DATASHEET
SAFETY
MATERIAL
CEEMICAL PRODUCT Al[D COMPAIIY IDENTIFICATION
SECTION 1:
February 24, 2000
PRODUCT: M-Prep Neutralj-zer 5A
MSDS # MGMO4SG
Measurements Group, Inc.
Post, Office Box 21777
Raleigh, NC 276LL
9 19 - 3 6 5 - 3 8 0 0
CHEMTREC 8OO-424-9300 (U. S. )
703-52'7-3887 (Outside U.S. )
numbers to be used only in the event of chemical
NOTE: CHEMTREC
exposure or accident
leak, fire,
emergencies involving a spill,
involving chemicals.
IDENTITY INFORMATION
SECTTON 2 : EMARDOUS INGREDIENTS /
I
CES NI'MBER CIIEII{ICAT TDENTTTY
<0.02
L336-2L-6 Ammonium Hydroxide
<0.05
760r_-54-9 Trisodium Phosphate
<0.01
1303-96-4 Sodium Tetraborate Pentahvdrate
'7732-18-5
Water
Distilled 9 9. 9 2
SECTION 3: IIEiAITH IIAZARD DATA
Routes Entry:
of
Inhalation: Skin: fngestion:
YES YES Accidental
(Acute and Chronic):
Eealth Eazards Ammonium hydroxide is irritating
and corrosive person may react to
to body tissues and a sensitized
even dilute soluti-ons.
Carcinogenicity: NTP: Not listed
IARC Monographs: Not listed
OSHARegulat.ed: Not listed
Signs and Slrnptoms of Exposure:
INEALATfON: May cause headache, coughing, and possible lung damage
(edema and difficulty in breathing). Excessive inhalation of vapors
1|
is irritati-ng
V to the mucous membranes of 1-he resniratory tract.
M-Prep Neutralizer 5A MSDS # MGM64BG
EYE coliIrACT: May cause possibre burning and reddening. Liquid
contact to the eye can be severely damaging and can result in loss of
vision.
SKIII COIITACT: May cause irritation, reddening, and possible burns.
rNGEsrroN: May cause possible burning sensation. rngestion is
corrosive to the digestive tract
preclude
Conditions Generally Aggravated by Exposure: from exposure
anyone with eye or pulmonary disease.
INEALATION: Remove to fresh air. If breathing is difficult have a
person administer
trained oxygen. Keep warm and at rest, and contact
physician promptly.
EYE CONTACT: Immediately flush with plenty of water for at least 15
minutes while holding the eyelids Contact physicj-an,
opeh. preferably
an ophthalmologist.
SKIN COIITACT: Flush with plenty of water while removing contamj-nated
clothing. wash affected area with soap and water. Launder
contaminated clothing before reuse. Seek medj-cal aid. if irritation
persists.
INGESTION: rf conscious, promptly give lots of water, dilute vinegar,
juices to drink,
or citrus followed by milk. Do NOT induce womiting.
Contact physician.
SECTION 5: FIRE A}ID E]
(Method Used):
Flash Point NONE
F1amnab]'e limits: LEL: N/A IIEL: N/A
Extinguishing Media: Will not support combustion.
Special Firefighting Procedures: Use m e d i a a p p r o p r i a t e to surrounding
fire condj-tions. Use cold water spray to control vapors and cool fire
exposed containers.
Unusual Fire and Explosion Hazards: When heated, materiaL will emit
anhydrous ammon:a vapor which necessitates respiratory and eye
protection for firefighting. Use protect.ive clothing.
SECTTON 5: ACCTDENTAI, RELEASE ME"ASURES
Steps to be taken if material is released or spilled: Ventil-ate area.
A b s o r b w i t h a b so rb e n t ma te ri a l. Neutralize with dilute acid. F1ush
s p i 1 l a r e a wi th p l e n ty o f w a ter .
MSDS# MGMO4SG
5A
M-Prep Neutralizer
E:(POST,RE CONTROTS -- PROTECTION
PERSONAI
7:
SECTION
For air contaminants abowe'TLV or permissible
Protection:
Respiratory
for organic vapors.
approved respirator
use NfOSH
limits
Ventilation:
TLV
Keep below
Local E:charrst:
TLV
Mechanical: Keep below
Spee5.al: N/A
Otber: N/A
gloves are recommended.
