO SPREAD.IF WATER IS USED,FOG
NOZZLES ARE PREFERRED.WATER MAY BE USED TO COOL CLOSED CONTAINERS
TO PREVENT PRESSURE BUILD -UP WHICH MAY RESULT IN EXPLOSION.USE
SELF-CONTAINED BBREATHING APPARATUS AND PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:A STRAIGHT STREAM OF WATER WILL SPREAD
FIRE.A VAPOR ACCUMULATION WILL FLASH AND/OR EXPLODE IF
IGNITED.CONTAINERS MAY BURST EXPLSOIVELY IF OVERHEATED.COOL
CONTAINERS WITH WATER SPRAY/FOG.EMPTY CONTAINE RS MAY ALSO PRESENT
FIRE/EXPLOSION HAZARD DUE TO RESIDUE VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. PROVIDE ADEQUATE
VENTILATION. AVOID BREATHING VAPORS. SHUT OFF SOURCE OF SPILL IF IT
CAN BE DONE SAFELY. USE NON-SPARKING TOOLS. ABSORB WITH INERT
ABSORBENT MATERIAL AND D ISPOSE OF IN ACCORDANCE WITH APPLICABLE
REGULATIONS.
Neutralizing Agent:NOT RELEVANT.
====================== Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. KEEP CLOSURE
TIGHT AND CONTAINER UPRIGHT TO PREVENT LEAKAGE. STORE CONTAINER OUT
OF SUNLIGHT AND AWAY FROM HEAT, SPARKS, AND FLAME. STORE ONLY IN
WELL-VENTILATED AREAS. CONTAI NERS SHOULD BE GROUNDED WHEN BEING
EMPTIED. DO NOT PUNCTURE, DRAG, OR SLIDE CONTAINER.
Other Precautions:NEVER USE PRESSURE TO EMPTY. CONTAINER IS NOT A
PRESSURE VESSEL. ATTENTION: EMPTIED CONTAINERS MAY RETAIN HAZARDOUS
RESIUE AND EXPLOSIVE VAPORS. KEEP AWAY FROM HEAT, SPARKS, AND
FLAMES. DO NOT CUT OR WELD ON OR NEAR THIS CONTAINER. FOLLOW LABEL
WARNINGS UNTIL CONTAINER THROUGHLY CLEANED OR DESTROYED .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR AN APPROPRIATE,PROPERLY FITTED
RESPIRATOR(NIOSH/MSHA APPROVED) DURING AND AFTER APPLICATION UNLESS
AIR MONITORING DEMONSTRATES THAT VAPOR/MIST LEVELS ARE BELOW
APPLICABLE LIMITS.FOLLOW RESPIRATOR MANUFACTURER'S DIRECTIONS FOR
RESPIRATOR USE.
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST VENTILATION IN VOLUME AND
PATTERN TO KEEP AIR CONCENTRATION BELOW OSHA PEL.
Protective Gloves:IMPERVIOUS
Eye Protection:SAFETY EYEWEAR TO PROTECT AGAINST SPLASH LIQUIDS.
Other Protective Equipment:EYEWASH,SAFETY SHOWER,IMPERVIOUS CLOTHING
AND BOOTS.SELECTION OF PERSONAL PROTECTIVE EQUIPMENT WILL DEPEND ON
THE PRODUCT USER'S OPERATION.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:>93.3C, 200.F
Vapor Density:NO DATA
Spec Gravity:0.95
Evaporation Rate & Reference:NO DATA
Percent Volatiles by Volume:58%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS AND ACIDS
Stability Condition to Avoid:OPEN FLAME,SPARKS,HIGH TEMPERATURE
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE AND
TOXIC VAPORS
=================== Toxicological Information ===================
Toxicological Information:NOT PROVIDED.
===================== Ecological Information =====================
Ecological:NOT PROVIDED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE
FEDERAL, STATE, AND LOCAL REGULATIONS. UNDER THE RESOURCE
CONSERVATION AND RECOVERY ACT (RCRA) REGULATORY, IT IS THE
RESPONSIBILITY OF THE PRODUCT USER TO DETE RMINE, AT THE TIME OF
DISPOSAL, WHETHER A MATERIAL SHOULD BE CLASSIFIED AS A HAZARDOUS
WASTE. CONSUL T YOUR ATTORNEY OR REGULATORY OFFICER.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 312: FIRE HAZARD + ACUTE HEALTH
HAZARD + CHRONIC HEALTH HAZARD. SECTION 313 STATUS: ETHYL BENZENE
100-41-4 < 7%, XYLENE (MIXED ISOMERS) 1330-20-7 < 18%
Federal Regulatory Information:ALL COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE TOXIC SUBSTANCE CONTROL ACT (TSCA) SECTION B(B)
INVENTORY OR EXEMPT FROM THE INVENTORY.
State Regulatory Information:CALIFORNIA PROPOSITION 65 STATUS: WARNING:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE CANCER. WARNING: THIS PRODUCT CONTAINS A CHEMICAL KNOWN
TO THE STATE OF CALIFORNI A TO CAUSE BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM. MASSACHUSETTS RIGHT TO KNOW: ETHYL BENZENE <7,
XYLENE (MIXED ISOMERS) <18, MINERAL SPIRITS <8 HYDROCHLORIC ACID:
TRACE. PENNSYLVANIA RIGHT TO KNOW : ETHYL BENZENE <7, XYLENE
(MIXED ISOMERS) <18, MINERAL SPIRITS <8
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|