=====================  Product Identification  =====================

MSDS NAME:PR-1201-HT, PART B
NIIN:00-117-9135
Kit Part:Y
MSDS Number: BHCJD
=== Responsible Party ===
Company:PRODUCTS RESEARCH & CHEMICAL CORPORATION
Address:5430 SAN FERNANDO ROAD
Box:1800
City:GLENDALE
State:CA
ZIP:91209
Country:US
Info Phone Num:818-240-2060
Emergency Phone Num:818-240-2060
Preparer's Name:AO
CAGE:DO563
=== Contractor Identification ===
Company:PRC-DESOTO INTERNATIONAL, INC. A PPG INDUSTRIES COMPANY
Address:5430 SAN FERNANDO RD
Box:1800
City:GLENDALE
State:CA
ZIP:91209
Country:US
Phone:818-240-2060
CAGE:83574
Company:PRODUCTS RESEARCH & CHEMICAL
Address:NOW DBA COURTAULDS AEROSPACE
Box:1800
City:GLENDALE
State:CA
ZIP:91209
Phone:818-240-2060
CAGE:DO563

=============  Composition/Information on Ingredients  =============

Name:PHENOL FORMALDEHYDE RESIN
CAS:9003-35-4
Fraction by Wt: <5%

Name:TOLUENE  (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:LD50 ORAL (RAT) IS NOT ESTABLISHED.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MILD IRRITATION OF SKIN,
    EYE.MAY SENSITIZE ALLERGIC REACTIONS.INHALATION CAUSES NARCOTIC
    EFFECTS, CHRONIC:MAY CAUSE LIVER AND/OR KIDNEY DAMAGE.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN ANY
    COMPOUNDS WHICH ARE LISTED BY NTP, IARC OR OSHA AS CARCINOGENIC.
Effects of Overexposure:IRRITATION OF EYE,SKIN,RESPIRATORY TRACT. 
    INHALED:HEADACHE,CONFUSION,DIZZINESS NUMBNESS,FATIGUE.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF  KIDNEY,
    LIVER, PULMONARY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.

=======================  First Aid Measures  =======================

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING IF NEEDED.
    GET MEDICAL ATTENTION. EYE: IMMEDIATELY FLUSH WITH PLENTY OF WATER
    FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION. SKIN: FLUSH WITH
    SOAP A ND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNEER BEFORE
    REUSE. INGESTION: DO NOT INDUCE VOMITING. GIVE WATER TO DRINK.
    NOTHING BY MOUTH IF UNCONSCIOUS. GET MEDICAL IMMEDIATE ATTNENTION.

=====================  Fire Fighting Measures  =====================

Flash Point Method:PMCC
Flash Point:188F,87C
Lower Limits:1.3
Upper Limits:7.0
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
    FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
    FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
    SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE

==================  Accidental Release Measures  ==================

Spill Release Procedures:ABSORB WITH SAND OR INERT MATERIAL.  SWEEP OR
    SCOOP UP AND REMOVE. CLEAN WITH CHLORINATED SOLVENT.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE IN A COOL DRY WELLVENTILATED
    AREA. KEEP AWAY FROM HEAT, SPARKS, AND OPEN FLAMES.
Other Precautions:NONE

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NOT NORMALLY REQUIRED.USE NIOSH/MSHA APPROVED
    EQUIPMENT FOR ORGANIC VAPORS IF TLV/PEL IS EXCEEDED.
Ventilation:NORMAL VENTILATION IS USUALLY SUFFICIENT.
Protective Gloves:SOLVENT RESISTANT
Eye Protection:SAFETY GLASSES - GOGGLES
Other Protective Equipment:NONE
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICES.WASH
    THOROUGHLY AFTER HANDLING, AND BEFORE EATING, DRINKING OR SMOKING.
Supplemental Safety and Health
MSDS NO. MS4072C00.

==================  Physical/Chemical Properties  ==================

HCC:V4
Vapor Density:3.14
Spec Gravity:1.40
Solubility in Water:SLIGHT
Percent Volatiles by Volume:2.9

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
    OXIDES OF SULFUR

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL,STATE,LOCAL
    REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***