MATERIAL SAFETY DATA SHEET
Section 1: IDENTIFICATION
VIRACLEAN
Recommended Use: Disinfectant Cleaner.
Product Code: 210556 (2x5L), 210555 (15L), 210564 (12X500mL Pump), 210574 (12X500mL Squeeze).
Whiteley Medical
A division of Whiteley Corporation Pty Ltd (A.C.N. 000 906 678)
Postal Address: P. O. Box 1076 North Sydney NSW 2059
Telephone Number: (02) 9929 9155 Facsimile: (02) 9929 9077
Emergency Telephone Number: Poisons Information Centre (National) 131126
Section 2: HAZARDS
Not classified as hazardous by the criteria of NOHSC.
Section 3: COMPOSITION INFORMATION
Ingredient CAS No Proportion
Proprietary Blend Not applicable 10-30%
Ingredients deemed not to be hazardous Not applicable To 100%
Section 4: FIRST AID
Hold eyelids apart and flush the eye continuously with running water.
Eye (Contact)
Remove contaminated clothing and flush skin and hair with running water.
Skin (Contact)
Remove to fresh air. The product is non volatile at room temperatures.
Inhalation(Breathing)
DO NOT induce vomiting. For advice, contact a Poisons Information
Ingestion (Swallowing)
Centre (Phone 131126) or a doctor.
Treat symptomatically for neutral detergent.
Advice to Doctor
Ensure an eye wash is available and ready for use.
First Aid Facilities
No aggravated medical conditions are known to be caused by exposure to
Additional Information
this product.
Section 5: FIREFIGHTING MEASURE
Solution does not burn. Use extinguishing media suited to the
Suitable Extinguishing Media
materials that are burning. eg. Dry chemical, CO2 or water spray
Carbon dioxide and carbon monoxide may be produced in the case
Hazards From Combustion
of fire or during thermal decomposition.
Products
Issue No. 9 Page 1 of 4
MATERIAL SAFETY DATA SHEET VIRACLEAN
Keep containers cool by spraying with water.
Precautions For Fire Fighters
and Special Protective
Equipment
Hazchem Code 鈥? Not applicable.
Additional Information
Section 6: ACCIDENTAL RELEASE MEASURES
SAA/SNZ HB76: Dangerous Goods 鈥? Initial Emergency Response Guide
Emergency Procedure
鈥? Not applicable.
Clean up personnel should wear full protective clothing. Restrict access
Spills / Clean up
until completion of clean up. Then ensure adequate ventilation. Stop leak
if safe to do so. Contain spill with absorbent material, such as towelling,
sand, vermiculite or other inert material. Prevent spill entering stormwater
drains or waterways. Collect and dispose of clean up material according
to local regulations. Wash away remnants with copious amounts of cold
water to sewer. Clean area by working from the periphery to the centre of
spill or from the edge of the room to the centre.
Section 7: HANDLING AND STORAGE
Contact Whiteley Corporation sales representative for advice
Precautions for Safe Handling
when using this product for any application other than that
outlined on the label or technical bulletin.
Any non-intended or non-authorised use of this product may
result in personal injury or damage to equipment.
Store product in original container.
Wash thoroughly after handling product.
Store in a cool, dry, well ventilated area. Keep container tightly
Conditions for Safe Storage
sealed. Store below 25oC.
Section 8: EXPOSURE CONTROL/PERSONAL PROTECTION
National Exposure Standards 鈥? Source: National Exposure Standards for Atmospheric
Contaminants in the Occupational Environment [NOHSC:1003].
Ingredient CAS No ES-TWA ES-STEL
None available
Not available.
Biological Limit Values
Use only in a well ventilated area.
Engineering Controls
Eye/face protection 鈥? Safety glasses / face shield / chemical
Personal Protective Equipment
resistant goggles should be worn to prevent eye contact.
Skin protection 鈥? Use Nitrile gloves or similar to prevent skin
contact.
Respiratory protection 鈥? Respirator is not usually necessary
but if required use a respirator suitable for organic vapours.
Section 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point approximately 100oC
Appearance Clear pink liquid
Freezing Point approximately 0oC
Odour Slight Lemon odour
pH 7.00-7.40 Solubility Soluble in water.
Issue No. 9 Page 2 of 4
MATERIAL SAFETY DATA SHEET VIRACLEAN
Specific Gravity 0.985-0.995 Flash Point Not Applicable.
Vapour Pressure Not Available. Upper and Lower Flammability limits (in air) Not
Applicable.
Vapour Density Not Available. Ignition Temperature Not Applicable.
Section 10: STABILITY AND REACTIVITY
Stable for period of shelf-life when stored as directed.
Chemical Stability
Avoid high temperatures (store below 25oC). Do NOT
Conditions to avoid
store in direct sunlight. Protect against physical damage.
None known. Do not mix with other chemicals.
Incompatible materials
None known.
Hazardous decomposition products
None known.
Hazardous reactions
Section 11: TOXICOLOGICAL INFORMATION
HEALTH EFFECTS
Acute
Considered an unlikely route of entry in commercial / industrial environments. May
Swallowed
be irritating to gastro-intestinal tract.
May cause irritation and reddening.
Eye
May cause irritation.
Skin
May cause irritation if aerosol inhaled.
Inhaled
Chronic
No effects known.
Swallowed
No effects known.
Eye
No effects known
Skin
No effects known.
Inhalation
TOXICITY DATA
Not available.
Section 12: ECOLOGICAL INFORMATION
Not available.
Ecotoxicity
Not available.
Persistence and degradability
Not available.
Mobility
Section 13: DISPOSAL CONSIDERATIONS
Disposal to sewer is normally recommended with copious amounts of water.
Disposal method
Refer to State/Territory Land Waste Management Authorities if applicable.
Containers are recyclable and can be disposed of by a licensed waste
contractor. Containers can be disposed of to general waste or rinsed
thoroughly and recycled.
Issue No. 9 Page 3 of 4
MATERIAL SAFETY DATA SHEET VIRACLEAN
Suitable for incineration by approved agent.
Special precautions
Section 14: TRANSPORT INFORMATION
Not classified as Dangerous Goods by the criteria of the Australian Dangerous Goods Code (ADG
Code).
Not applicable.
UN Number
Not applicable.
UN Proper Shipping Name
Not applicable.
Class and subsidiary risk
Not applicable.
Packing Group
Special precautions for user Not applicable.
Not applicable.
Hazchem Code
Section 15: REGULATORY INFORMATION
Poisons Schedule (SUSDP): Not applicable.
All ingredients are listed in the Australia Inventory of Chemical Substances (AICS).
Section 16: OTHER INFORMATION
G. Probert 22 February 2006
Prepared by: Date of preparation:
National Operations Manager
Position:
漏 This document remains property of Whiteley Corporation Pty Ltd.
Alterations are not permitted without prior written authorisation from Whiteley
Corporation Pty Ltd.
Issue No. 9 Page 4 of 4
|