MATERIAL SAFETY DATA SHEET (MSDS)
24 HOUR EMERGENCY PHONE: CHEMTREC 1-800-424-9300
Effective Date: Sept. 1, 2004 / Supersedes: Jan. 1, 2000 / PAGE 1 OF 2
JBS INDUSTRIES
2550 Henkle Drive - Lebanon, Ohio 45036
TELEPHONE: 1-888-745-0720
SECTION 1 PRODUCT & COMPANY IDENTIFICATION
PRODUCT NAME: CITRUSOLVE M-91-3 PRODUCT NUMBER: IJ-100
CITRUS SOLVENT DEGREASER
PRODUCT DESCRIPTION:
JBS Industries
MANUFACTURER: PHONE: 888-745-0720
2550 Henkle Drive FAX: 513-228-2810
Lebanon, Ohio 45036
SECTION 2 COMPOSITION / INFORMATION ON INGREDIENTS
HAZARDOUS INGREDIENTS: EFFECT CAS# PERCENT
CITRUS TERPENE SKIN & EYE IRRITANT 5989-27-5 0-70
2-BUTOXYETHANOL EYE IRRITANT 111-76-2 0-5
CORROSIVE TO EYES
QUATERNARY AMINE/MIXTURE 61789-77-3 0-25
HAZARDOUS INGREDIENTS: EXPOSURE LIMITS OF INGREDIENTS
OSHA PEL ACGIH TLV
CITRUS TERPENE NOT ESTABLISHED NOT ESTABLISHED
2-BUTOXYETHANOL 25 ppm (SKIN) 25 ppm (SKIN)
QUATERNARY AMINE/MIXTURE 400 ppm 400 ppm
SECTION 3 HAZARDS IDENTIFICATION
>>>>>>>>>>>>>>>>>>>>EMERGENCY OVERVIEW<<<<<<<<<<<<<<<<<<<
CAN BE CORROSIVE TO EYES. INHALATION OF MISTS MAY BE IRRITATING TO THROAT AND RESPIRATORY TRACT. MAY
CAUSE IRRITATION TO SKIN WITH PROLONGED EXPOSURE.
>>>>>>>>>>>>>>>>>>>>>>>>>>>><<<<<<<<<<<<<<<<<<<<<<<<<<<<<<
SECTION 4 FIRST AID MEASURES
FLUSH EYES WITH LARGE QUANTITIES OF WATER, HOLDING EYELIDS OPEN FOR AT LEAST 15
EYES: MINUTES. GET IMMEDIATE MEDICAL ATTENTION.
REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. SEEK MEDICAL
SKIN: ATTENTION IF IRRITATION PERSISTS.
INGESTION: GIVE WATER IF CONSCIOUS. DO NOT INDUCE VOMITING, ALTHOUGH VOMITING MAY OCCUR
NATUARALLY. GET IMMEDIATE MEDICAL ATTENTION.
INHALATION: MOVE TO FRESH AIR. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION.
SECTION 5 FIRE FIGHTING MEASURES
FLASH POINT: 110 F Flammable Limits: Not Determined
Flammability: COMBUSTIBLE
Fire Hazard: Combustible liquid and vapor. Keep away from heat, sparks and flame.
Fire-Fighting Procedures: Use alcohol foam, water spray or fog. Cool closed containers exposed to fire with water. Fire- fighters
should wear proper protective equipment.
SECTION 6 ACCIDENTAL RELEASE MEASURES
SPILLS & LEAKS: SMALL SPILLS: RINSE TO DRAIN.
LARGE SPILLS: CONTAIN FOR RECLAMATION OR DISPOSAL.
CAUTION: SPILLS OF THIS MATERIAL MAY CAUSE FLOOR TO BECOME SLIPPERY.
SECTION 7 HANDLING & STORAGE
PRODUCT SHOULD BE STORED IN ORIGINAL CONTAINERS AT TEMPERATURES BELOW 120 DEGREES F.