Neoprene or rubber
Protective Gloves:
goggles
safety are
Full face shield or chemical
Eye Protection:
recommended.
Rubber apron is recoflrmended.
or Equipnent:
Otber Protectiwe Clothing
in work area.
available
Safety shower and eyewash should be
practices.
Use good housekeeping Wash
tfork / nygienic Practices:
after use.
thoroughly
AI\TD STORAGE
8: HA}IDLING
SECTION
to be taken in bandling and storing: Store below BOoF
Precautions
(27"C) in dry p1ace. Keep containers tightly sealed.
vapors and direct contact.
Precautions: Avoid breathing
Otber
PH,YSICAL A}ID CNEMICAI, PROPERTIES
SECTION 9:
212"8 (10ooc)
Boiling Point:
Vapor Pressure (mmHg) 760 mmHg 100"C
: @
Vapor Density (Air = 1) : I.U
S p e c i f i c G r a vi ty (E O = 1 ): 1n
32oE (OoC)
MeJ.ting Point:
Rate (BuAc = 1) :
Evaporation <1
Volatile Organic Compounds: 0%
SolubiJ.ity in Water: 100t
Appearance and Odor: liquid;
Colorless mild ammonia odor.
M-Prep Neutralizer 5A MSDS # MGMO4BG
SECTION 10: STABTLITY A}ID REACTTVITY DATA
StabiJ.ity: Stable.
Conditions to Awoid: Adding Sodium Hydroxide this material
to and/or
heating will volatize Ammonia.
(l'taterials
rncompatibility to Avoid) peroxides,
: Acids, metallic
copper, tin, zlnc, and their alloys, halogenated compounds.
Eazardous Decomposition or By-products: None known.
Eazardous PoJ.ymerization: v[il1 not occur.
SECTION 11: TOXICOLOGICAI. INFORIIATION
Ammonj-umHydroxide
35 ppm ( S T E L )
OSHAPEL:
35 ppm ( s r E L )
ACGIH TLV:
OTHER: N/A
Trisodium Phosohate
OSHAPEL: Not establ-ished
ACGIH TLV: Not established
OTHER: N/A
Sodiurn Tetraborate PentahydraLe
OSHAPEL: Not established
ACGIH TLV: 1 mg/m'
OTHER: N/A
Dist.illed Water
OSHAPEL: Not established
ACGIH TLV: Not established
OTHER: N/A
SECTION l2z DISPOSAI CONSIDERATIONS
llaste Disposal Method: material with dilute
Neutralize absorbent
acid. Dispose of in accordance with local, state, and federal
requlations.
MSDS # MGMO4SG
5A
M-Prep Neutralizer
cr.Ass U}I NT'MBER
SEIPPING NI}IE
N.O.S.
Corrosive Liquids,
(Ammonium Hydroxj-de) 1,7 0
6
S E C T T O N1 4 : INFORIIATTON
REGUIATORY
SECTTON 313 SUPPTIER NOTIFICATION:
chemical or chemicals (as Iisted
This product contains a toxic below)
subject to the reporting of Section 31-3 Title
requirements III of the
Superfund Amendment and Reauthorization Act of I986 a n d 4 0 C F R P a r t
372.
tBv TVETGST
CAS NI'MBER CEEMTCAI" NA!!E
NONE
TSCA NOTIFICATION:
product
All this
components of listed in Toxic
are the Substance
( TSCA)
Co n t r o l Ac t C h e mi ca l S u b sta n ce Inventor y .
O
SECTION 15: OTHER INEORI'TATION
To the best of 'our knowledge, the j-nformation provided abowe meets the
requirements of the United States Occupational Safety and Health Act
under 29 CFR 191-0.1200 (gl (2) (c) (1) - (4)
and regulations established
for a mi-xture of hazardous chemicals which has not been tested as a
The data provided on this Material
whole. Safety Data Sheet is from
manufacturers of the original components. Measurements Group, Inc.
specj.fically disclaims any and al-l- form of liability and/or
responsibility for the application of this product.
PREPARED BY: R. Fridley
L.
DATE: February 24, 2000
5
|