45-499 Page: 1
MATERIAL SAFETY DATA SHEET
PRODUCT NAME: POOLPOXY HI-BILD CAT. (PART B) HMIS CODES: H F R P
PRODUCT CODE: 45-499 3*3 1
=================== SECTION I - MANUFACTURER IDENTIFICATION ==================
MANUFACTURER'S NAME: NELSONITE POOL AND DECK COATING
ADDRESS : 3150 E. PICO BLVD.
LOS ANGELES, CA 90023-3683
EMERGENCY PHONE(CHEMTREC) : (800) 424-9300 DATE PRINTED : 09/21/06
INFORMATION PHONE : (800) 544-1998 NAME OF PREPARER : N/A
=========== SECTION II - HAZARDOUS INGREDIENTS/SARA III INFORMATION ==========
VAPOR PRESSURE WEIGHT
REPORTABLE COMPONENTS CAS NUMBER mmHG @TEMP(F) PERCENT
----------------------------------------------------------------------------------
NON-HAZARDOUS ING. OF ANCAMINE 1884 PROPRIETARY 19.9
LIGHT AROMATIC SOLVENT NAPHTHA 64742-95-6 3 68 19.7
OSHA PEL: 100 ppm, ACGIH TLV: 100 ppm
FATTY ACID POLYAMIDE. 68410-23-1 0 68 19
OSHA PEL: NOT KNOWN, ACGIH TLV: NOT KNOWN
1,2-CYCLOHEXANEDIAMINE 694-83-7 0 68 13
OSHA PEL: NE, ACGIH TLV: NE
BENZYL ALCOHOL 100-51-6 NE NE 11
OSHA PEL: NE, ACGIH TLV: NE
~ XYLENE 1330-20-7 6.1 68 10.39
OSHA PEL: 100 ppm, ACGIH TLV: 100 ppm
~ ALIPHATIC AMINE PROP. 4.05
TRIETHYLENE TETRAMINE 112-24-3 NA NA 2
OSHA PEL: NE, ACGIH TLV: NE
~Indicates toxic chemical(s) subject to the reporting requirements of section
313 of Title III and of 40 CFR 372.
================ SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS =============
BOILING RANGE (Deg F): 92 - 401 F DENSITY: 8.09 lb/gl
VAPOR DENSITY: HEAVIER THAN AIR SPECIFIC GRAVITY (H2O=1): 0.97
COATING V.O.C.: 2.44 lb/gl MATERIAL V.O.C.: 2.44 lb/gl
COATING V.O.C.: 292 g/l MATERIAL V.O.C.: 292 g/l
SOLUBILITY IN WATER: Negligible EVAPORATION RATE: SLOWER THAN ETHER
APPEARANCE AND ODOR: Clear liquid with mild odor
================== SECTION IV - FIRE AND EXPLOSION HAZARD DATA ===============
FLASH POINT (Deg F): 23 95 METHOD USED: TCC
FLAMMABLE LIMITS IN AIR BY % VOLUME- LOWER: .01 UPPER: 7
EXTINGUISHING MEDIA: FOAM, CO2, DRY CHEMICAL FOAM, ALCOHOL FOAM, CO2, DRY
CHEMICAL
SPECIAL FIREFIGHTING PROCEDURES
Use approved self-contained breathing apparatus. Do not use direct stream of
water. Wear self-contained breathing equipment in confined areas to avoid
inhalation of smoke or fumes. Water should be used to keep fire-exposed
containers cool.
45-499 Page: 2
UNUSUAL FIRE AND EXPLOSION HAZARDS
Fire-exposed containers should be cooled with water to prevent pressure build-up
which could result in container rupture. Isolate from heat, sparks, electrical
equipment and open flames. Vapors formed by this product may travel and be
ignited by sources distant from the handling or use point.
========================= SECTION V - REACTIVITY DATA ========================
STABILITY: STABLE
CONDITIONS TO AVOID
Excessive heat, sparks or open flames. Sparks, flames, excessive heat, poor
ventilation.
INCOMPATIBILITY (MATERIALS TO AVOID)
Strong oxidizing agents
HAZARDOUS DECOMPOSITION OR BYPRODUCTS
Thermal decomposition may yield carbon dioxide and/or carbon monoxide.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
===================== SECTION VI - HEALTH HAZARD DATA ========================
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Inhalation: May cause nasal and respiratory irritation, dizziness, weakness,
fatigue, nausea and headache. High concentrations may result in bronchitis and
convulsions. Its use in poorly ventilated areas can cause nausea, headache and
dizziness.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Eye contact: Severe irritation, redness, tearing and blurred vision. Skin
contact: Moderate irritation. Short-term contact will result in eye irritation.