PRODUCT SHELF LIFE IS APPROXIMATELY 6 MONTHS.
SECTION 8 EXPOSURE CONTROLS / PERSONAL PROTECTION
EYES: WEAR CHEMICAL GOGGLES.
SKIN: SOLVENT PROOF GLOVES. RUBBER APRON IF GREATER EXPOSURE IS LIKELY.
RESPIRATORY: GOOD GENERAL VENTILATION. RESPIRATOR NOT NORMALLY REQUIRED.
MSDS - JBS INDUSTRIES (CONT.) CITRUSOLVE M-91-3 PAGE 2 OF 2
SECTION 9 PHYSICAL & CHEMICAL PROPERTIES
APPEARANCE & ODOR: THIN AMBER LIQUID WITH CHARACTERISTIC CITRUS ODOR.
SOLUBILITY IN WATER: EMULSIIES IN WATER
VAPOR PRESSURE: 0.3 kPa (1.9 mmHg) (at 20 C) BOILING POINT: 170 C (338 F)
VAPOR DENSITY: 4.7 (Air=1) SPECIFIC GRAVITY: 0.85 (Water=1)
PH FULL STRENGTH: n/a
SECTION 10 STABILITY & REACTIVITY
STABILITY: THIS IS A STABLE MATERIAL.
CONDITIONS TO AVOID: NONE KNOWN.
MATERIALS TO AVOID: STRONG OXIDIZING AGENTS.
HAZARDOUS POLYMERIZATION WILL NOT OCCUR.
SECTION 11 TOXICOLOGICAL INFORMATION
NO DATA AVAILABLE ON THIS MIXTURE. FOR INFORMATION ON INGREDIENTS, WRITE TO THE ADDRESS LISTED IN
SECTION 1 OF THIS MSDS.
SECTION 12 ECOLOGICAL INFORMATION
NO DATA AVAILABLE ON THIS MIXTURE. ALL SURFACTANT COMPONENTS ARE BIODEGRADABLE. THIS PRODUCT DOES
NOT CONTAIN PHOSPHATES.
SECTION 13 DISPOSAL CONSIDERATIONS
FOLLOW ALL FEDERAL, STATE, AND LOCAL REGULATIONS APPROPRIATE FOR THIS MATERIAL.
SECTION 14 TRANSPORTATION INFORMATION
D.O.T. HAZARDOUS MATERIAL CLASS: NOT A D.O.T. HAZARDOUS MATERIAL.
UN NUMBER: NOT APPLICABLE NA NUMBER: NOT APPLICABLE
SECTION 15 REGULATORY INFORMATION
THIS MATERIAL IS NOT SARA TITLE III REPORTABLE.
SECTION 16 OTHER INFORMATION
***HAZARD RATINGS PROVIDED FOR USE BY TRAINED INDIVIDUALS ONLY.***
HMIS RATINGS (0=MINIMAL, 1=SLIGHT, 2=MODERATE, 3=SERIOUS, 4=SEVERE HAZARD)
FOR CONCENTRATE: HEALTH: 1 FLAMMABILITY: 2 REACTIVITY: 0
NFPA RATINGS (0=MINIMAL, 1=SLIGHT, 2=MODERATE, 3=SERIOUS, 4=SEVERE HAZARD)
FOR CONCENTRATE: HEALTH: 1 FLAMMABILITY: 2 REACTIVITY: 0
The information relates to this specific material. It may not be valid for this material if used in combination with
any other materials or in any process. JBS Industries makes no warranty, express or implied as to the accuracy
or completeness or adequacy of information herein, except that such information is to the best of JBS Industries'
belief, accurate as of the date indicated. JBS Industries assumes no responsibility for injury from the use of the
product described herein.
JBS INDUSTRIES a Division of Mix Masters, Inc. 2550 HENKLE DRIVE LEBANON, OH 45036, 888-745-0720
|