=====================  Product Identification  =====================

MSDS NAME:VP-31A PENETRANT
NIIN:01-264-8678
MSDS Number: BGTBF
=== Responsible Party ===
Company:MET-L-CHEK COMPANY
Address:1639 EUCLID STREET
City:SANTA MONICA
State:CA
ZIP:90404-3770
Country:US
Info Phone Num:213-450-1111
Emergency Phone Num:213-450-1111
CAGE:98733
=== Contractor Identification ===
Company:MET-L-CHEK COMPANY
Address:1639 EUCLID ST
Box:00000
City:SANTA MONICA
State:CA
ZIP:90404
Country:US
Phone:310-450-1111/FAX 310452-4046
CAGE:98733

=============  Composition/Information on Ingredients  =============

Name:DISTILLATE (PETROLEUM),HYDROTREATED MIDDLE; ON MSDS MFR
    SIMOLY NOTED AS "PETROLEUM HYDROCARBON" FOR ABOVE CAS NO.
CAS:64742-46-7
RTECS #:JN9379645
OSHA PEL:5MG/CUM
ACGIH TLV:5MG/CUM

=====================  Hazards Identification  =====================

Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN	  IARC:UNKNOWN	  OSHA:YES
Health Hazards Acute and Chronic:PER MANUFACTURER,MAY CAUSE SLIGHT
    IRRITATION TO SKIN ON CONTACT AND RESPIRATORY TRACT SYSTEM.
Explanation of Carcinogenicity:CARCINOGENICITY OF THE PRODUCT FOR OSHA
    REQUIREMENTS IS SPECIFIED"YES" BY THE MFR BUT DID NOT SPECIFIED THE
    COMPONENT.
Effects of Overexposure:EYES:PRESUMED NON-IRRITATING;SKIN:SLIGHT
    IRRITATION ON LIQUID CONTACT;INHALATION:VAPORS OR OIL MIST MAY
    CAUSE MILD IRRITATION OF UPPER RESPIRATORY TRACT;INGESTION:MAY
    RESULT IN VOMITING.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
    DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

=======================  First Aid Measures  =======================

Eyes:FLUSH WITH WATER.GET MEDICAL HELP IF IRRITATION OCCURS
    OR PERSISTS; SKIN: FLUSH WITH WATER.WASH WITH WATER & SOAP.GET MED
    ATTN FOR PERSISTING IRRITATION; INHALATION:REMOVE TO FRESH
    AIR.PROVIDE OX YGEN IF BREATHING IS DIFFICULT GET MED ATTN IF
    NEEDED; INGESTION:DO NOT INDUCE VOMITING.GET MEDICAL ATTENTION.

=====================  Fire Fighting Measures  =====================

Flash Point Method:PMCC
Flash Point:188F(86.7C)
Extinguishing Media:WATDR FOG,DRY CHEMICAL,CARBON DIOXIDE OR FOAM;DO
    NOT USE DIRECT STREAM OF WATER.
Fire Fighting Procedures:IN CONFINED AREA,DO NOT ENTER WITH A FULL
    BUNKER GEAR INCLUDING A POSITIVE PRESSURE NIOSH APPROVED SELF
    CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NOT KNOWN

==================  Accidental Release Measures  ==================

Spill Release Procedures:ELIM IGNITION SOURCES.WEAR APPROPRIATE
    PROTECTIVE CLOTHING & RESPIRATOR.DIKE & TRANSFER LIQ TO A SALVAGE
    TANK,SOAK UP RESIDUE WITH ABSORBENT CLAY,SAND OR OTHR MATL.PLACE
    RAGS & ABSORBED WASTE MATERL I N COVERED NON-LEAKING CONTAINERS.

======================	Handling and Storage  ======================

Handling and Storage Precautions:KEEP AWAY FROM HEAT/IGNITION SOURCES.
    STORE IN DRY,COOL,& VENTILATED LOCATION.DO NOT STORE NEAR OXIDIZING
    MATERIAL. AVOID PHYSICAL DAMAGE TO CANS.
Other Precautions:MINIMIZE SKIN CONTACT.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF EXPOSURE EXCEEDS TLV,USE NIOSH APPRVD
    RESPIRATOR TO PREVENT OVEREXPOSURE.
Ventilation:PER MANUFACTURER,PROVIDE LOCAL EXHAUST, OR
    MECHANICAL(GENERAL) VENTILATION TO MAINTAIN.
Protective Gloves:CHEMICAL RESISTANT
Eye Protection:GOGGLES
Other Protective Equipment:EYE WASH FOUNTAINS AND SAFETY SHOWERS.
Work Hygienic Practices:WASH WITH SOAP AND WATER BEFORE
    EATING,DRINKING,SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NSN FOR TYPE II,METHOD C PRODUCT I/A/W QPL-25135-15 OF
    MIL-I-25135,REVISION D; THIS ENTRY DESCRIBES P/N:VP-31A PENETRANT
    MFR MAY SUPPLY EITHER VP-30 OR VP-31A I/A/W QPL UNDER THIS NSN.

==================  Physical/Chemical Properties  ==================

HCC:V4
Boiling Pt:B.P. Text:>400F/>204C
Spec Gravity:0.86
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DEEP REDDISH-PURPLE LIQUID,HYDROCARBON ODOR.

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL
Stability Condition to Avoid:HEAT & IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE & OTHER UNIDENTIFIED
    ORGANIC COMPOUNDS.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF AS EPA HAZARDOUS WASTE
    #D001,IGNITABLE WASTE.PLACE WASTE MATERIAL IN AN APPROPRIATE
    DISPOSAL FACILITY, OR DISPOSE OF IN COMPLIANCE WITH FEDERAL,STATE &
    LOCAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***