===================== Product Identification =====================
MSDS NAME:C-SOLV #1301 INDUSTRIAL SOLVENT DEGREASER
NIIN:01-412-0986
Status Code:A
MSDS Number: CLBTC
=== Responsible Party ===
Company:ZEP MFG CO DIV OF NATIONAL SERVICE INDUSTRIES
Address:1310 SEABOARD INDUSTRIAL BLVD NW
Box:2015
City:ATLANTA
State:GA
ZIP:30301
Country:US
Emergency Phone Num:(800)424-9300
Chemtrec Ind/Phone:(800)424-9300
CAGE:27674
=== Contractor Identification ===
Company:ZEP MANUFACTURING COMPANY
Address:1310 SEABOARD INDUSTRIAL BLVD NW
Box:2015
City:ATLANTA
State:GA
ZIP:30318
Country:US
Phone:877-428-9937
CAGE:27674
============= Composition/Information on Ingredients =============
Name:HYDROTREATED LIGHT DISTILLATE (PETROLEUM): PARAFFINIC,
NAPHTHENIC SOLVENT
CAS:64742-47-8
RTECS #:OA5504000
Minumum % Wt:60.
Maxumum % Wt:70.
Other REC Limits:PEL OF 100PPM
Name:D-LIMONENE: ORANGE DISTILLATE; CITRUS TERPENE; CYCLOHEXENE,
1-METHYL-4(1-METHYLETHENYL)-, (R)-
CAS:5989-27-5
RTECS #:GW6360000
Minumum % Wt:30.
Maxumum % Wt:40.
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:OVEREXPOSURE TO VAPORS MAY CAUSE
MUCOUS MEMBRANE IRRITATION, PARTICULARLY OF EYE AND RESPIRATORY
TRACT. VAPORS MAY ALSO PRODUCE MILD, CENTRAL NERVOUS SYSTEM
DEPRESSION, CHARACTERIZED BY HEADACHE, DIZZ INESS, NAUSEA, AND
STUPOR, LEADING TO UNCONSCIOUSNESS IN EXTREME CASES. INTRODUCTION
OF SOLVENTS AS AN ASPIRATION OF VOMITOUS FLUID MAY PRODUCE CHEMICAL
PNEUMONIA. EXISTING RESPIRATORY DISORDERS AND LUNG DISEASES MAY
BE AGGRIVATED BY INHALATION OF VAPORS. SKIN REPEATEDLY DEFATTED
FROM CONTACT MAY BE MORE SUSCEPTABLE TO IRRITATION, INFECTION, OR
DERMATITIS. ONE INGREDIANT HAS CAUSED SENSITIZATION IN SMALL % OF
GENERAL POPULATION.
Effects of Overexposure:MSDS DATA PERTAINS TO PRODUCT AS DISPENSED FROM
CONTAINER. ADVERSE HEALTH EFFECTS WOULD NOT BE EXPECTED UNDER
RECOMMENDED CONDITIONS OF USE (DILUTED) SO LONG AS PRESCRIBED
SAFETY CONDITIONS ARE PRACTI CED.
Medical Cond Aggravated by Exposure:EXISTING RESPIRATORY AND LUNG
DISEASES BY INHALATION OF VAPORS.
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. WASH WITH SOAP OR
MILD DETERGENT. APPLY SKIN CREAM WITH LANOLIN. IF IRRITATION
PERSISTS, SEE DR. EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15
MINUTES, OC CASIONALLY LIFTING UPPER AND LOWER LIDS. GET MEDUCAL
ATTENTION. INHALATION: REMOVE TO FRESH AIR. IF IRRITATION
PERSISTS, GET MED ATTENTION PROMPTLY. INGESTION: DO NOT INDUCE
VOMITING. IF VOMITING O CCURS, KEEP HEAD BELOW HIP LEVEL. CALL DR
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=62.2C, 144.F
Lower Limits:0.6
Upper Limits:6.1
Extinguishing Media:WATER FOG, ALCOHOL FOAM, DRY CHEMICAL, CARBON
DIOXIDE
Fire Fighting Procedures:WEAR POSITIVE PRESSURE, SELF-CONTAINED
BREATHING APARATUS. FIRE EXPOSED DRUMS SHOULD BE COOLED WITH STREAM
OF WATER.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:OBSERVE SAFETY PROCEDURES AS OUTLINED IN THIS
MSDS. ABSORB SPILL ON INERT, ABSORBANT MATERIAL (ZEP-O-ZORB). PICK
UP AND PLACE RESIDUE IN CLEAN, DOT SPECIFICATION CONTAINER FOR
DISPOSAL. WASH AREA THOR OUGHLY WITH DETERGENT SOLUTION, THEN RINSE
WELL WITH WATER.
====================== Handling and Storage ======================
Handling and Storage Precautions:COMBUSTABLE! STORE/USE AWAY FROM HEAT,
SPARKS, OPEN FLAME, OR ANY SOURCE OF IGNITION. STORE TIGHTLY
CLOSED CONT. IN DRY AREA AT 40-120 DEGREES F. KEEP AWAY FROM
SKIN/EYES. DO NOT BRETHE SPRAY MISTS O R VAPORS. REMOVE
CONTAMINATED CLOTHING OR SHOES IMMEDIATELY AND NOT REWORN UNTIL
THOROUGHLY CLEANED.
Other Precautions:KEEP OUT OF THE REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN EXPOSURE LEVELS EXCEED PEL/TLV (LIKELY IN
CONFINED AREAS), USE AN ORGANIC VAPOR RESPIRATOR (ZEP 2211)
Ventilation:PROVIDE LOCAL EXHAUST/VENTILATION AS NEEDED TO KEEP
CONCENTRATION OF VAPORS BELOW EXPOSURE LIMITS (PEL/TLV)
Protective Gloves:NEOPRENE, NITRILE, OR GLOVES PROVEN TO BE RESISTANT
TO INGREDIENTS
Eye Protection:WEAR TIGHT-FITTING SAFETY GLASSES OR GOGGLES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=171.1C, 340.F
Spec Gravity:0.828
Solubility in Water:NONE
Appearance and Odor:CLEAR, THIN LIQUID WITH AN ORANGE-LIKE FRAGRANCE
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HEAT, FLAME, SPARKS, STRONG ACIDS, AND/OR OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE, AND
OTHER UNIDENTIFIED ORGANIC COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQUIDS CANNOT BE SENT TO LANDFILLS. PRODUCT IS
NOT CONSIDERED A HAZARDOUS WASTE UNDER RCRA. ABSORB UNUSABLE LIQUID
ON AN INERT, ABSORBANT MATERIAL (EG. ZEP-O-ZORB), DRUMMED AND TAKEN
TO A CHEMICAL/IN DUSTRIAL LANDFILL. PRETREATMENT MAY BE REQUIRED
BEFORE LANDFILLING. CONSULT LOCAL, STATE, OR FED AGE NCIES FOR
PROPER DISPOSAL METHOD IN YOUR AREA.
===================== Regulatory Information =====================
State Regulatory Information:
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|