Prolonged and repeated contact can cause a drying of the skin and irritation.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Skin absorption: May cause irritation, defatting and dermatitis. May cause skin
irritation.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Ingestion: May cause gastrointestinal irritation, nausea, vomiting and diarrhea.
Adverse health effects from ingestion may include irritation of the throat and
stomach lining. Not expected to be acutely toxic by ingestion.
HEALTH HAZARDS (ACUTE AND CHRONIC)
Acute: May cause eye, nose, respiratory tract and skin irritation,
headache,drowsiness and nausea. Ingestion may result in vomiting; aspiration
(breathing in) into the lungs may result in aspiration pneumonitis. Chronic:
Long term exposure may lead to central nervous system depression, dermatitis and
liver and kidney damage. Acute: May cause eye and skin irritation, nausea,
headache and dizziness. Chronic: Reports have associated repeated and prolonged
occupational over-exposure to solvents with permanent brain and nervous system
damage.
CARCINOGENICITY: NTP CARCINOGEN: Yes IARC MONOGRAPHS: Yes OSHA REGULATED: No
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
Pre-existing eye, skin and respiratory disorders may be aggravated.
EMERGENCY AND FIRST AID PROCEDURES
45-499 Page: 3
INHALATION: REMOVE TO FRESH AIR AND PROVIDE OXYGEN IF BREATHING IS DIFFICULT.
SPLASH (EYES): FLUSH EYES IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. SPLASH (SKIN): WASH AFFECTED AREAS WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHING. INGESTION: DO NOT INDUCE VOMITING. IF VOMITING OCCURS
SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUID INTO THE
LUNGS. GET MEDICAL ATTENTION IMMEDIATELY. INHALATION: MOVE PERSON TO FRESH AIR.
PROVIDE ARTIFICIAL RESPIRATION OR OXYGEN IF BREATHING IS DIFFICULT. EYE & SKIN
CONTACT: FLUSH EYES IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. WASH AFFECTED AREAS WITH SOAP AND WATER IMMEDIATELY. REMOVE
CONTAMINATED CLOTHING. INGESTION: IF SWALLOWED, DO NOT INDUCE VOMITING. GET
MEDICAL ATTENTION IMMEDIATELY.
============ SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE =============
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
PROVIDE VENTILATION. LARGE SPILLS MAY BE SCOOPED UP. SMALL SPILLS MAY BE PICKED
UP WITH ABSORBENT MATERIALS. ELIMINATE ALL SOURCES OF IGNITION. ABSORB WITH
INERT MATERIAL (SAND, VERMICULITE, ETC.), SWEEP OR SCOOP UP AND PUT IN DISPOSAL
CONTAINER. FLUSH AREA OF SPILL WITH WATER.
WASTE DISPOSAL METHOD
Place in tightly closed containers. Incinerate or dispose of in accordance with
local, state and federal regulations. Incinerate under safe conditions or
dispose of in accordance with local, state and federal regulations.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
Store away from heat, sparks and open flames. Keep containers tightly closed
when not in use. Use with adequate ventilation. COMBUSTIBLE! Keep away from
heat, sparks, and open flame. Avoid breathing vapors. Close container after each
use. Keep away from children.
OTHER PRECAUTIONS
Do not take internally. Avoid prolonged contact. Ground equipment to prevent
accumulation of static charge. Do not take internally. Avoid prolonged contact
with skin.
====================== SECTION VIII - CONTROL MEASURES =======================
VENTILATION
Adequate volume and pattern to keep air contaminant concentration below current
applicable OSHA or ACGIH's TLV limits. Local exhaust at point of use in closed
spaces.
RESPIRATORY PROTECTION
Use self-contained breathing apparatus where vapor concentration may be above
TLV limits. Where vapor does not exceed TLV limits, use NIOSH/MSHA approved
respirator. All purpose canister mask or air supplied mask, if TLV limits are
exceeded.
PROTECTIVE GLOVES
Chemical resistant gloves
EYE PROTECTION
Chemical goggles, safety glasses Safety glasses
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
Eye bath and safety shower
WORK/HYGIENIC PRACTICES
Wash hands thoroughly before eating or using the washroom. Smoke in smoking
areas only.
45-499 Page: 4
==================== SECTION IX - REGULATORY INFORMATION =====================
CALIFORNIA PROPOSITION 65
None
========================== SECTION X - DISCLAIMER ============================
The information contained herein is based on the data available to us and is
believed to be correct. However, NELSONITE POOL AND DECK COATING makes no
warranty expressed or implied regarding the accuracy of these data or the
results to be obtained from the use thereof. NELSONITE POOL AND DECK COATING
assumes no responsibility for injury from the use of the product described
herein.
|