Permatex, A Brand of ITW Devcon
30 Endicott St.
Danvers, MA 01923 USA
Telephone: 978-777-1100
Emergency: 800424-9300
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: 2C FORM-A-GASKET #2 SEALANT 11OZ
Item No: 80011
Product Type: Sealant
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredients Percent ACGIH 8 Hr. TWA: OSHA 8 Hr. TWA:
2 mg/m3 dust 10 mg/m3 dust; 5 mg/m3 respir.
KAOLIN 50-60
1332-58-7
VEGETABLE OIL 15-25 Not Listed Not Listed
68187-84-8
15 mg/m3 total dust; 5 mg/m3
ROSIN 10-20 sensitizer; reduce exposure to as
8050-09-7 low as possible respir.
400 ppm TWA; 983 mg/m3 TWA
2-PROPANOL 10-20 400 ppm TWA
67-63-0
0.1 mg/m3 TWA respirable 0.1 mg/m3 TWA respirable
SILICA, QUARTZ 0.1-1.0
14808-60-7
3. HAZARDS IDENTIFICATION
May cause eye, skin and respiratory irritation. Oral LD50 greater than 5000 mg/kg.
Toxicity:
Eye and skin contact, ingestion, inhalation.
Primary Routes of Entry:
Signs and Symptoms of Exposure: Excessive accidental exposure may cause headache, dizziness, nausea and mild respiratory irritation.
Overexposure may cause eye and skin redness.
Ingredients Percent NTP: ACGIH IARC:
Carcinogens
SILICA, QUARTZ 0.1-1.0 Known Carcinogen Not known Group 1; Vol. 68; 1997
14808-60-7
Medical Conditions Recognized as Preexisting eye, skin and respiratory disorders may be aggravated by overexposure to this product.
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapors. Oxygen or artificial respiration if needed.
Inhalation:
Obtain medical attention.
Wash off immediately with soap and plenty of water removing all contaminated clothes and shoes If
Skin Contact:
skin irritation persists, call a physician
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
Does not apply. Per ASTM D4359 this product is a solid.
Flash Point (掳F/C):
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus. Water spray
Special Fire-Fighting Procedures:
may be ineffective on flames but should be used to keep fire-exposed
containers cool.
Aldehydes, Oxides of carbon. Carboxylic acids
Hazardous Products Formed by Fire or Thermal
Decomposition:
Closed containers may rupture or explode when exposed to extreme
Unusual Fire/Explosion Hazards:
heat.
2
Lower Explosive Limit:
12
Upper Explosive Limit:
1 of 3
Product name: 2C FORM-A-GASKET #2 SEALANT Item 80011
11OZ
6. ACCIDENTAL RELEASE MEASURES
Eliminate all sources of ignition. Maintain good ventilation. Take up with an inert absorbent. Store in a
Spill Procedures:
closed waste container until disposal. Residues may be cleaned up with isopropyl alcohol.
7. HANDLING AND STORAGE
Store away from heat, sparks or open flame. Do not store at temperatures above 120 degrees F.
Storage:
Avoid contact with skin and eyes. Do not inhale vapors. Keep container closed when not in use.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses.
Eyes:
Rubber or plastic gloves
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits during the use of this product.
An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Black paste
Appearance:
ALCOHOLIC
Odor:
180 degrees F.
Boiling Point (掳F):
Does not apply
pH:
Partial
Solubility in Water:
1.5
Specific Gravity:
12.7% by weight
VOC Content(Wt.%):
33 mm Hg @ 68 degrees F.
Vapor Pressure:
2.07
Vapor Density (Air=1):
7.7 (ether = 1)
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
Will not occur
Hazardous Polymerization:
Strong oxidizers.
Incompatabilities:
Keep away from heat, sparks and open flame.
Conditions to Avoid:
Aldehydes, Oxides of carbon. Carboxylic acids
Hazardous Products Formed by Fire or Thermal
Decomposition:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
Unrestricted
DOT Shipping Name:
NONE
Hazard Class:
None
UN/ID Number:
None
Marine Pollutant:
IATA
not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/NA Number:
IMDG
2 of 3
Product name: 2C FORM-A-GASKET #2 SEALANT Item 80011
11OZ
Unrestricted
Proper Shipping:
None
Hazard Class:
None
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
SARA 313 Information
NONE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present at or above the No Significant Risk Level.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 1 , REACTIVITY 0
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Health and Safety Manager
Prepared By: Revision Date: 01/29/2004
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 3
Company: Revision
06106 Number:
Telephone Number: 1-87-Permatex (877) 376-2839
3 of 3
|