=====================  Product Identification  =====================

MSDS NAME:VP-30 PENETRANT
NIIN:01-264-8677
MSDS Number: BGTBB
=== Responsible Party ===
Company:MET-L-CHEK COMPANY
Address:1639 EUCLID STREET
City:SANTA MONICA
State:CA
ZIP:90404-3770
Country:US
Info Phone Num:213-450-1111
Emergency Phone Num:213-450-1111
CAGE:98733
=== Contractor Identification ===
Company:MET-L-CHEK COMPANY
Address:1639 EUCLID ST
Box:00000
City:SANTA MONICA
State:CA
ZIP:90404
Country:US
Phone:310-450-1111/FAX 310452-4046
CAGE:98733

=============  Composition/Information on Ingredients  =============

Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC
CAS:64742-88-7
OSHA PEL:500PPM
ACGIH TLV:100PPM

Name:SOLVENT NAPHTHA (PETROLEUM) LIGHT AROMATIC
CAS:64742-95-6
OSHA PEL:500PPM
ACGIH TLV:100PPM

=====================  Hazards Identification  =====================

Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SLIGHT SKIN
    IRRITATION;VAPORS OR OIL MIST MAY CAUSE MILD IRRITATION OF UPPER
    RESPIRATORY TRACT,AND CAUSES CNS DEPRESSION.
Effects of Overexposure:EYES/SKIN:LIQUID IS MINIMALLY IRRITATING TO THE
    EYES AND SLIGHTLY IRRITATING TO THE SKIN.VAPORS CAUSE EYES
    IRRITATION; INHALATION:VAPORS CAUSE IRRITATION TO NOSE,THROAT AND
    RESPIRATORY TRACT,AND CAUSE  CNS DEPRESSION;INGESTION:MAY CAUSE
    NAUSEA,GIDDINESS OR HEADACHE,AND POSSIBLE VOMITING.
Medical Cond Aggravated by Exposure:PREEXISTING EYE,SKIN AND
    RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
    PRODUCT.

=======================  First Aid Measures  =======================

First Aid:EYES/SKIN:FLUSH WITH PLENTY OF RUNNING WATER.REMOVE
    VONTAMINATED CLOTHS,AND WASH SKIN WITH SOAP & WATER GET MEDICAL
    ASST IF IRRITATION PERSISTS;INHALATION:REMOVE TO FRESH AIR.PROVIDE
    OXYGEN IF BREATHI NG IS DIFFICULT.GIVE ARTIFIICIAL RESPIRATION IF
    REQUIRED.GET MED HELP IF NEEDED;INGESTION:DO NOT INDUCE
    VOMITNG.NOTHING BY MOUTH IF VICTIM IS UNCONSCIOUS;GET MEDICAL
    ASSISTANCE IMMEDIATELY.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:140F/60C
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:WATER FOG,DRY CHEMICAL,CARBON DIOXIDE OR FOAM;DO
    NOT USE DIRECT STREAM OF WATER.
Fire Fighting Procedures:IN CONFINED AREA,DO NOT ENTER WITHOUT A FULL
    BUNKER GEAR INCLUDING A POSITIVE PRESSURE NIOSH APPROVED
    SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTENSE HEAT FROM
    FIRE SHOULD BE COOLED WITH WATER SPRAY TO PREVENT VAPOR PRESSURE
    BUILDUP WHICH COULD RUPTURE CONTAINER.

==================  Accidental Release Measures  ==================

Spill Release Procedures:ELIM IGNITION SOURCES.WEAR APPROPRIATE
    PROTECTIVE CLOTHING & RESPIRATOR.DIKE & TRANSFER LIQ TO A SALVAGE
    TANK.SOAK UP RESIDUE WITH ABSORBENT CLAY,SAND OR OTHR MATL.PLACE
    RGAS & ABSORBED WASTE MATERL I N COVERED NON-LEAKING CONTAINERS.

======================	Handling and Storage  ======================

Handling and Storage Precautions:KEEP AWAY FROM HEAT/IGNITION SOURCES.
    STROR IN DRY,COOL& VENTILATED LOCATION.DO NOT STORE NEAR OXIDIZING
    MATERIAL. AVOID PHYSICAL DAMAGE TO CANS.
Other Precautions:MINIMIZE SKIN CONTACT.KEEP CONTAINERS CLOSED WHEN NOT
    IN USE.USE WITH ADEQUATE VENTILATION;AVOID PROLONGED BREATHING OF
    VAPORS.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF EXPOSURE EXCEEDS TLV,USE NIOSH APPRVD
    RESPIRATOR TO PREVENT OVEREXPOSURE.
Ventilation:PER MANUFACTURER,PROVIDE LOCAL EXHAUST, OR
    MECHANICAL(GENERAL) VENTILATION TO MAINTAIN TLV.
Protective Gloves:CHEMICAL RESISTANT
Eye Protection:GOGGLES
Other Protective Equipment:EYE WASH FOUNTAINS AND SAFETY SHOWERS.
Work Hygienic Practices:WASH WITH SOAP AND WARER BEFORE EATING,
    DRINKING,SMOKING OR USING TOILET FACILITIES,MINIMIZE SKIN CONTACT.
Supplemental Safety and Health
NSN FOR TYPE II,METHOD C OF MIL-I-25135,REVISION "D";PER
    QPL-25135-15,THE QUALIFIED PRODUCTS OF MET-L-CHEK ARE VP-30 AND
    VP-31A PENETRANTS FOR TYPE II,METHOD C. THIS ENTRY DESCRIBES:VP-30
    PENETRANT; M FR MAY SUPPLY EITHER VP-30 OR VP-31A UNDER THIS NSN.

==================  Physical/Chemical Properties  ==================

HCC:F4
Boiling Pt:B.P. Text:368-415F
Spec Gravity:0.8
Evaporation Rate & Reference:<0.1 (BUTYL ACETAYE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DEEP RED COLORED LIQUID,HYDROCARBON ODOR

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL
Stability Condition to Avoid:HEAT & IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE & OTHER UNIDENTIFIED
    ORGANIC COMPOUNDS.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF AS EPA HAZARDOUS WASTE
    #D001,IGNITABLE  WASTE.PLACE WASTE MATERIAL IN AN APPROPRIATE
    DISPOSAL FACILITY, OR DISPOSE OF IN COMPLIANCE WITH FEDERAL,STATE &
    LOCAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***