===================== Product Identification =====================
MSDS NAME:DO-IT BEST PREMIUM SATIN LATEX, W56 W 790 BRIGHT WHITE
Status Code:A
MSDS Number: CKQMS
=== Responsible Party ===
Company:SHERWIN-WILLIAMS CO
Box:6709
City:CLEVELAND
State:OH
ZIP:44101
Country:US
Info Phone Num:216-566-2902
Emergency Phone Num:216-566-2917
Resp. Party Other MSDS Num.:LI/HW1
CAGE:54636
=== Contractor Identification ===
Company:SHERWIN-WILLIAMS CO THE
Address:101 PROSPECT AVE NW
Box:City:CLEVELAND
State:OH
ZIP:44115-1042
Country:US
Phone:800-251-2486/216-566-2242
CAGE:54636
============= Composition/Information on Ingredients =============
Name:2-(2-BUTOXYETHOXY) ETHANOL. (VAPOR PRESSURE: 0.1MMHG)
CAS:112-34-5
RTECS #:KJ9100000
= Wt:2.
Name:ETHYLENE GLYCOL. (VAPOR PRESSURE: 0.1 MMHG)
CAS:107-21-1
RTECS #:KW2975000
= Wt:2.
OSHA PEL:C50 PPM
ACGIH TLV:C50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Name:CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
= Wt:.1
OSHA PEL:0.05 MG/M3(RESP DUST
ACGIH TLV:0.05 MG/M3(RESP DUST
Name:CALCIUM CARBONATE
CAS:471-34-1
RTECS #:FF9335000
= Wt:2.
OSHA PEL:15 MG/M3 (RESP DUST)
OSHA STEL:5 MG/M3 (RESP DUST)
ACGIH TLV:10 MG/M3 (RESP DUST)
Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
= Wt:24.
OSHA PEL:15 MG/M3 (RESP DUST)
OSHA STEL:5 MG/M3 (RESP DUST)
ACGIH TLV:10 MG/M3 (RESP DUST)
Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
= Wt:45.6
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EXPOSURE MAY BE BY INHAL AND/OR
SKIN/EYE CONT, DEPENDING ON CNDTNS OF USE. TO MINIMIZE EXPOS,
FOLLOW RECS FOR PROPER USE, VENT, & PERSONAL PROT EQUIP. ACUTE:
IRRITATION OF EYES, SKIN & UPPER RESPIRATO RY SYSTEM. IN CONFINED
AREA VAPORS IN HIGH CONCENTRATION MAY CAUSE HEADACHE, NAUSEA OR
DIZZINESS. CHRONIC: CRYSTALLINE SILICA (QUARTZ, CRISTOBALITE) IS
LISTED BY IARC & NTP. LONG TERM EXPOSURE TO HIGH LEVELS OF SILICA
DUST, WHICH CAN OCCUR ONLY WHEN SANDING OR ABRADING DRY FILM, MAY
CAUSE LUNG DAMAGE (SILICOSIS) AND POSSIBLY CANCER. ETHYLENE GLYCOL
IS CONSIDERED ANIMAL TERATOGEN. IT HAS BEEN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA, QUARTZ AND
CRISTOBALITE: IARC MONOGRAPHS, VOL 68, 1997: GROUP 1. NTP 9TH
ANNUAL REPORT ON CARCINOGENS. 1998: ANTICIPATED TO BE CARCINOGEN.
Effects of Overexposure:HLTH HAZS: SHOWN TO CAUSE BIRTH DEFECTS IN RATS
& MICE AT HIGH DOSES WHEN GIVEN IN DRINKING WATER/BY GAVAGE. THERE
IS NO EVIDENCE TO INDICATE IT CAUSES BIRTH DEFECTS IN HUMANS.
PROLONGED OVEREXPOSURE TO SOLVENT INGREDS IN SECTION II MAY CAUSE
ADVERSE EFFECTS TO LIVER & URINARY SYSTEMS. RATS EXPOSED TO
TITANIUM DIOXIDE DUST AT 250 MG/M3 DEVELOPED LUNG CANCER. HOWEVER,
SUCH EXPOSURE LEVELS ARE NOT A TTAINABLE IN THE WORKPLACE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM & QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE.
EYES: FLUS H WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
GET MEDICAL ATTENTION. INGEST: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG
NOZZLES ARE PREFERABLE. WATER MAY BE USED TO COOL CLSD CNTNRS TO
PVNT PRESSURE BUILD -UP & POSSIBLE AUTOIGNITION OR EXPLOSION WHEN
EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT. HMIS (NFPA)
RATING(HEALTH-FLAMMABILITY-REACTIVITY): 2-0-0.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
====================== Handling and Storage ======================
Handling and Storage Precautions:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP
& SPRAY MIST. AVOID CONT W/SKIN & EYES. WASH HANDS AFTER USING.
THESE COATINGS MAY CNTN MATLS CLASSIFIED AS NUISANCE PARTICULATES
(LISTED "AS DUST" IN SECTION II) WHICH MAY BE PRESENT ! HAZ LEVELS
ONLY DURING SANDING/ABRADING OF DRIED FILM.
Other Precautions:IF NO SPECIFIC DUSTS ARE LISTED IN SECTION II,
APPLICABLE LIMITS FOR NUISANCE DUSTS ARE ACGIH TLV 10 MG/M3 (TOTAL
DUST), OSHA PEL 15 MG/M3 (TOTAL DUST), 5 MG/M3 (RESPIRABLE
FRACTION. KEEP CNTNR CLSD W HEN NOT IN USE. TRANSFER ONLY TO APPRVD
CNTNRS W/COMPLETE & APPROP LBLG. DO NOT TAKE INTERNALLY. (SU PDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENT, WEAR PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH FOR PROTECTION
AGAINST MATLS IN SECTION II. WHEN SANDING OR ABRADING DRIED FILM.
WEAR DUST/MIST RESPIRATOR APPROVED BY NIOSH FOR DUST WHICH MAY BE
GENERATED FROM THIS PRODUCT, (SUPDAT)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOSURE TO MATLS
IN SECTION II IS MAINTAINED BELOW APPLICABLE EXPOSURE LIMITS.
(SUPDAT)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER
MEETING ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
WEIGHT PER GALLON: 10.65 LBS. VOC - TOTAL (LBS/GAL.): 0.37. VOC -
LESS WATER (LBS/GAL): 0.89. HMIS (NFPA) RATING (HEALTH,
FLAMMABILITY, REACTIVITY): 2, 0, 0. OTHER PREC: KEEP OUT OF REACH
OF CHILD REN. RESP PROT: UNDERLYING PAINT, OR THE ABRASIVE. VENT:
REFER TO OSHA STANDARDS 1910.94, 1919.107, 1910.108.
================== Physical/Chemical Properties ==================
Boiling Pt:>100.C, 212.F
B.P. Text:212-488F
Vapor Pres:SEE INGREDIENTS
Vapor Density:HVR/AIR
Spec Gravity:1.12-1.55
pH:8.2-9.0
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:57-81
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THESE PRODS IS NOT HAZ AS DEFINED
UNDER RCRA 40 CFR 261. INCINERATE IN APPRVD FACILITY. DO NOT
INCINERATE CLOSED CONTAINER. DISPOSE OF IN ACCORDANCE WITH FEDERAL,
STATE, AND LOCAL REGULATIO NS REGARDING POLLUTION.
===================== Regulatory Information =====================
SARA Title III Information:22-(2-BUTOXYETHOXY)-ETHANOL AND ETHYLENE
GLYCOL ARE SUBJECT TO REPORTING REQUIREMENTS OF THE SUPERFUND
AMENDMENT AND REAUTHORIZATION ACT (SARA) SECTION 313, 40 CFR
372.85C.
State Regulatory Information:CALIFORNIA PROPOSITION 65: THESE PRODUCTS
CONTAIN A CHEMICAL(S) KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|